Professional Documents
Culture Documents
You may use whichever units you wish but you must be consistent, e.g. do not mix units of length or
time (metric units are provided as an example):
F: force applied to shackle [N]
t: cheek plate thickness (each) [mm]
C: total clearance between cheeks and eyes [mm]
C: total clearance between pin and hole [mm]
: maximum allowable stress in the padeye plate [MPa]
E: modulus of elasticity for padeye and cheeks [MPa]
WJF: weld joint factor []
T: thickness of padeye plate [mm]
R: outside radius of padeye [mm]
C: clearance between padeye and mating shackle [mm]
T: weld thickness (or leg) [mm]
: pin hole diameter [mm]
: shackle pin diameter [mm]
w: shackle width in between eyes [mm]
: shackle eye outside diameter [mm]#
C: shackle throat clearance inside bow [mm]
: shackle bow section diameter [mm]
B: bearing stress (incl. cheeks) [MPa]
b: bending stress (excl. cheeks) [MPa]
t: tensile stress (excl. cheeks) [MPa]
: shear stress (excl. cheeks) [MPa]
#Outside diameter of cheek plates need be no larger than outside diameter of shackle eye