Professional Documents
Culture Documents
Engineering Dynamics
Assignment 1
Answer all questions. Please submit your solution before 17 April 2015.
Question 1
The carriage, shown in the figure above, has a vertical slot that is driven in an
oscillatory manner. The carriages horizontal position as a function of time is x =
3sin(2t), where x is in cm and t is in seconds. This carriage in turn drives the motion
of pin A which is further constrained to move in the parabolic slot whose shape is
described by the function y = -x2, where the y coordinate also has units of cm.
Determine the overall velocity of pin A as a function of time.
Question 2
The angular speed of a 15 inch diameter circular saw blade is 1500 rpm when the
power to the saw is turned off. The speed decreases at a constant rate until the
blade comes to rest 15 seconds later. Determine the acceleration of a saw tooth, on
the circumference of the saw blade, 5 seconds after the power is turned off.
BTM2223
Engineering Dynamics
Question 3
Consider the following projectile motion of the ball shown in the figure above. The
initial velocity of the ball is vo = 30 m/s and it is thrown at an angle = 40o above
the horizontal. Find the maximum height H, the time it takes the particle to reach
point C, and the total horizontal range L that the particle travels
Question 4