Bullovak sesiens the ROTO-VAK to
provide maximum heat and mass transfer
Blade clearance, rotor speed, feed rate, wall thickness, and temperature difference are the
interrelated processing variables affecting heat and mass transfer for a given material,
XP blade and eva
VISCOSITY
‘This is the product parameter that dictates optimum blade clear
ance, rotor speed and feed rte because tis the factor that deter
nines shearate or Reynolds number High product shear isthe
bhsis for the high heat and mans ansfer ceeficients realized in
a Roto-Vak Newtonian materials with apparent stale viscosities
1 500,000 centipoisesar mow can be processed in « Roto-Vak.
‘Thixotroptematele that have apparent high viscosities are sac
cosa pct eas hybrid ncn Go
Limes by factor of 100) when subjected to high shear in the Roto
Yak After processing the material recover
is state viscosity.
BLADE CLEARANCE
Procise machining produces a normal blade clearance ina Roto-
Vak of 0060” 0400 inches A smal clearence betwoon the Sxed
orator wall ineeases product shear ehh fs a
sod racaste of est and mass trnsfee Tho swing blade option
Froies varying bled ck ‘suse for those applicn-
Hons where aligh overod rate is oxired
__— ROTOR SPEED
aD reas
enue
There so rng of acceptable rotor spends or any ven
and in general itisinvorsoly proportional to viscosity Tho optimum,
heat transfer coefficient is usually determined during pilot tests,
and is conditioned by power requirements and minimizing foam,
generation
MATERIALS OF CONSTRUCTION
Stainless stoel and high nickel alloys are normal materials of
‘construction, however a Roto-Vak can be fabricated from almost
‘any metal or metal alloy For units less than 35 sq.ft, solid plate
‘construction is utilized. Por larger units, the heating section is
"usualy alloy clad carbon sol to tako advantage ofthe economy
and high thermal conductivity afforded by carbon steel The mint
imum alloy thicknoss after machining is 100 inches.
‘TEMPERATURE DIFFERENCE
Processing in a Roto-Vak i a rapid, short residence time, single
nis ninemu back maxing high shear operation As contrase
‘rth shell and tube evaporators, higher wall tomporatures wits
Higher hea fixes can be uted without product gradation or
bharn on. A Roto-Vak can also operate at de same heat fix as a
hell and tube unt uta omer wal temporstres di toa highot
iat transfer cotficent