Professional Documents
Culture Documents
Private Client
Private Client
Private Client
Asheville, NC 28804
Denise Trantham
denise.trantham@pacelabs.com
Project Manager
Enclosures
Page 1 of 9
#=CP#
CERTIFICATIONS
Project:
92293848
Page 2 of 9
#=SA#
92293848
Lab ID
Sample ID
92293848001
Analytes
Reported
Method
Analysts
Laboratory
SM 9222D
TEP
PASI-A
92293848002
Pearson Bridge
SM 9222D
TEP
PASI-A
92293848003
Azalea Park
SM 9222D
TEP
PASI-A
92293848004
Fletcher Park
SM 9222D
TEP
PASI-A
92293848005
SM 9222D
TEP
PASI-A
Page 3 of 9
#=AR#
ANALYTICAL RESULTS
Project:
92293848
Units
Report Limit
DF
Prepared
Matrix: Water
Analyzed
CAS No.
Qual
CFU/100 mL
1.0
Units
Report Limit
04/13/16 17:40
DF
Prepared
Matrix: Water
Analyzed
CAS No.
Qual
CFU/100 mL
1.0
Units
Report Limit
04/13/16 17:40
DF
Prepared
Matrix: Water
Analyzed
CAS No.
Qual
CFU/100 mL
1.0
Units
Report Limit
04/13/16 17:40
DF
Prepared
Matrix: Water
Analyzed
CAS No.
Qual
CFU/100 mL
1.0
Units
Report Limit
04/13/16 17:40
DF
Prepared
Matrix: Water
Analyzed
CAS No.
Qual
CFU/100 mL
1.0
04/13/16 17:40
Page 4 of 9
#=QC#
92293848
QC Batch:
WET/44227
Analysis Method:
SM 9222D
QC Batch Method:
SM 9222D
Analysis Description:
1709517
Matrix: Water
Fecal Coliforms
CFU/100 mL
SAMPLE DUPLICATE:
ND
1.0
Qualifiers
04/13/16 17:40
1709518
Parameter
Fecal Coliforms
92293649001
Result
Units
CFU/100 mL
ND
Dup
Result
RPD
Qualifiers
ND
Results presented on this page are in the units indicated by the "Units" column except where an alternate unit is presented to the right of the result.
Page 5 of 9
#=QL#
QUALIFIERS
Project:
92293848
DEFINITIONS
DF - Dilution Factor, if reported, represents the factor applied to the reported data due to dilution of the sample aliquot.
ND - Not Detected at or above adjusted reporting limit.
MDL - Adjusted Method Detection Limit.
PQL - Practical Quantitation Limit.
RL - Reporting Limit.
S - Surrogate
1,2-Diphenylhydrazine decomposes to and cannot be separated from Azobenzene using Method 8270. The result for each analyte is
a combined concentration.
Consistent with EPA guidelines, unrounded data are displayed and have been used to calculate % recovery and RPD values.
LCS(D) - Laboratory Control Sample (Duplicate)
MS(D) - Matrix Spike (Duplicate)
DUP - Sample Duplicate
RPD - Relative Percent Difference
NC - Not Calculable.
SG - Silica Gel - Clean-Up
U - Indicates the compound was analyzed for, but not detected.
Acid preservation may not be appropriate for 2 Chloroethylvinyl ether, Styrene, and Vinyl chloride.
A separate vial preserved to a pH of 4-5 is recommended in SW846 Chapter 4 for the analysis of Acrolein and Acrylonitrile by EPA
Method 8260.
N-Nitrosodiphenylamine decomposes and cannot be separated from Diphenylamine using Method 8270. The result reported for
each analyte is a combined concentration.
Pace Analytical is TNI accredited. Contact your Pace PM for the current list of accredited analytes.
TNI - The NELAC Institute.
LABORATORIES
PASI-A
ANALYTE QUALIFIERS
B
Page 6 of 9
#=CR#
92293848
Lab ID
Sample ID
QC Batch Method
QC Batch
92293848001
92293848002
92293848003
92293848004
92293848005
SM 9222D
SM 9222D
SM 9222D
SM 9222D
SM 9222D
WET/44227
WET/44227
WET/44227
WET/44227
WET/44227
Analytical Method
Analytical
Batch
Page 7 of 9
Page 8 of 9
Page 9 of 9