[ASTM A325 OR A490 BOLTS 6377
Table 1. Nominal Hole Dimensions
ay | areal omar etoareal Core S
(oer | ay | twitnstangy | yaa etary
Ye %e % Nex Ye Nex 1%
% Me e Mex Mex te
% %e Se %ext Hex 1%
% Se Me ‘Sex 1M Sex 2s
1 M6 1% Mex 146, Mg x2
2% dt%e d+ Se (d+ Ye) x(O+%) (d+
@5xq)
In this expression:
R,= nominal strength of a bolt subject to axial tension or shear, kips
nominal strength from Table 2 for appropriate kind of load, ksi
A= area of bolt corresponding to nominal diameter, in.?
resistance factor from Table 2.
(b) Combined Tension and Shear Strength Limit State. In bearing connec-
tions in which the applied shear force is greater than ¥ the design shear
strength according to 4(a). the design strength in axial tension for A325
and A190 bolts is 6R, where:
R,
Eady (LRFD 4.2)
Where
jominal tension strength of a bolt subject to concurrent sheat. kips
jominal tension strength of a bolt as calculated by formulas in Table 3,
ksi
rea of bolt corresponding to nominal diameter, in?
= resistance factor equal to 0.75
In Table 3.,f, equals the shear force on the bolt in ksi.
o ag ama ETO
nected material for all bolis in a connection with two oF more bolts in the
line of force in standard, oversize, or short slotted holes when the edge dis-
tance in direction of force is not less than I'sd and the distance center to
center of bolts is not less than 3d is Ry, where:
Ry=24aih, (LRED 4.3)
‘The design bearing strength on the connected material for all bolts in a con-
nection with two or more bolts in the line of force in long slotted holes
perpendicular to the direction of force when the edge distance, L, is not
less than 14d and the distance center to center of bolts is not less than 34
is OR, where:
R= 200th, (RFD 44)
The design bearing strength on the connected material for the bolt nearest.
to the free edge in the direction of force when two or more bolts are in
the line of force in standard, oversize, or short slotted holes but with the
Asturucan INsTTTuTE OF STEEL. CONSTRUCTION