Professional Documents
Culture Documents
0314648
0310043
0308226
0314997
Ng Teng Wern
0315014
0314700
0310165
0315185
TABLE OF CONTENT
1.0 Introduction
2.0 Measured drawings
3.0 Structural drawings
4.0 Conclusion
5.0 Individual proposal
- Adeline Ting Yuh Chee
- Cheng Chen Liang
- Lee Run Sen
- Lim Fou Sing
- Ng Teng Wern
- Tan Kwok Seong
- Teo Kean Hui
- Tsai Wan Ching
1.0 Introduction
In a group of 8, we are required to obtain floor plan of a bungalow and carry out an
analysis on the structural framing and produce a set of structural drawings which
includes foundation plan, ground floor plan, first floor plan, second floor plan and roof
plan. Individually, each member has to propose an extension work of the bungalow
that does not exceed 100sq.m for each floor. This extended area should be framed
using structural members such as columns, beams, slabs and trusses. Next, we are
required to identify and analyze a minimum of 6 beams, 4 columns and the load acting
on it.
The case study that we have chosen is a 3 storey bungalow, which is located in
Hartamas Height, Kuala Lumpur. This bungalow is developed since early 2009 and
completed in late 2010. The built up area of a single unit is approximately 573.2 sq.m,
which includes a total of 332.91 sq.m built area and 240.29 sq.m covered exterior
area. This bungalow consists of sub-basement, ground floor and first floor. The interior
of this bungalow is made up of an entertainment room, living room, dining, kitchen,
bedrooms, guest room and study room; while the exterior consists of a swimming pool,
car porch and a yard.
A set of structural plan drawings are produced by the group, locations of columns and
beams are found through observation and analysis. Grid lines are then produced after
further developing and discussion with the tutor.