Professional Documents
Culture Documents
Tulsa, OK 74132
Ph: 918-584-2220 Fax: 918-584-2221
Wrap calculations have taken into consideration all information provided on the Engineering Assessment and are subject to Citadel Technologies' Terms and Conditions.
The following calculations apply only to Citadel Technologies' products.
Case #:
DGPEC022912a
1097.39m; 5.59h
Owner Contact
Company
REPSOL
Name
DAVID BALDEON
Address
Quito Ecuador
joel.bernal@pec-ecuador.com
593-3-2380 658
Phone
Fax
= User Input
= Material Properties
Desired Pressure =
380 psi
Operating Temp. =
201 F
Number of
Plies =
0.333
Poisson's Ratio: =
0.196
E ac =
CB
0.6
Service Factor: =
Modulus:
Material
Used:
4,223,486 psi
Epoxy type:
0.09 in
OD of Pipe, D =
16.000 in
Diameter of Defect, d =
0.25 in
0.375 in
3,051,498 psi
1,000 psi
Shear Modulus: G =
88,780 psi
Toughness Parameter, =
2
2.5 in.-lb/in
0.01297
"
%
$
'
$
'
! LCL
ASME PCC2 Equation (13): P = fT f $
2
"
%
1!
"
) $ 3 d 4 + 1 d ' + 3 d 2 ''
$(
$ E
3
! & 64Gtmin '&
# 512tmin
#
ac
P=
Equation (17):
504.6 psi
!
$
E!t
Lover = max # 2.5 Dt / 2, a a repair &
"
"
%
L over =
Is # of Plies Acceptable?
4.90 in
2.5 Dt / 2 =
4.9003
Ea! atrepair
=
"
3.5624
Yes
4
plies of material and should extend a minimum of
4.90 inches from the defect on all sides.
Repair Recommendations:
(1) DW-HP-XM-1604HTA
(16 inch DiamondWrap HP 4-ply High Temperature Ambient 1 meter wide kit)
Installation Instructions: Wrap with 100% overlap for complete 4-ply repair. This kit will provide 1 meter of repair length and hold up to a .25
inch diameter through-wall defect no closer than 5 inches from the edge of the repair.
Note: The leak must be stopped prior to the installation of this repair kit. A warranty cannot be offered for components suffering from internal
corrosion. Citadel Technologies' products are not designed to stop crack propogation. Proper surface preparation is required to ensure adequate
bond strength to the substrate.
Project? (Yes/No)
Reviewed by:
Date: