You are on page 1of 4

UTC M4565 LINEAR INTEGRATED CIRCUIT

DUAL OPERATIONAL AMPLIFIER

DESCRIPTION
The UTC M4565 integrated circuit is a high-gain,
wide-bandwidth, dual low noise operational amplifier SOP-8
capable of driving 20V peak-to-peak into 400Ω load.

FEATURES
*Operating Voltage: ±4V~±18V
*Wide Gain Bandwidth Product: 4MHz (typ.)
TSSOP-8
*Slew Rate: 4V/μs (typ.)

DIP-8

PIN CONFIGURATION

OUT1 1 8 Vcc +

- +
IN1(-) 2 7 OUT2

+ -
IN1(+) 3 6 IN2(-)

Vcc - 4 5 IN2(+)

UTC UNISONIC TECHNOLOGIES CO., LTD. 1


QW-R105-022,A
UTC M4565 LINEAR INTEGRATED CIRCUIT
EQUIVALENT CIRCUIT

Vcc+

IN(-)
output
IN(+)

-
Vcc

ABSOLUTE MAXIMUM RATINGS(Ta=25℃)


PARAMETER SYMBOL RATINGS UNIT
Supply Voltage V+/V- ±18 V
Differential Input Voltage VID ±30 V
Input Voltage VIC ±15 * V
Power Dissipation
DIP-8 500
PD mW
SOP-8 300
TSSOP-8 250
Operating Temperature Range Topr -20~+75 °C
Storage Temperature Range Tstg -40~+125 °C
* For supply voltage less than ±15V,the absolute maximum input voltage is equal to the supply voltage.

ELECTRICAL CHARACTERISTICS (Ta=25℃,V+/V-=±15V)


PARAMETER SYMBOL TEST CONDITION MIN TYP MAX UNIT
Input Offset Voltage VIO Rs≤10kΩ 0.5 3.0 mV
Input Offset Current IIO 2 50 nA
Input Bias Current IB 50 200 nA
Input Resistance RIN 0.3 5 MΩ
Large Signal Voltage Gain Av RL≥2kΩ,Vo=±10V 86 100 dB
Maximum Output Voltage Swing 1 VOM1 RL≥2kΩ ±12 ±14 V
Maximum Output Voltage Swing 2 VOM2 Io=25mA ±10 ±11.5 V
Input Common Mode Voltage Range VICM ±12 ±14 V
Common Mode Rejection Ratio CMR Rs≤10kΩ 70 90 dB
Supply Voltage Rejection Ratio SVR Rs≤10kΩ 76.5 90 dB
Operating Current Icc 4.5 7 mA
Slew Rate SR 4 V/μs
Gain Bandwidth Product GB 10 MHz
Equivalent Input Noise Voltage VNI RIAA, Rs=2.2kΩ,30kHz LPF 1.2 µVrms

UTC UNISONIC TECHNOLOGIES CO., LTD. 2


QW-R105-022,A
UTC M4565 LINEAR INTEGRATED CIRCUIT
TYPICAL CHARACTERISTICS

Equivalent Input Noise Voltage vs.Frequency


60.0
V+/V-=±15V
54.0 Rs=1kΩ

Equivalent Input Noise Voltage, en (nV√Hz)


Ta=25℃
48.0

Maximum Output Voltage Swing 42.0


vs.Frequency
Maximum Output Voltage Swing, Vopp (V)

36.0
36
32 V+/V-=±15V,Ta=25℃
30.0
RL=2kΩ
28
RL=400Ω 25.0
24
20 18.0
16
12 12.0
8
6.0
4
0 0
10 100 1k 10k 100k 1M 3 10 100 1k
Frequency, f (Hz) Frequency, f (Hz)

Maximum Output Voltage Swing vs. Voltage Gain Phase vs. Frequency
Maximum Output Voltage Swing, Vopp (V)

Load Resistance
V+/V-=±15V,Ta=25℃ 50
30 0
Voltage Gain, Av (dB)

40
-60
20 30 ψ ψ
-120 (deg)
20
Av
10 -180
10 V+/V-=±15V,RL=2kΩ
40dBAmp,Ta=25℃
0
0.01 0.1 1 10 100 0 1k 10k 100k 1M
Load Resistance, RL (kΩ) Frequency, f (Hz)

Operating Current vs.Temperature Maximum Output Voltage Swing


vs.Temperature
+VOM ,(V)

9 15
V+/V-=±15V V+/V-=±15V,RL=2kΩ
Maximum Output oltage Swing
Operating Current, Icc (mA)

8
7 14
6
5 13
~
~
4 -13
3
2 -14
-VOM,(V)

1
-15
-50 -25 0 25 50 75 100 125 -50 -25 0 25 50 75 100 125
Ambient Temperatur, Ta (℃) Ambient Temperatur, Ta ( ℃)

UTC UNISONIC TECHNOLOGIES CO., LTD. 3


QW-R105-022,A
UTC M4565 LINEAR INTEGRATED CIRCUIT
TYPICAL CHARACTERISTICS

Input Offset Voltage vs.Temperature Input Bias Current vs. Temperature


90
Input Offset Voltage, VIO (mV)

V+/V-=±15V V+/V-=±15V
2.0 80

Input Bias Current, In (nA)


70
1.0 60
50
0 40
30
-1.0 20
10
-2.0 0
-50 -25 0 25 50 75 100 125 -50 -25 0 25 50 75 100 125
Ambient Temperatur, Ta(℃) Ambient Temperatur, Ta (℃
)

Maximum Output Voltage Swing Operating Current vs.Operating Voltage


vs.Operating Voltage
Input Offset Voltage, VIO (mV)

RL=400Ω, Ta=25℃ 6 Ta=25℃


Operating Current, Icc (mA)

15
5
10
+VOM 4
5
0 3

-5 2
-VOM
-10 1
-15
0
0 5 10 15 20 5 10 15 20
Operating Voltage, V + /V - ( ± V Operating Voltage, V +/ V - (± V
)

UTC assumes no responsibility for equipment failures that result from using products at values that
exceed, even momentarily, rated values (such as maximum ratings, operating condition ranges, or
other parameters) listed in products specifications of any and all UTC products described or contained
herein. UTC products are not designed for use in life support appliances, devices or systems where
malfunction of these products can be reasonably expected to result in personal injury. Reproduction in
whole or in part is prohibited without the prior written consent of the copyright owner. The information
presented in this document does not form part of any quotation or contract, is believed to be accurate
and reliable and may be changed without notice.

UTC UNISONIC TECHNOLOGIES CO., LTD. 4


QW-R105-022,A

You might also like