Professional Documents
Culture Documents
Antenna Units
Gain and size
(Antenna size (m 0.2 0.3 0.6 1.2 1.8 2.4 3.0 3.7 32.0 37.0 41.0 43.1 45.1 47.3 36.0 41.8 45.3 47.7 49.7 32.1 36.6 42.7 46.4 48.7 34.4 39.2 44.6 48.5 (Frequency range (GHz 7/8 13 15 18 23 31.8 36.2 40.0 46.0 49.5 26 33.8 37.3 41.5 47.1 28 34.6 38.0 42.4 47.9 32 35.4 38.8 43.5 49.0 38 37.5 40.4 44.3
Antenna Units
3 dB Lobe width
-3 dB -3 dB
&re'(ency band
" *+, *+, 13 *+, 1- *+, 1 *+, 23 *+, 26 *+, 3 *+,
0.3
. . . !.2 3./ 3 2.1.6
)ntenna 0.6
!.2 3./ 2. 2.2 1.1.3 0.
Different
hresho!ds
RAU
RAU. / F
"#es
.0 "echanical design which is - or 2 /0 ""U %o!$atibilit& and ca$acit& 1 2,lan340 "ediu! ca$acit& RAU %o!$atible with %5678, su$$orts 292 to 3:92 in a range of ; to 3< ='* li3e RAU2 23 1 2>40 'igh ca$acit& radio units 7u$$orts -)) "bit s ca$acit& using -2< 5A" li3e RAU- > < 1 2?40 Agile %o!$atible with %5678, -6 5A" and -2< 5A" and su$$orts 292 -)) "bit s li3e RAU2 ? 23
to
F0 Fre(uenc& band
RAU
$-12#3
425+0
161)M
425+0
12 1)M
4#5+0
; ='* < ='* -3 ='* -) ='* -< ='* 23 ='* 26 ='* 2< ='* 32 ='* 3< ='*
; ='* < ='* -3 ='* -) ='* -< ='* 23 ='* 26 ='* 2< ='* 32 ='* 3< ='*
; ='* < ='* -3 ='* -) ='* -< ='* 23 ='* 26 ='* 2< ='* 32 ='* 3< ='*
RAU
The received signal strength is co!$ared to a $reset value The far end trans!itter is ordered to ad@ust the out$ut $ower, u$ or down, in order to !eet the target ,enefits0 1 Anterference reduction 1 Reduced $ower consu!$tion 7etting is done in ""U and usuall& the $ower is set in 316 d, above threshold
er$ina! 'onfi(urations
161 +ot #tand-by
-B- 'ot 7tand1b&0 A!$roved availabilit& b& hardware redundanc& - radio channel - trans!itter is active T. switch on hardware alar! 2 radios receiving - Receiver selected as active Receiver switch on hardware alar!
er$ina! 'onfi(urations
'ot 7tand1b& and 7$ace #iversit&
'ardware availabilit& i!$rove!ent A!$roved radio $ath $erfor!ance b& receiver switching on radio $ro$agation alar! 1 "ulti1$ath fading 1 Reflection hC<0 f D='*E Usuall& alar! will ha$$en when signal is -0 d, !ore than threshold %onsider wind load
er$ina! 'onfi(urations
For3ing 7tand1b& and fre(uenc& diversit&
2 radio channels
A!$roved availabilit& b& hardware redundanc& A!$roved $ro$agation $erfor!ance G"ulti1$athH #oesnIt effect ground reflection 2 radio channels 2 radio trans!itting, 2 radio receiving - receiver selected as active Receiver switch on hardware and $ro$agation alar! f2C-.0) f-
Different 'onfi(urations
)*+ er$ina! Mountin(
Different 'onfi(urations
)*) er$ina! Mountin(
Different 'onfi(urations
&ower ,#!itters
As&!!etrical 6ower 7$litter G-B- 'ot 7tand b&H
d, loss ; d, loss
3 d, loss 3 d, loss
Indoor Units
Access Ter!ination Unit GATUH Access "odule "aga*ine GA""H with $lug1in units0 1 Jthernet Anterface Unit GJTUH, o$tional 1 >ine Ter!ination Unit G>TUH, o$tional 1 "ode! Unit G""UH 1 ?ode 6rocessor Unit G?6UH 1 6ower Filter Unit G6FUH 1 7witch "ulti$le9er Unit G7"UH, o$tional
AMM -#
7uitable for end sites and re$eater sites "a9 2 radio units Fitted in a rac3 or a wall $ower su$$l& is integrated with ?6U2 G1:< or B2:H
AMM .#
7uitable for !ediu! si*e hub sites "a9 ) radio ter!inals Filled with ?6U <92, ""U K >TU G-692H For -B-, ""Us should be ad@acent and starting at even slots 1:<v connected to 6FU G2: needs #%1#% 3itH
AMM -+#
7uitable for large si*e hub sites GAntersection of o$tical networ3 and !icrowave networ3 ?6U <92, one or two 6FU $rotected $airs in a -B- configuration are $ositioned in ad@acent slots starting with an even slot nu!ber FAU- is fitted on to$ of the A"" A"" 20$ is $ower su$$lied b& 1:< L #% connected to 6FU or A%F Using 2: L #% needs #% #% 3it
7282 )MM 2p )dd:drop possibility of !;<1 traffic 8#= port for on site management
728 ;2 )MM 6p and )MM 20p )dd:drop possibility of ;<1 traffic 3 relay (ser o(tp(ts: 3 relay (ser inp(ts
Traffic handling and node central $rocessor 7&ste! control and su$ervision J!bedded #%? router and ele!ent !anager 7?"6 "aster Agent -0,A7J1T Jthernet interface for connection to a site >A? 7torage and ad!inistration of inventor& and configuration data
MMU
0Line
er$ination Unit (L U
>?8 12;2 8sed in )MM 2p@ when ! <1 of 728 is not eno(gh@ 120 ohm balanced >?8 16;2 8sed in )MM 6p and )MM 20p@ when <1 of 728 is not eno(gh@ 120 ohm balanced
2ower &ilter 8nit 1 42&810 2ower filter (nit for )MM 20p ?wo 2&81s config(red for red(ndancy +alf si,e to accommodate two (nits in one f(ll-height position )larm interface towards &)81 -! A 5$ inp(t
'onfi(uration e/a$#!e
)*+ A"" 6$ Add #ro$ 2 "bit s
'onfi(uration e/a$#!e
'onfi(uration e/a$#!e
)*)
'onfi(uration ru!es
)MM 20p
- 161 with MM82: #tarting at slots 2@ 6@ 1! or 1 - 161 with MM82=:$ #tarting at even slots e;cept for slot 12 - 161 M#2 #taring at even slots - 7o MM8 in slot 12 - 728 in slot 11 and 2&8 in 0 and 01
)MM 6p
- 161 with MM82: #taring at slot 2 - 161 with MM8 2=:$ #taring at slots 2 or ! - 161 M#2 #taring at slots 2 or ! - 728 in slot "
MINI-LINK 1'
UC:: !!
Traffic rate0 -)) B 2 "bit s ""U -)) -60 -6 5A" "odulation, )6 "'* ,andwidth ""U -)) -2<0 -2< 5A" "odulation, 2< "'* ,andwidth The !ain function of the ""U is to !odulate the 7T"1- +%13 digital data to an analogue signal suitable for !icrowave trans!ission and de!odulate the received signal fro! the RAU.
0 raffi% Unit ( RU
TRU J>
+ne TRU $er ter!inal in -B0 and -B- G2 TRU in -B- J>6H Ter!ination of traffic and +K" #%? J!bedded A6 router, Jle!ent "anager and ter!inal "A,
Interfa%es
5$ in ><5# B)8
2 Pole D-SUB
TNC
MM8 ?B8
9 Pole D-SUB
SC/SC
DIN 47297
9 Pole D-SUB
9 Pole D-SUB
9 Pole D-SUB
25 Pole D-SUB
1.0/ 2.3 mm
#?M-1 <l. #?M-1 Cpt. : C$-3 8ser %:C 6! 3bit:s A.11 CDM 10=)#<-? 6! 3bit:s *."03 &)7 )larm <1:?1
'onfi(uration e/a$#!e
)*)
'onfi(uration 2/a$#!e
)*) 2L&
'onfi(uration 2/a$#!e
)*) 2L&
DMR (Frequency/Distance/Capacity(
&re'(ency band *+, !.2 E 3.6 *+, -.0 E !.! *+, 6.! E -./ *+, ".1 E 6.! *+, "./ E ".1 *+, .3 E "." *+, 11." E 10." *+, 13.3 E 12." *+, 1-.3 E 1!.*+, 1/." E 1"." *+, 23.6 E 21.2 *+, 26.- E 2!.2 *+, 3/.- E 3".0 *+, 60
Note: Distan e !a"#es a$e a%%$o&imate and !a"id 'o$ ()edis* "imate
.)ntenna diam m 3." E 3.0 m 3.0 E 2.! m 3.0 E 2.0 m 3.0 E 2.0 m 3.0 E 0.6 m 3.0 E 0.6 m 3.0 E 0.6 m 2.! E 0.3 m 2.0 E 0.2 m 1. E 0.2 m 1.2 E 0.2 m 0.6 E 0.2 m 0.6 E 0.2 m 0.6 E 0.2
02ath length 4km km 6- E !0 km 60 E !0 km -- E 30 km -- E 30 km -0 E 1km !- E 1km 3- E km 30 E km 30 E km 20 E 2 km - E 0.km 3 E 0.1 km 1.- E 0.1 km 1 E 0.1
$apacity <! D #?M-1 <! D #?M-1 <! D #?M-1 <! D #?M-1 <1 - <! D #?M-1 <1 - <! D #?M-1 <! D #?M-1 <1 - <! D #?M-1 <1 - <3 D #?M-1 <1 - <! D #?M-1 <1 - <3 D #?M-1 <1 - <3 D #?M-1 <1 - <3 D #?M-1 <1 - <3