Professional Documents
Culture Documents
EX.NO: DATE:
Aim: To Simulate Half wave rectifier to observe the following waveforms by using PSIM.
(1) Output Voltage across R.
(2) Top and bottom waveforms of switch used(IGBT)
Requirements:
Procedure:
Steps to create Simulation Model using PSIM:
1. Click on File New.
2. Make/Model the circuit by placing all its Blocks from its corresponding Library/toolbox, which is
clearly shown in the table 1. Right click on the block to rotate mirror etc. to organize the circuit
elements.
3. To change the circuit parameters applicable to the block by double clicking on the block/element
and type the values. Keep the values default for some blocks like thyristor, diodes, mosfet etc.
4. To measure/observe the voltage across or current passes through the electrical block/device,
connect voltmeter blocks , it is available on the Elements/others/Probes/Voltmeter To observe the
waveform provide the clock from the simulate/simulation control provide time to observe the wave
form.
5. For Half wave inverter, components required and its parameter values tabulated in Table 1. The
schematic arrangement is shown in schematic diagram.
Schematic diagram: 1
Half wave inverter
G1
IGBT1
10u C1
vo 0 180.
V
R switch(IGBT1) is ON from 0-180.
Vin 100
switch(IGBT2) is ON from 180-360.
100k
G2
10u C2 IGBT2
180 360.
Output voltage and top, bottom(IGBT) Voltage waveform
Result:
A single phase half wave inverter model is created and analyzed the various waveforms by using
PSIM.
Inference: