Cape Peninsula University of Technology - Department of Electrical Engineering Set by AA du Plessis
12V 5k6 3k3 6k8 R X V 1 V 2 ELECTRONICS 1 PRACTICAL 1 EQUIPMENT REQUIRED: 1. Oscilloscope and probes. 2. Breadboard. 3. Power supply and connectors. 4. 4 x Resistors: 1 x 5,6 k 1 x 3,3 k 1 x 6,8 k unknown resistor INSTRUCTIONS: Build the circuit shown and then do the following: 1. Calibrate the oscilloscope. 2. Set the power supply on 12 V using the oscilloscope. 3. Connect the 12 V to the circuit. 4. Calculate V 1 and write down the answer at results No. 1. 5. Now measure V 1 on the oscilloscope and write the answer at No. 2. 6. Now measure V 2 on the oscilloscope and write the answer at No. 3. 7. Calculate the value of the unknown resistor Rx and write it at No. 4. RESULTS: 1. Calculated value of V 1 = V 2. Measured value of V 1 = V 3. Measured value of V 2 = V 4. Calculated value of Rx =