Professional Documents
Culture Documents
1
Single Phase uncontrolled Rectifier
Objective :
i)
Practically analyze the networking and the performance of a single phase rectifier
Equipment :
AC supply ,a diode(1N4007) ,resistor(1k),Oscilloscope, DMM, connecting wires
Procedure:
1. Adjust the supply voltage as used in design procedure. Recommended is 10
peak voltage at frequency of 50 HZ.
2. Arrange the circuit as shown in figure.
3. Record your observations and calculations in tabular form and also plot the
waveforms observed on oscilloscope.
4. Compare the practical output voltage with theoretical output voltage.
Performance parameters :
1. Peak output voltage =Vm=-----------2.
3.
4.
5.
6.
Average value of output voltage =V dc=0.318*Vm=-------------RMS value of output voltage =Vrms=0.5* Vm=--------------RMS value of output current =Irms=Vrms/R=-----------------Output DC power =Pdc=Vdc*Idc=-------------------Output AC power =Pac =Vrms*Irms=-----------------
Evaluate the following parameter (also write down the required formulae) :
1. Rectifier efficiency = =----------------------2. Form factor=------------------3. Ripple factor=-----------------Observe V0ut on the oscilloscope and sketch it on a graph paper
Conclusion :