Aleyandra University Ayala) deal
Faculty of Engincering re] Hasigh y's
Textile Engineering Department gets J a
Textile Quality Control PT FR IR ADS eas
Hime £3 how to sig ed
car
oe hela ighaayl ae
Part I
Answer the following questions
1. The following table represents data studying the effect of oil
viscosity (X) on the fretting wear of mild steel (Y):
x[9 [16 [20 [22 136
'¥ [180] 190 | 160 | 170 | 110
a. Construct a plot of the data. Does a linear regression model
appear to be plausible
b. Fita linear regression curve to the given data
¢. Predict the value of fretting wear when the viscosity is 30
(12 Marks)
It is required to estimate the proportion of ring spinning machines
Working with an efficiency higher than 92%, A group of 50
are found to have
machines is tested: whereas 35 mac
ficiencies higher than 92%. Construct a 95% confidence interval
for the population proportion. (10 Marks)
‘A process manufacturing ring spinning spindles is being controlled.
The performance characteristic to be taken is the tensile strength in
pounds per squace inch. Samples of size 3 each are taken every
mples are reported. The data obtained are shown in
hour and 3
the table below
fenumber;
7 si
and Committee
Examiners:Dr. SamaBy jase) Aaa
Haste Als
Alevandra University
Faculty of Engineering
extile Engineering Department a
Textile Engineering Departmen ety daha pA
Textile Quality Control Bye Pa ie I ET
Time : 3 hours oS Tre823)
3 year wens Ay jal) Abad
cela Tigh ae
Construct suitable contro! charts to control the mean value AND
h of the produced spindles.
the variability in the tensile str
(13Marks)
4. In order to produce a certain yarn, a roving is produced with 0.73
tums/inch and a standard deviation of 0.01 tums/inch. A sample of
50 roving spindles is tested and a mean number of tums/in of 0.72
is recorded. Test a ince level the hypothesis that the
population mean is 0.73 tums/inch against the altemative
hypothesis that the population me: ss than 0.73 tums inch
(10 Marks)
signi
Examiners:Dr. Samar Ahmed Mohsen and CommitteeAlexandria University
Faculty of Engineering,
Textile Engineering Department
January 2011
Quality Control in Textile TE323
3 “year
Time allowed: _1,3_Hr.
geal Sill aaa
2011 98
TE323 GUM ep
way ai
eed y dele: a3
Final Exam
mntrol part (1
ual
QI: Write briefly about the following terms: - [Give examples if possible]
L-R& D,
2-Sigma Level.
3-V.0.C
4-Intelligent Machine,
$-Destructive Tests,
6-Just-in-Time.
7- Scrap.
(10 Marks)
Q2: Introduce a TOM program to reach a zero defect approach at knitting
industry.
(10 Marks)
hall, a pareto diagram was presented to the members as
igure (1). The members had two opinions:
pinion: contro! defects A,B,and C
cts A and B only.
n do you support, and why?
ii-Develop Cause-and- Effect Diagrams of defects for your selected opinion?
(25Marks)
DEFECT VALUE'.
Where:
A: Weak se
E: defective packing.
. B: Skipped stitches, , C: knitting holes. . D: Oil spots
Dr. Sherien Elkateb and Dr.Samar Mohsen
ge T-1