You are on page 1of 1

Installation Instructions P.N.

733647 Adjustable Electric Fan Thermostat


The adjustable fan thermostat allows the user to custom tailor the turn-on temperature. Factory preset at 160 degrees, adjustment range is 150240 degrees. Note: Before starting installation, read instructions completely and disconnect battery. Fan Control Module Installation The fan control module must be mounted in a cool, dry location, away from hot components. The temperature probe wires are 18 long but can be lengthened to allow mounting the control box further from the radiator. When lengthening probe wires use good quality connectors and wire. 1. Using mounting feet on fan control module as a guide, mark and drill two 5/32 holes. 2. Use the two #10 metal screws provided top mount the control module. Wiring Red: Attach to positive (+) side of battery. Orange: Attach to fan positive (+) lead. Blue: When using dual fans, attach to second fan positive (+) lead. Yellow: Attach to an ignition switched 12-volt source. If this wire is hooked up to a constant source (like the battery) the fan will continue to run after the vehicle is shut off and could run down the battery. Green: Attach to positive (+) wire on air conditioning clutch. This runs fan whenever the AC is on. Black: Attach to a good chassis ground. Do the same with the ground lead off the fan motor.

Temperature Probe Installation 1. The temperature probe must be inserted into the radiator core between the fins. The best location is close to the water inlet on the radiator tank. 2. The probe should fit tightly in the radiator fins and should not extend past radiator core. This will not affect operation. Note: Do not use sharp objects to install temperature probe. Do not install probe in radiator water or radiator hoses. Water will damage temperature probe. Temperature Adjustment 1. Turn adjustment pot counter clockwise to lower fan turn-on temperature. 2. Turn adjustment pot clockwise to raise fan turn-on temperature. 3. Adjustment range is of a turn. Do not force past stop. Insure vehicle is up to operating temperature before adjusting.

350163

080807

You might also like