You are on page 1of 2

Chapter 7: Non-destructive Testing

Reference procedure

Measurement of the Optical Density of X-ray Films


Key words
optical density, film step tablet, X-ray film with graded optical densities

Quantities and items tested


Optical density, film step tablet, radiographs

Testing range

Uncertainty of results

0,2 up to 4,8

from

0,01

to

0,05

Fields of application
Verification and calibration of densitometers for measurement of the optical density on radiographs (X-ray films) in
industrial radiographic testing

Methodology and instrumentation


Traceable measurement of densities of X-ray films with a calibrated densitometer according to ISO 5-3 (diffuse
optical transmission density)

Qualification and quality assurance


Traceability to a reference standard of the National Institute of Standards and Technology (NIST) respectively a
calibrated step tablet of the Physikalisch -Technische Bundesanstalt (PTB).
The densitometer is checked and calibrated periodically by the above mentioned reference standards.

Contact:

Dr. Uwe Zscherpel

Phone:

+49 30 8104 3677

E-mail:

uwe.zscherpel@bam.de

Fax:

+49 30 8104 1837

Division 8.3: Radiological Methods

Date: Dec. 2012

back to Catalogue of Reference


Procedures

1(2)

704en.pdf

Reference procedure

Chapter 7: Non-destructive Testing

Further information
Flaws in technical installations or devices can be detected by differences in optical density of X-ray films/
radiographs.
It is therefore important that the optical density is defined and traceable to standards.
The optical density is measured by transmission of light through the film.
The optical density is defined by:

D lg

L0
LF

D = diffuse optical density


Lo = Luminance in cd/m2 (on the side of the light source before the film, diffuse)
LF = Luminance in cd/m2 (on the side of the observer, behind the film, specular)
The optical densities measured with a densitometer are traced back onto a NIST-standard respectively a density
step tablet calibrated by the PTB.
The density step tablets measured with the reference method Measurement of the optical density are used in
industrial radiography to check the densitometers and therefore for the quality assurance of the exposed x-ray
films, i.e. for a proof of the achieved density.
The measured density step tablets have to be recalibrated in certain intervals depending on national directives
(remeasurement of the optical density). The measurement results are summarized in a certificate.

Example for a measured density step tablet with certificate:

Date: Dec. 2012

2(2)

704en.pdf

You might also like