You are on page 1of 2

2013 Thermaco, Inc.

All rights reserved Patented/Patents Pending Specifcations subject to change without notice
8/13 Thermaco, Inc. PO Box 2548 Asheboro, NC 27204-2548 Phone: (336) 629-4651 Online: www.trapzilla.com 1
Trapzilla

Solids Separators
A THERMACO Technology
TSS-70-SSA Specifcations
TECHNICAL DATA
Materials:
Maximum Inlet Flow Rate:
Solids Retention Capacity:
Rotationally Molded Polyethylene
75 GPM (4.73 l/s)
70 Gallons (265 l )
TOP VIEW
18.5 (47 cm) CLEARANCE FROM
TOP OF TANK REQUIRED FOR LID REMOVAL
Inlet Pipe
Outlet Pipe
TSS-70 UNIT
FEATURES:
Constructed of corrosion resistant
materials suitable for installation in
virtually any location.
Compact footprint.
Includes one SSOP-70/95 support stand
for above-ground installation.
2013 Thermaco, Inc. All rights reserved Patented/Patents Pending Specifcations subject to change without notice
8/13 Thermaco, Inc. PO Box 2548 Asheboro, NC 27204-2548 Phone: (336) 629-4651 Online: www.trapzilla.com 2
Trapzilla

Solids Separators
Install P trap on outlet connection
of tank.
DONT . . .
Reduce pipe size on outlet piping.
DO . . .
READ instruction manual included with
system before doing anything.
Install unit allowing for the minimum
clearances shown.
Make piping connections with rubber
No Hub connectors.
Keep outlet piping as straight as pos-
sible. Use only sweep connections.
Install vent on outlet piping.
If installing with other Trapzilla prod-
ucts, include cleanout ports between
each unit.
INSTALLATION INFORMATION
Suggested Minimum Footprint Dimensions
NOTE: Drawing for reference only. Equip-
ment must be installed in compliance with
all applicable laws, regulations and codes,
including plumbing codes. Installation should
be performed by a qualifed plumber.
A THERMACO Technology TSS-70-SSA Specifcations
Job Specifcation:
Solids separator(s) shall be Thermaco Trapzilla solids interceptor system(s) as manufactured
by Thermaco, Inc., Asheboro, North Carolina as noted on plans.
Separator Specifcations:
Furnish and install ___ Thermaco Trapzilla Model No. TSS-70-SSA, rotationally molded poly-
ethylene solids separator(s) for in-ground installation, rated at 75 gallons per minute (4.73 l/s)
peak fow, 70 gallons (265 l) of solids storage capacity, fully removable lid for vacuum access by
pump truck for solids removal, and including as an integral part of the unit a vessel vent. Included
support stand manufactured out of linear low-density rotationally molded polyethylene.
The Trapzilla

requires
6 (15.2 cm) of clearance
all the way around the
lid from walls or other
structures to allow for
servicing.

You might also like