Er246
B.Tech DEGREE EXAMINATION, APRIL/MAY 2009,
Fourth Semester
Mechanical Engineering
MACHINE DRAWING
‘Three hours ‘Maximum : 50 marks
Sketch is attached in a separate sheet,
sumed.
Missing Date may be suitably.
[Answer ALL questions,
1. Sketch neatly the conventional representation of
the following,
(a) A thresded rod of size M12 and thread length
30 mm,
() A single head key. o
2. Draw the 150 surface finish sy:nbol and explain,
o
3. Differentiate between clearance fit and transition
fit with practical example, 6)
4. Differentiate betwoen shaft basis and hole basis
system of tolerances, 6
5. Accompanying sketch show the details of a
SWIVEL BEARING. Assemble all the parts to support
fa shaft with ite axis 175 mm above the supporting
‘surface and draw the following views.
(a) Front view in half section. 20)
(&) Top viow in half soetion, the section being,
taken along the axis of the shaft. ao