Professional Documents
Culture Documents
DESCRIPTION: If the operator stops the truck with the handle stem in the fully lowered
position, the handle may bend due to uneven stop blocks.
REMEDY: The stop block on the right hand side of the handle pivot can be ground down to
eliminate the possibility of the handle stem bending.
FILING INSTRUCTIONS:
After completing (if change is necessary) place this Product
Improvement Notice in the service manual.
Return
PROCEDURES:
Figure 1
Carefully tape
this entire area
to prevent
metal grindings
from getting
into this entire
area.
Completely
tape off.
Using a 4 disc grinder and two new grinding discs, carefully grind away
7/16 from the cast block. See figure 2.
Figure 2
After carefully grinding away excess metal allow casting to cool. Using
compressed air or a vacuum, remove grindings from the handle pivot,
and remove tape.
Connect battery, turn on the truck and ensure proper truck operation
before returning to service.
Return