Candidate sk
Total No. of Questions : 5
Time
M1112010
MECHANICAL ENGINEER
First Paper
3 Hours|
Instructions to the candidates :
L
nw
There are five questions in this qu
to be answered. Each question has internal cl
The total number of marks is 300 and the time al
carry equal marks, unless specifically stated.
The first question will be of short answer typ
each one is to be answered in 3 or 4 lines
Questions should be answered exactly in order
enestion naner Answers to the various nartsAnswer all of the following questions in brief (in 3
(a)
(b)
tc)
(d)
fe)
Define the continuous beam and draw thi
Who developed the Simplex method in lir
Define quality control.
What is interferometer ? Where is it usec
What do you mean by tool signature ? Wri
ASA system,
The ratio of inside to outside diameter of a
is a solid shaft with same torsional strengt
outside diameter of hollow shaft to the 4
solid shaft ?(k)
a
(m)
(n)
(0)
Write the full form of PERT and CPM.
Where the worm and worm wheel is useful
worm and worm wheel that is not in the
What is whirling of shaft ? Why is stud)
required ?
Why are the lathe machine spindles mad
What is stress concentration ? From the st
view, show the safe design of a bolt, with
What is meant by break-even point ? Draw
answer.
Why is taper provided in a cotter ? What is t
provided in cotter for cotter joint ?2. ta)
ib)
4
Prove that in a bar uniformly taperi
diameter dy and length L, subjected to at
is given by :
4PL
nEd,d,
In meshanism as shown in Fig. 1,
crank,
as 600 rpm. Deternine the Hi
aod the angular velocity of the link BD
ae to the verte ‘Tie
are OA. 25 nua. AB = 44 mm. BC =
The centy distence between the centres 0
The path of travel of the slider 13 1] mn:
slider moves along a horizontai path antei
7
A horizontal beam, 30 m long, carries a ur
10 kN/m over the whole length and a cont
the right end. If the beam is freely support
position of the second support so that ben
should be as small as possible.
Draw the diagrams of shearing force and
the principal values.
Or
A gun metal rod screw at the ends passes
tube has 30 mm external diameter and 25
diameter of the rod is 22 mm. The assemt
the nuts on the rod are then screwed tight
tha Find the intensity af ctroce in rad andIn a manufacturing plant, one machine has
with a roller follower. The least radius of
roller radius is 18 mm. The angle for out
total lift is 20 mm. The cam shaft runs ¢
(@ Principal dimensions of the cam,
(i) The acceleration of the follower at
where the straight flank merge int
(iii) Acceleration of the follower at the aj
when the angle turned by cam m
when the roller is at the top of t
there is no dwell between outward(a)
(bi
A close-coiled helical spring has mean coil «
d and number of active turns N. The sprin;
rigidity G. Derive an expression for the defle
axial load W.
Design and draw a cast iron flange coupl
transmitting 80 kW at 200 rpm with the
Allowable shear stress in the shaft = 40 1
Permissible angle of twist < 1° in a lengt
Allowable shear stress in the coupling bol
Rigidity modulus of the shaft material =
Allowable shear stress for hub material =
You may adopt, width of key = 25 mm and(ce)
(a)
(b)
What is belt drive ? Classify the ope
V-belt drive ratio of the tensions in
Ty = elt0 cosee c
given by