You are on page 1of 11

Document Title

Security Level

RRU3829

2.1 RRU Functions


This section describes the main functions of the RRU. The RRU performs the following functions: l Receives downlink baseband data from the BBU and sends uplink baseband data to the BBU. l Receives RF signals from the antenna system, down-converts the signals to intermediate frequency (IF) signals, amplifies the IF signals, and performs analog-to-digital conversion. The transmit (TX) channel filters downlink signals, performs digital-to-analog conversion, and up-converts RF signals to the TX band. l Multiplexes receive (RX) and TX signals on the RF channel, which enables these signals to share the same antenna path. It also filters the RX and TX signals. l The RRU has a bilut-in Bias Tee (BT). The internal BT couples RF signals and OOK signals and transmits them through the TX/RX port A. The internal BT also supplies power to the tower mounted amplifier (TMA). l The RRU can be powered by the AC/DC power module. The RRU is called AC RRU. For details about the AC/DC power module, see the AC/DC Power Module User Guide.

2.2 RRU Exterior


This section describes the exterior and dimensions of an RRU. Figure 2-1 shows an RRU. Figure 2-1 RRU exterior

2012-07-12

Huawei Proprietary - Restricted Distribution

Page1, Total11

Document Title

Security Level

Figure 2-2 shows RRU dimensions.

2.3 RRU Ports


This section describes RRU ports positioned on the RRU panels. An RRU has a bottom panel, cabling cavity panel, and indicator panel. Figure 2-3 shows RRU ports on the panels.

2012-07-12

Huawei Proprietary - Restricted Distribution

Page2, Total11

Document Title

Security Level

Table 2-1 describes RRU ports and indicators on the panels.

2012-07-12

Huawei Proprietary - Restricted Distribution

Page3, Total11

Document Title

Security Level

RRU3829 Technical Specifications

An RRU3829, which is a remote radio unit for UMTS, supports a maximum of four carriers.

Supported Modes and Frequency Bands


Table 1 lists the modes and frequency bands supported by an RRU3829. Table 1 Modes and frequency bands supported by an RRU3829

2012-07-12

Huawei Proprietary - Restricted Distribution

Page4, Total11

Document Title

Security Level

Type

Mode

Frequency Band (MHz)

RX Frequency Band (MHz) 1920 to 1980

TX Frequency Band (MHz) 2110 to 2170

RRU3829

UMTS

2100

RF Specifications
Table 2 lists radio frequency (RF) specifications of an RRU3829. Table 2 RRU3829 RF specifications

Type

RX and TX Channel

Capacity

Receiver Sensitivity (dBm) Receiver with One Antenna Receiver with Two Antennas -128.9 Receiver with Four Antennas -131.6

Power

Power Consumption

Sensitivity Sensitivity Sensitivity

RRU3829 2T2R

With MIMO: 4 carriers Without MIMO: 6 carriers

-126.1

Output power of RRU3829 without MIMO Output power of RRU3829 with MIMO Output power of RRU3829 in combined configuration

DBS3900 power consumption (RRU3829 without MIMO) DBS3900 power consumption (RRU3829 with MIMO)

NOTE: The receiver sensitivity is measured, as recommended in 3GPP TS25.104, at the antenna connector over the full band on condition that the channel rate reaches 12.2 kbit/s and the bit error rate (BER) does not exceed 0.001. RRU3829s with MIMO and without MIMO support four carriers and six carriers, respectively. The output power at its antenna port is 2 x 60 W. NOTE:

2012-07-12

Huawei Proprietary - Restricted Distribution

Page5, Total11

Document Title

Security Level

Configurations of single-output, multiple-input multiple-output (MIMO), or combination of the two are supported. Uneven power configuration is supported. Table 3 Output power of RRU3829 without MIMO

Number of Carriers Related Number of Carriers Related to Power Amplifier 1 1 2 3 4 1 2 3 0 0 0 0 1 2 3 to Power Amplifier 2

Output Power per Carrier (W) 60 30 20 15 60 30 20

Table 4 Output power of RRU3829 with MIMO

Number of Carriers 1 2 3 4 50+50 30+30 20+20 15+15

Output Power per Carrier (W)

Table 5 Output power of RRU3829 in combined configuration

Number of MIMO Carriers 1 2 3


2012-07-12

Number of Single-Output Carriers 5 4 2

Huawei Proprietary - Restricted Distribution

Page6, Total11

Document Title

Security Level

NOTE: In combined configuration, each TX channel of the RRU3828 supports a maximum of four carriers. The maximum output power is 60 W. Table 6 DBS3900 power consumption (RRU3829 without MIMO)

Configuration (Carrier x Sector)

Output Power per Carrier (W)

Typical Power (W)

Maximum Power (W)

Power Backup Duration Estimated Based on Typical Power Consumption of New Batteries (Hours) 50 Ah 92 Ah 9.5 7.9

Consumption Consumption

31 32 NOTE:

20 20

454 550

529 691

4.7 3.8

Typical power consumption refers to the power consumption when the base station runs with 40% load at the 25C ambient temperature. Maximum power consumption refers to the power consumption when the base station runs with 100% load at the 25C ambient temperature. In 3 x 1 or 3 x 2 configuration, one WBBPd2 board and one WMPT board are configured. Table 7 DBS3900 power consumption (RRU3829 with MIMO)

Configuration (Carrier x Sector)

Output Power per Carrier (W)

Typical Power (W)

Maximum Power (W)

Power Backup Duration Estimated Based on Typical Power Consumption of New Batteries (Hours) 50 Ah 92 Ah 4.1 3.2

Consumption Consumption

32 33 NOTE:

20+20 20+20

932 1152

1214 1557

2.0 1.5

2012-07-12

Huawei Proprietary - Restricted Distribution

Page7, Total11

Document Title

Security Level

Typical power consumption refers to the power consumption when the base station runs with 40% load at the 25C ambient temperature. Maximum power consumption refers to the power consumption when the base station runs with 100% load at the 25C ambient temperature. In 3 x 2 configuration, two WBBPd2 boards and one WMPT board are configured. In 3 x 3 configuration, three WBBPd2 boards and one WMPT board are configured.

Engineering Specifications
Table 8 lists the engineering specifications of an RRU3829. Table 8 Equipment specifications of an RRU3829

Type

Input Power

Dimensions (H x W x D)

Weight

RRU3829

-48 V DC; voltage range: -57 V DC to -36 V DC

480 mm x 270 mm x 40 mm (without the housing and connectors) 485 mm x 300 mm x 170 mm (with the housing)

20 kg (without the housing) 22 kg (with the housing)

Table 9 lists the environmental specifications of an RRU3829. Table 9 Environmental specifications of an RRU3829

Type

Operating Temperature

Relative Humidity 5% RH to 100% RH

Absolute Humidity (1 to 30) g/m


3

Atmospheric Pressure 70 kPa to 106 kPa

RRU3829

-40C to +55C (without solar radiation) -40C to +50C (with solar radiation)

Table 10 lists the compliance standards for an RRU3829.


2012-07-12 Huawei Proprietary - Restricted Distribution Page8, Total11

Document Title

Security Level

Table 10 Compliance standards for an RRU3829

Type

Operating Environment

Anti-seismic Performance NEBS GR63 zone4

Protection Rating

RRU3829

Standards: 3GPP TS25.141 V3.0.0 ETSI EN 300019-1-4 V2.1.2 (2003-04) Class 4.1: "Non-weatherprote cted locations"

IP65

Table 11 lists the surge protection specifications of ports on an RRU3829. Table 11 Surge protection specifications of ports on an RRU3829

Port

Usage Scenario

Surge Protection Mode

Specifications

DC power port

Applicable to Surge all scenarios

Differential mode Common mode

2 kV (1.2/50 s)

4 kV (1.2/50 s)

Surge current

Differential mode Common mode

10 kA

20 kA

Antenna port

Applicable to Surge all scenarios current

Differential mode Common mode

8 kA

40 kA

Port for RF module cascading


2012-07-12

Applicable to Surge all scenarios

250 A

Huawei Proprietary - Restricted Distribution

Page9, Total11

Document Title

Security Level

Table 11 Surge protection specifications of ports on an RRU3829

Port

Usage Scenario

Surge Protection Mode

Specifications

RGPS port

Applicable to Surge all scenarios current

Differential mode Common mode

3 kA

5 kA

RET antenna port

Applicable to Surge all scenarios current

Differential mode Common mode

3 kA

5 kA

Dry contact or Applicable to Surge RS485 alarm port all scenarios current

Differential mode Common mode

3 kA

5 kA

Local power monitoring and alarm port

Monitored power and RRUs are installed in back-to-back mode or within 1 m.

Surge

250 A

Antenna Capability
Table 12 lists the antenna capability of an RRU3829. Table 12 Antenna capability of an RRU3829

Type RRU3829 NOTE:

TMA Support Supported

RET Antenna Support AISG2.0

2012-07-12

Huawei Proprietary - Restricted Distribution

Page10, Total11

Document Title

Security Level

For RRUs supporting RET antennas, the feeding voltage is 12 V and feeding current is 2.3 A.

2012-07-12

Huawei Proprietary - Restricted Distribution

Page11, Total11

You might also like