You are on page 1of 59

 


 



!#  


$
$    $    
 " $    $    

To avoid errors or delay in filling your parts order,


always give the MODEL, SPEC NO. and SERIAL
NO. from the Onan nameplate.
For handy reference, insert your nameplate information in the spaces below.

MODEL AND SPEC NO.

SERIAL NO.

DIGITAL CONTROL SOFTWARE VERSION


AND DATE (IF APPLICABLE)

The following symbols are used in Onan manuals


to alert users to the potentially dangerous conditions relating to maintenance of equipment and replacement of parts. Please read and observe.
This symbol warns of immediate hazards which will result in
severe personal injury or death.
This symbol refers to a hazard
or unsafe practice which can result in severe personal injury or
death.
This symbol refers to a hazard
or unsafe practice which can result in severe personal injury or
product or property damage.

Service and repair of Onan equipment must be performed by trained, experienced personnel only. Improper service or repair may result in property damage, severe personal injury or death. Do not use this
catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.

Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.

Contact with ASBESTOS has been identified by a United States federal agency and some USA state
agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all
necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation and wear protective gloves, masks and clothing!

Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified
by a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take
all necessary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and wear protective gloves, masks and protective clothing!
PSP-1

INTRODUCTION

This catalog applies to the standard BGE/BGEL Recreational Vehicle Generator Sets as listed in the Generator
Set Data Table. Parts are arranged in groups of related items and each illustrated part isidentified by a referencenumber corresponding to the same reference number in the parts list. Unless otherwise mentioned in the description, parts are interchangeable between models. Parts illustrations are typical. Using the model and specification
number from your generator set nameplate, select parts that apply to your set. Right and Left sides are determined
by Facing the engine (front) of the set. Generator Set Data Table

MODEL NUMBER
3.5BGEL53CR/31813
3.5BGEL53CR/31814E
4.0BGEL1R/26110E
4.0BGEL1R/26111E
3.5BGE53CR/29236F
3.5BGE53CR/29237F
3.5BGEFN/31813
3.5BGEFN/31814
4.0BGE1R/26100
4.0BGE1R/26101
4.0BGEFR/26103
4.0BGEFR/26104
4.0BGE1R/26109
4.0BGEFA/26110
4.0BGEFA/26111
4.0BGEFN/29236
4.0BGEFN/29237
4.0BGEFN/37593
4.0BGEFA/55215
5.0BGEFA/26100
5.0BGEFA/26101

MOUNTING
LOCATION
Above Floor
Below Floor
Above Floor
Below Floor
Above Floor
Below Floor
Above Floor
Below Floor
Above Floor
Below Floor
Above Floor
Below Floor
Below Floor
Above Floor
Below Floor
Above Floor
Below Floor
Below Floor
Above Floor
Above Floor
Below Floor

VOLTS HERTZ
120/240
50
120/240
50
120
60
120
60
120/240
50
120/240
50
115/230
50
115/230
50
120
60
120
60
100
60
100
60
120
60
120
60
120
60
115/230
50
115/230
50
115/230
50
120
60
120
60
120
60

WIRE
FUEL
4
LP Liquid
4
LP Liquid
2
LP Liquid
2
LP Liquid
4
Gasoline
4
Gasoline
3
LP Liquid
3
LP Liquid
2
Gasoline
2
Gasoline
2
Gasoline
2
Gasoline
2 NHE Drip Pan Gasoline
2
LP Liquid
2
LP Liquid
3
Gasoline
3
Gasoline
3 NHE Drip Pan Gasoline
2
Gasoline
2
Gasoline
2
Gasoline

* The diagonal line (/) in the model and specification number separates generator set characteristics from the
specification number and letters. The specification number denotes customer requested options or deviations
from a standard (1A, 1B, etc.) model. The spec ification letter advances (A, to B, to C, etc.) with major manufacturing changes.

Index
Connector, Conduit, 45
Connector, Hose, 30
Connector, Receptacle, 45
Connector, Tab, 45
Control, 47
Control, Ignition, 25
Control, Start Remote, 43
Conversion Kits, 52, 53
Cover, Block Brush, 45
Cover, Box Breaker, 27
Cover, Choke, 17
Cover, Control, 47
Cover, Housing Choke, 17
Cover, Inlet Air, 17
Cover, Switch Rocker, 47
Cover, Valve RH, 7
Crankshaft, 11
Cup, Governor, 10
Cup, Intake Oil Pump, 13

Adapter, Carburetor, 30
Adapter, Cleaner Air, 17, 21
Adapter, Exhaust, 35
Adapter, Filter Oil, 14
Adapter, Generator, 45
Adapter, Hose Fuel, 17
Adapter, Preheater, 17
Adapter, Reducer, 21
Arm, Governor, 15
Backplate, Scroll, 33
Baffle, Valve Breather, 7
Ball, Bearing, 15
Ball, Governor, 10
Base, Box Breaker, 27
Base, Oil, 13
Bearing, Camshaft, 7
Bearing, Crankshaft, 7
Bearing, Needle, 15
Bearing, Ring Collector, 45
Bimetal, Choke, 17
Block, Brush, 45
Block, Cylinder, 7
Board, Circuit Printed, 47
Bowl, Fuel, 24
Box Assy, Breaker, 27
Brace, Rear, 38, 39, 40, 41
Brace, Side, 38, 39, 40
Bracket, 40
Bracket, Cable Governor Adjust, 22
Bracket, Coil Ignition, 25
Bracket, Control Ignition, 25
Bracket, Exhaust, 35
Bracket, Gas Regulator, 31
Bracket, Governor, 22
Bracket, Holder Fuse, 47
Bracket, Housing, 38, 39, 41
Bracket, Lifing, 33
Bracket, Line Fuel, 21
Bracket, Manifold Exhaust, 35, 37
Bracket, Mounting Diaphragm, 17
Bracket, Mounting Filter, 21
Bracket, Mounting Housing, 17, 21
Bracket, Regulator Gas, 30
Breaker, Circuit, 47
Bridge, Rectifier, 45
Brush, Block, 45
Bushing, Governor, 10
Bushing, Reducer, 21

Diode, 43
Drain, Filter Oil, 14
Elbow, 21, 48
Elbow, Inlet, 17
Elbow, Inverted, 19
Elbow, Male, 21
Elbow, Male Inverted, 17
Elbow, Reducing, 21
Elbow, Street, 21, 30
Element, Choke, 17
Element, Cleaner Air, 17, 21
Element, Filter Fuel, 21
Exhaust System, 35, 37
Fan, Armature, 45
Filter, Fuel, 17
Filter, Oil, 14
Filter, Tube Breather, 9
Fitting, Vacuum Intake, 17
Flange, Exhaust Manifold, 35
Flywheel, 11
Fuel System (Gasoline), 17, 19
Fuel System (LP Liquid), 21
Fuel System (LPG) Field Conversion, 30, 31
Fuse, 47, 51
Gasket Kits, 52, 53
Gasket, Adapter Air Intake, 30
Gasket, Adapter Oil Filter, 14
Gasket, Airhorn, 31
Gasket, Base Oil, 13
Gasket, Bowl, 24
Gasket, Box Breaker, 27
Gasket, Carburetor, 31
Gasket, Exhaust, 35, 37
Gasket, Filter Oil, 13, 14
Gasket, Head Cylinder, 7
Gasket, Horn Air, 17, 21
Gasket, Manifold Exhaust, 35, 37
Gasket, Manifold Intake, 17, 21
Gasket, Mounting Carburetor, 17, 21
Gasket, Mounting Gearcase, 15
Gasket, Plate, 25
Gear, Armature, 45
Gear, Camshaft, 10
Gear, Crankshaft, 11

Cable, Adjust Governor, 22


Cable, Plug Spark, 25, 26
Camshaft, 10
Cap, Drive, 29
Cap, End, 29
Cap, End Drive, 29
Cap, Fill Oil, 13
Cap, Valve, 7
Cap, Vinyl, 17
Carburetor, 17, 21
Carburetor (Gasoline), 23
Carburetor (LP), 24
Carburetor Kits, 52, 53
Carburetor, LPG (Emissions), 31
Coil, Ignition, 25, 26
Condenser, Ignition, 26, 27
Connector, 25

Index
Gearcase, 15
Generator, 45
Governor, 22
Grommet, Rubber, 38, 39, 40, 41
Guard, Breaker Circuit, 47
Guard, Scroll, 33
Guide, Valve, 7

Kit, Float Carburetor, 23


Kit, Gasket Engine, 7
Kit, Gasket Oil Pump, 7
Kit, Key Blower Wheel, 11
Kit, LP Accessory, 31
Kit, Repair Carburetor, 23
Kit, Ring Piston, 9
Kit, Vacuum Sustain Valve, 23
Kit, Vacuum Valve Hose, 23

Hanger, Exhaust, 35
Hanger, Pipe Exhaust, 37
Harness, Charger Battery, 45
Harness, Wiring, 14, 49, 51
Harness, Wiring AC Outlet, 47
Harness, Wiring Fuel Pump, 17
Harness, Wiring Ignition Relay, 21
Harness, Wiring PCB #1, 47
Harness, Wiring PCB #3, 49
Harness, Wiring Remote, 43, 50
Harness, Wiring Voltage Regulator, 47
Head, Cylinder, 7
Holder, Fuse, 47, 51
Hose, Fuel, 17, 21, 30, 31
Hose, Oil (Vent), 30, 31
Hose, Preheater, 17
Housing Below Floor, (Specs 26109, 37593), 40
Housing Below Floor Models

Label, Kit Number, 31


Label, Caution, 40
Label, LP Kit, 31
Label, Preheat, 17
Label, Warning, 38, 39, 40, 41
Labels, 52, 53
Lead, Box Breaker, 27
Lead, Bracket Filter Mounting, 21
Lead, Resistor, 45
Lead, Starter, 28
Lever, Shaft Throttle, 24
Line, Fuel, 17, 21
Link, Spring Governor, 15
Linkage, Choke, 17
Linkage, Choke Pulloff, 17
Lock, Spring Valve, 7

      


    

 
      
    

 
   

Manifold, Exhaust, 21, 35, 37


Manifold, Intake, 17, 21
Meter, Condition Battery, 43
Meter, Totalizing Time, 43
Muffler, Arrester Spark, 35
Muffler, Arrestor Spark, 37

Housing, Air, 33
Housing, Breather, 7
Housing, Choke, 17
Housing, Cleaner Air, 17, 21
Housing, Cyilnder Air, 33
Housing, Cylinder Air, 33
Housing, Stator, 45
Hub, Cup Governor, 10

Needle, Adjust Idle, 24


Nipple, Close, 21
Nipple, Pipe, 30
ORing, Cap Oil Fill, 13
ORing, Housing Stator, 45
Paint, 52, 53
Pan, Drip, 13, 38, 39, 40, 41
Panel Rear, 40
Panel, Control, 43
Panel, Housing, 38, 39, 41
Panel, Left Hand, 40
Panel, Right Hand, 40
Pin, Alignment Gear Cover, 7
Pin, Center Camshaft, 10
Pin, Dowel Governor Cup Stop, 15
Pin, Drive Bearing Stop, 7
Pin, Hinge, 38, 39, 40, 41
Pin, Piston, 7
Piston, 7
Plate, Bearing Rear, 7
Plate, Cover Ignition Plunger, 25
Plate, Hinge, 38, 39, 40
Plate, Throttle, 24
Plug, Bowl, 24
Plug, Button Dot, 33
Plug, Cap, 48
Plug, Drain Oil, 13
Plug, Head Square, 30
Plug, Hole, 47
Plug, Hole Core, 7
Plug, Pipe Hex, 19, 21

Ignition System, 26
Ignition, Electronic, 25
Insert, Seat Valve, 7
Insert, Valve Seat, 7
Insulator, Board PC, 47
Insulator, Fuse, 47
Insulator, Terminal Start, 47
Isolator, Vibration Engine End, 13
Isolator, Vibration Generator End, 13
Jet, Idle, 23
Jet, Power, 23
Joint, Ball, 22
Key, Gear Crankshaft, 11
Key, Woodruff, 10
Kit Assembly, Drive, 29
Kit, Choke Bimetal, 23
Kit, Choke Pulloff Breaker, 23
Kit, Choke Shaft, 23
Kit, Control Deluxe Remote, 43
Kit, Control Standard, 43
Kit, Conversion, 31
Kit, Conversion LP, 30
Kit, Damper Governor, 22
Kit, Drive Starter, 29

Index
Plug, Spark, 25, 26
Plug, Welch Camshaft, 7
Plunger, Point Breaker, 27
Plunger, Valve Bypass, 7
Points, Breaker, 27
Potentiometer, 47
Pulloff, Choke, 17
Pump, Fuel Electric, 17
Pump, Oil, 7

Solenoid, Vapor LP, 30


Spacer, Brace, 41
Spacer, Mounting Pump, 17
Spacer, Muffler, 35
Spring, Brush Generator, 45
Spring, Bypass, 17
Spring, Compression, 22
Spring, Governor, 22
Spring, Needle Idle, 15, 24
Spring, Screw Main Jet, 24
Spring, Stop Throttle, 24
Spring, Valve, 7
Spring, Valve Breather, 7
Spring, Valve Bypass, 7
Starter, 28
Starter Components, 29
Stator, Generator, 45
Strap, Ground, 13
Strap, Muffler, 35
Stud, Adjustment Speed, 22
Stud, Grounding, 45
Stud, Long Extended Shaft, 45
Support, 40
Support, Hinge, 38, 39, 40, 41
Support, Housing, 38, 39, 41
Switch, Pressure Low Oil, 14
Switch, Rocker, 43, 47

Rectifier, 21, 49
Reed, Valve Breather, 7
Regulator, Gas, 30, 31
Regulator, LP, 21
Regulator, Voltage, 47
Relay (K4), 51
Relay, Ignition, 21
Resistor, Charger Battery, 45
Resistor, Pump Fuel, 45
Resonator, Exhaust, 35
Retainer Pushon, 22
Ring, Collector Armature, 45
Ring, Retainer Choke Housing, 17
Ring, Retaining Camshaft, 10
Ring, Retaining Crankshaft, 11
Ring, Retaining Piston, 7
Ring, Tolerance, 45
Rod, Arm Governor, 22
Rod, Connecting, 9
Rod, Inlet Air, 17
Rod, Throttle, 22
Rotor Assembly, Ignition, 25
Rotor, Generator, 45

Tappet, Valve, 7
Thread Sealant, 52, 53
Tie, Cable, 28, 45, 47
Tube, Breather, 17, 21, 48
Tube, Bypass Breather, 48
Tube, Exhaust, 35, 37
Tube, Housing Choke, 17
Tube, Idle, 24
Tube, Oil Cylinder Block, 7

Scroll, 33
Seal, Dust, 24
Seal, Dust Rubber, 24
Seal, Oil Crankshaft Front, 15
Seal, Oil Crankshaft Rear, 7
Seal, Oil Governor Shaft, 15
Seal, Valve Intake, 7
Shaft, Governor, 15
Shield, Noise, 33
Snubber, Isolator, 13
Solenoid, Liquid LP, 21
Solenoid, Start, 47

Valve, Exhaust, 7
Valve, Fuel Shutoff, 31
Valve, Intake, 7
Valve, Shutoff Fuel, 21
Valve, Shutoff Oil Base, 13
Wheel, Blower, 11
Yoke, Governor, 15

Cylinder Block
30
41
25
58

30

26
23

41
24

38
27

21

32

26
43

22
32

31

26
43

33

10
7

37
49
50
51
52

16
2

5
6 4

11
19
34

9
14
28
42
35
20
13

11
48

47

45

36

57

15
12

29

18

39

17

44

40
56

55 54
53
46

Cylinder Block
REF
NO.

PART
NO.

QTY
USED

1
2
3

4
5

6
7
8
9
10
11
12
13

517004801

8000575

8000051

1040776

1010804
101080402
101080410
101080420
101080430
1040575
1010809
101043901
1010405
5090041
5160072
1201320

1
1
1
1
1
2
1
1
2
1
4
1

1101824
110182402
110182405
110182410
110182425

2
2
2
2
2

1100197
110019710

2
2

1010805
101080502
101080510
101080520
101080530

1
1
1
1
1

1103527
1103526
1140392
8700533

2
2
4
4

8500050
5260402
5160141
1231175
1231173
1231174
110187901
1231649

5
5
2
1
1
1
1
1

14

15

16

17
18
19

20
21
22
23
24
25

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

Block, Cylinder (See Short


Block Catalog #9320109)
Plug, Welch Camshaft
Screw, Cap
Spec FH, Flanged Head
(3/816 x 11/8)
Begin Spec J, Hex Head
(3/816 x 11/4)
Shim, End Play Crankshaft
Bearing, Crankshaft Rear
(Includes Thrust Washer)
Standard
.002 Undersize
.010 Undersize
.020 Undersize
.030 Undersize
Washer, Thrust
Gasket, Plate Bearing
Plate, Bearing Rear
Bearing, Camshaft
Seal, Oil Crankshaft Rear
Pin, Drive Bearing Stop
Tube, Oil Cylinder Block
Insert, Valve Seat Exhaust
Standard
.002 Oversize
.005 Oversize
.010 Oversize
.025 Oversize
Insert, Valve Seat Intake
Standard
.010 Oversize
Bearing, Crankshaft Front
Standard
.002 Undersize
.010 Undersize
.020 Undersize
.030 Undersize
Guide, Valve
Exhaust
Intake
Bolt, Rod Connecting
Nut, SelfLocking (5/1624)
Washer
Spec FH, Lock (3/8)
Begin Spec J, Flat (3/8)
Pin, Alignment Gear Cover
Reed, Valve Breather
Baffle, Valve Breather
Spring, Valve Breather
Cover, Valve Right Hand
Housing, Breather

26
27

1103709

1150006
115000602
115000605
1103479

4
4
4
2

30

1103480
1103515
8000010

2
2
2

31
32
33
34

1103485
1103511
5090289
8030071

4
8
2
2

35
36

1103181

37

1103509
1103508
1103487

1
1
4

38
39
40

5260018
5260122
8000571

1
18
18

41
42
43
44

5260063
5170067
1103510

2
1
4

45
46
47
48

1680189
1680192
1200491
1200161
7401004
8000007

1
1
1
1
2
2

49

8010049

50
51
52
53

5260066
1200140
1200398

1
1
1

1120264
112026405
112026401
112026402
112026403
1120229
5180311

2
2
2
2
2
2
4

Gasket, Cover Valve


Tappet, Valve
Standard
.002 Oversize
.005 Oversize
Valve, Intake
Valve, Exhaust
Stellite
Standard
Screw, Cap Hex Head
(1/420 x 13/4)
Spring, Valve
Lock, Spring Valve
Seal, Valve Intake
Screw, Set Socket
(3/816 x 5/8)
Gasket, Head Cylinder
Head, Cylinder
Right Side
Left Side
Washer, Retaining Valve
Spring
Washer, Flat (1/4)
Washer, Flat (5/16)
Screw, Cap Hex Head
(5/1618 x 21/4)
Washer, Flat Copper (1/4)
Plug, Hole Core
Cap, Valve
Kit, Gasket
Carbon Removal/Valve Grind
Engine, Complete
Pump, Oil
Kit, Gasket Oil Pump
Washer, Flat (M6)
Screw, Cap Hex Head
(1/420 x 1)
Screw, Cap Hex Head
(3/824 x 7/8)
Washer, Flat Copper (3/8)
Spring, Valve Bypass
Plunger, Valve Bypass
Piston (Includes Pin and
Retaining Rings)
Standard
.005 Oversize
.010 Oversize
.020 Oversize
.030 Oversize
Pin, Piston
Ring, Retaining

28
29

54
55

Cylinder Block
30
41
25
58

30

26
23

41
24

38
27

21

32

26
43

22
32

31

26
43

33

10
7

37
49
50
51
52

16
2

5
6 4

11
19
34

9
14
28
42
35
20
13

11
48

47

45

36

57

15
12

29

18

39

17

44

40
56

55 54
53
46

Cylinder Block
REF
NO.

PART
NO.

QTY
USED

56
1130314
113031405
113031410
113031420
113031430

2
2
2
2
2

1130310
113031005
113031001
113031002
113031003

2
2
2
2
2

PART
DESCRIPTION

REF
NO.

Kit, Ring Piston


Specs EH
Standard
.005 Oversize
.010 Oversize
.020 Oversize
.030 Oversize
Begin Spec J
Standard
.005 Oversize
.010 Oversize
.020 Oversize
.030 Oversize

PART
NO.

57

58

1140397
114039710
114039720
114039730
1231871

QTY
USED

PART
DESCRIPTION

Rod, Connecting
(Includes Bolt and Nut)
2
Standard
.010 Undersize
2
2
.020 Undersize
2
.030 Undersize
1
Filter, Tube Breather

Camshaft

5
7
8
3

4
6

REF
NO.
1
2
3
4
5

PART
NO.
1500078
1501519
1501520
5100015
5150001

QTY
USED
1
1
1
10
1

PART
DESCRIPTION
Ring, Retaining
Hub, Cup Governor
Cup and Bushing, Governor
Ball, Governor
Key, Woodruff

10

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

6
7

1050637
1050700

1
1

8
9

1050541
1500075

1
1

Camshaft (Includes Center Pin)


Gear, Camshaft (Includes Gear,
Spacer and Plate)
Washer, Thrust
Pin, Center Camshaft

Crankshaft and Flywheel

REF
NO.
1
2
3
4
5

PART
NO.
1040170
5260356
5260017
1344342
5180014

QTY
USED
1
1
1
1
1

10

PART
DESCRIPTION
Screw, Cap Hex Head
Washer, Flat (7/16)
Washer, Flat (7/16)
Wheel, Blower
Ring, Retaining

11

REF
NO.

PART
NO.

QTY
USED

6
7
8
9
10

1040043
1040032
5150263
5150001
1041735

1
1
1
1
1

PART
DESCRIPTION
Washer, Gear
Gear, Crankshaft
Kit, Key Blower Wheel
Key, Gear Crankshaft
Crankshaft (Includes Keys)

Oil Base and Mounting Hardware

20

16

1
21
17

19

23

18

22
7
6

5
15

14

13

10

4
24

11

12

8
10
9

12

Oil Base and Mounting Hardware


REF
NO.

PART
NO.

QTY
USED

2
3

1021286
1021458
1021387

1
1
1

403255702

1
1

403221801
4020597

1
2

8210010

6
7

5260325
8150657

2
2

4020549

8210016

PART
DESCRIPTION
Base, Oil
Spec FM
Begin Spec N
Gasket, Base Oil
Pan, Drip
Above Floor Models
Below Floor Models (See
Below Floor Housing
Pages)
Begin Spec J
Isolator, Vibration Generator
End
Screw, Hex Washer Head
SelfLocking (1/420 x 1/2)
Washer, Flat (3/8)
Screw, Hex Head Thread
Form (3/816 x 23/4)
Isolator, Vibration Engine
End
Screw, Hex Washer Head Self
Locking (5/1618 x 3/4)

13

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

10

8210031

11
12
13
14

5260324
5260240
3372311
8210014

1
1
1
1

15
16

8560008
1231616

2
1

17
18

5040150
8000058

1
4

19
20
21
22
23
24

5260251
1231961
5090096
5050266
1020743
4020547

4
1
1
1
1
2

Screw, Hex Washer Head Self


Locking (3/816 x 3/4)
Washer, Flat (5/16)
Washer, Flat (3/8)
Strap, Ground
Screw, Hex Washer Head Self
Locking (5/1618 x 1/2)
Washer, Lock EIT (5/16)
Cup, Intake Oil Pump
(Includes Pipe And Cup)
Valve, Drain Oil
Screw, Cap Hex Head
(3/816 x 3)
Washer, Flat (3/8)
Cap, Fill Oil
ORing, Cap Oil Fill
Plug, Drain Oil (3/8)
Gasket, Drain Oil
Snubber, Isolator

Oil Filter

2
3
8

10

1
9
5

REF
NO.

PART
NO.

QTY
USED

1220814

5260065

8000028

4
5

122036050
8150340

1
2

1220771

PART
DESCRIPTION
Adapter, Filter Oil (Includes
Screws)
Washer, Flat Copper
(5/16)
Screw, Cap Hex Head
(5/1618 x 1)
Drain, Filter Oil
Screw, Cap Hex Washer Head
Thread Forming
(#1032 x 3/8)
Gasket, Adapter Oil Filter

14

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

7
8
9
10

1220645
3090322
1220502

1
1
1

3382041
3382634

1
1

3382086
3382635

1
1

Filter, Oil
Switch, Pressure Low Oil
Gasket, Filter Oil
Harness, Wiring (See Separate
Page for Components)
Gasoline
Spec FG
Begin Spec H
LP
Spec FG
Begin Spec H

Gearcase

15
17
18
14

16
2
13
3
4
8 7

11
12

6
5
9

10

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

Gearcase Assy (Includes Parts


Marked*)
*Arm and Shaft, Governor
*Seal, Oil Governor Shaft
*Bearing, Needle
*Ball, Bearing
*Pin, Stop Governor Cup
*Yoke, Governor
*Screw, Machine Pan Head
(#832 x 3/8)
*Seal, Oil Crankshaft Front
Gasket, Gearcase
Washer, Flat Copper
(5/16)
Screw, Cap Hex Head
13/4 Long
23/4 Long

13
14
15
16

1501998
8700328
1410710
8201077

1
1
1
1

17

8510031

18

8700257

*Link, Spring Governor


*Nut, SelfLock (#1032)
*Spring, Needle Idle
*Screw, Pan Head
(#1032 x 21/2)
*Washer, Spring Conical Disc
(#10)
Nut, Hex SelfLocking
(5/1618)

1030772

2
3
4
5
6
7
8

150200204
5090008
5100013
5100014
5160130
1501187
8150046

1
1
1
1
1
1
2

5090040
1030810
5260065

1
1
5

1140022
8000545

4
1

9
10
11
12

* Parts Included In Gearcase Assy.

15

Fuel System
(Gasoline)

49
53

37

18

38

19

48

41

46

47
45

40
9
13

24

44

20

23

21

25
8
36

26

36

27

31
12

6
3

67
66

17

4
56

7
11

22

64

16
10
43
15

32
50

34

30

54

39

55

35
51
33

52

54
6

14
42

28

2
61
14
60

54

57
61
29

58

32

65

62

59

54

63
55
14

55

16

28

Fuel System
(Gasoline)
REF
NO.
1
2
3

PART
NO.

QTY
USED

1542447
8150587

1
2

1410950
1410958
8620015

1
1
1

1460455
1460577
1460630

5020002
5021108
1530555

1
1
1

8
9

1402308
8150590

1
3

10

1530556

5180387

11

8150592

12

1530561

13
14

5180450

4
5

15
16

1492140
1492269
1492331
149233102
1530554
1530557

1
1
1
1
1
1

17

8150591

18

8000017

19
20
21

5260021
1402379

1
1

1401894
1402962
1530558

1
1
1

24

1402782
1403093
1530577

1
1
1

25
26

1530576
5031252

1
1

27
28

5021105
5020313

1
1

22
23

PART
DESCRIPTION
Manifold, Intake
Screw, Hex Washer Head
Gasket, Mounting Carburetor
Spec FJ
Begin Spec K
Nut, Hex (5/1618)
Carburetor (Includes Mounting
Gasket) (See Separate Page
for Components)
Spec FJ
Begin Spec K
Begin Spec L & Up
Elbow, Male Inverted 90
Spec F
Begin Spec G
Element and Cover, Choke
(Spec FJ)
Gasket, Horn Air
Screw, Cap Hex Head
(#1032 x 1/2)
Housing, Choke (Includes
Choke Shaft) (Spec FJ)
Ring, Retainer Choke Housing
(Not Shown)
Screw, Head Hex Washer
(#832 x 13/8) (Spec FJ)
Bracket, Mounting Diaphragm
(Spec FJ)
Clip, U (Spec FJ)
Pump, Fuel Electric (Includes
Mounting Bracket)
Spec F,G
Spec H
Begin Spec J
Begin Spec K
Bimetal, Choke (Spec FJ)
Bracket, Mounting Housing
(Spec FJ)
Screw, Head Hex Washer
(1/410 x 3/4) (Spec FJ)
Screw, Cap Hex Head
(1/420 x 31/2)
Washer, Flat (1/4)
Element, Cleaner Air
Housing, Cleaner Air
Spec FK
Spec L
Linkage, Choke (Spec FJ)
Adapter, Cleaner Air
Spec FK
Spec L
Linkage, Pulloff Choke
(Spec FJ)
Pulloff, Choke (Spec FJ)
Hose, Vacuum (Spec FJ)
(3/16 ID x 3 Long)
Fitting, Vacuum Intake 90
Elbow, 90

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

29

8150664

1492080
1492293
1492319
1492334
98610501

1
1
1
1
1

815069201

815069202

33
34

1542495
8000033

2
4

35
36
37
38
39
40
41
42

7401006
5030813
140191950
1231615
1492226
5031133
5030183
3382285

4
2
1
1
2
1
1
1

43

1530578

44
45
46

5170223
5260002
1200140

1
1
1

47
48
49
50

1450667
1450704
1450561
5031351
1530579

1
1
1
1
1

51
52

8700421
5180466

1
1

53

5180459

54

8150290

55
56

8530013

57
58

1492279
1492333
1491353
3704052

1
1
1
1
1
2

59
60

5031313
5021164

1
1

Screw, Thread Form


Torx (1/420 x 3/8)
Line, Fuel (Includes 2 Inverted
Nuts)
Spec F
Spec G
Spec H
Begin Spec J
Label, Preheat
Screw
Hex, Machine 60 Hz
(1/420 x 1/2)
Pan Head 50 Hz
(1/420 x 1)
Gasket, Manifold Intake
Spec FH
Screw, Cap Hex Head
(5/1618 x 2)
Washer, Flat (M8)
Clamp, Hose
Adapter, Preheater
Tube, Breather
Washer, Pump Fuel
Clamp, Hose Breather Tube
Clamp, Hose Breather Tube
Harness, Wiring Fuel Pump
(Includes Rectifier)
Tube, Housing Choke
(Spec FJ)
Cap, Vinyl
Washer, Flat (#6 Screw)
Spring, Bypass
Rod, Inlet Air
Spec FJ
Used on Spec K
Cover, Inlet Air
Hose, Preheater
Cover, Housing Choke
(Spec FJ)
Nut, Cap (#632) (Spec FJ)
Clip, Housing Choke
(Spec FJ)
Clip, Hose Preheater
(Spec FJ)
Screw, Torx Thread Form
(1/420 x .62)
Washer, ET (1/4) 50 Hz
Filter, Fuel
Spec FG
Begin Spec J
Filter, Fuel (Spec H)
Spacer, Mounting Pump
(Begin Spec H)
Hose, Fuel (Begin Spec H)
Adapter, Hose Fuel
(Begin Spec H)

30

31
32

17

Fuel System
(Gasoline)

49
53

37

18

38

19

48

41

46

47
45

40
9
13

44

20

23

24

21

25
8
36

26

36

27

31
12

6
3

67
66

17

4
56

7
11

22

64

16
10
43
15

32
50

34

30

54

39

55

35
51
33

52

54
6

14
42

28

2
61
14
60

54

57
61
29

58

32

65

62

59

54

63
55
14

55

18

28

Fuel System
(Gasoline)
REF
NO.

PART
NO.

QTY
USED

61
62
63

5180515
5030170
8150782

2
2
1

64

5020028

PART
DESCRIPTION
Clip, Wire (Begin Spec H)
Clamp, Hose (Begin Spec H)
Screw, Pan Head Torx (Begin
Spec J)
Plug, Pipe Hex Head (Begin
Spec K)

19

REF
NO.

PART
NO.

QTY
USED

65

5020065

66
67

7401006
8000033

4
4

PART
DESCRIPTION
Elbow, Inverted 45 (Begin
Spec J)
Washer, Flat (M8)
Screw, Hex Head Cap

Fuel System
(LP Liquid)

39

43
46
45
44
53

36

35
33

30

41
24
25

38

10
37

28

27

52

29

14

32
42
41

12

15

22

31
13

40

26
18

21
19
49

20
9
51

23

5
58

50
8

56

48

55

16

4
11

47
34

17
7

57
6
54
1

2
20

Fuel System
(LP Liquid)
REF
NO.

PART
NO.

QTY
USED

1
1542447
1543026
8150587

1
1
2

1410281
8620015

1
2

6
7
8
9

1410932
1460723
5051426
3071886
1402308
8150590

1
1
1
1
1
3

10

8150261

11

8210005

12

5030183

5031365
5030633

1
1

15
16
17

1480893
1481020
5410532
502092701
307255901
8150591

1
1
1
1
1
2

18

8000017

19
20
21
22
23
24

5260021
1402379
1401894
5020838
1402782
8150647

1
1
1
1
1
2

25
26
27

8500040
5020935

2
1

28

1480896
1480903
1480890

1
1
1

29
30

1480898
815069201

1
1

31

502093201

502093301

5020054

2
3
4
5

13

14

32

PART
DESCRIPTION
Manifold, Intake
Spec FK
Begin Spec L
Screw, Head Hex Washer
(5/1618 x 1)
Gasket, Mounting Carburetor
Nut, Hex (5/1618)
Carburetor (See Separate Page
For Components)
Spec FK
Spec L & Up (LPG Liquid)
Plug, Pipe (1/8) (Spec FK)
Relay, Ignition
Gasket, Horn Air
Screw, Cap Hex Head
(#1032 x 1/2)
Screw, Head Hex Washer
(1/420 x 1/2)
Screw, Cap Hex Washer
(#1032 x 1/2)
Clamp, Hose
(9/16 to11/16)
Hose, Fuel
Spec FK (8 Long)
Spec L & Up (71/4 Long)
Regulator
Spec FK
Spec L & Up (LPG Vapor)
Spec L & Up (LPG Liquid)
Bushing, Reducer (3/8 x 1/4)
Bracket, Mounting Zinc Plated
Screw, Head Hex Washer
(1/410 x 3/4)
Screw, Cap Hex Head
(1/420 x 31/2)
Washer, Flat (1/4)
Element, Cleaner Air
Housing, Cleaner Air
Elbow, Reducing 90
Adapter, Cleaner Air
Screw, Hex Washer Head
(1/420 x 5/8)
Washer, Lock (1/4)
Elbow, 90
Bracket, Mounting Filter
Bottom Outlet Exhaust
Front Outlet Exhaust
Filter, LPG (Includes Element
and ORings)
Element, Filter Fuel
Screw, Head Pan
(1/420 x 1/2))
Elbow, Street 45 (Front
Outlet, Exhaust Manifold)
Elbow, Male 90
Front Outlet, Exhaust
Manifold LP Liquid
Bottom Outlet, Exhaust
Manifold

REF
NO.

PART
NO.

QTY
USED

33

3072478

34
35

1542495
502092801

2
1

36
37
38

5010525
3369679
8150664

1
1
1

39

40

502096501

41

502092901

42

3072501

43

8150176

44
45
46
47

8700221
5031190
5260003
8000033

1
1
1
4

48
49
50

7401006
1231615
5030183

4
1
1

51

5031133

52
53
54

1480897
149203201

1
1

3382317

3382644

3382317

3570067

3231440
3231486

1
1

3320147
3320806

1
1

3321992
3321993

2
2

55
56

57

58

PART
DESCRIPTION
Solenoid, Lock Fuel (Front
Outlet Exhaust Manifold)
LP Liquid
Gasket, Manifold Intake
Adapter, Reducer (Front
Outlet Exhaust Manifold)
Line, Fuel
Lead
Screw, Torx Thread Form
(1/420 x 3/8)
Manifold, Exhaust (See Exhaust
System Pages)
Elbow, Reducing 45 (Bottom
Outlet, Exhaust Manifold) LP
Gas
Nipple, Close (Bottom Outlet,
Exhaust Manifold)
Valve, Fuel Shutoff LP Gas
(Bottom Outlet, Exhaust
Manifold)
Screw, Machine Hex Head
(#832 x 1/2)
Nut, Hex (#832)
Clamp, Hose
Washer, Flat (#8)
Screw, Cap Hex Head
(5/1618 x 2)
Washer, Flat (M8)
Tube, Breather
Clamp, Hose Breather
Tube (9/16 to 11/16)
Clamp, Hose Breather
Tube (Fits Hose O.D. .875)
Washer, Mounting Regulator
Bracket, Fuel Line Zinc Plated
Harness, Wiring Ignition
Relay
BGE
Spec FG (Includes Parts
Marked *)
Begin Spec H (Includes
Parts Marked +)
BGEL (Includes Parts
Marked *)
*+Rectifier, Silicon
Pin, Contact
* Brass, Gold Plated
+ 13 Ampere
Terminal, Ring
* #10 Red
+ #8 Blue
Terminal, Receptacle
* Red
+ Blue

* Parts Included in Wiring Harness.


+ Parts Included in Wiring Harness.

21

Governor

9
10
8
15

1
5

14

13

6
1
11
7
12
REF
NO.

PART
NO.

QTY
USED

8700131

2
3
4

1500096
1501612

1
1

150195802
150229801
5180006

1
1
1

5
6

7
8

1501957
1502079
1502493
1500939
1502294

1
1
1
1
1

1502295

PART
DESCRIPTION
Nut, Hex SelfLocking
(#1032)
Stud, Adjustment Speed
Spring, Governor
Bracket, Governor Zinc Plated
Gasoline
LP Liquid
Clip, Retaining BGE (Spec H)
Rod, Governor
BGE
Gasoline
LP
BGEL
Joint, Ball
Cable, Adjust Governor
(Begin Spec H)
Bracket, Cable Governor
Adjust

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

10
11

5180582
1502421

1
1

1502428
1502468
1502589

1
1
3

5180606

1502454

1502493

Retainer Push On
*Spring, Compression (Begin
Spec H)
Rod, Throttle
* Gasoline
LP Liquid/Vapor
*Washer, Friction (Begin
Spec H)
*Clip, Linkage (Begin Spec H)
Kit, Damper
Gasoline (Includes Parts
Marked *)
LP (Includes Parts Marked )

12

13
14
15

* Included in Gasoline Damper Kit.


Included in LP Damper Kit.

22

Carburetor Components
(Gasoline)

7
6

1
2

REF
NO.

PART
NO.

QTY
USED

1
2
3

1460455
1460577
1460630
1460449
1460450
1460453

1
1
1
1
1
1

1460457

1460588

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

Carburetor, Complete
(Includes Mounting Gaskets)
Spec FJ
Begin Spec K
Begin Spec L & Up
Jet, Idle
Jet, Power
Kit, Float (Includes Float,
Pin and Valve and Set Screw
Kit, Repair (Includes Gasket
Package, Float Valve, Idle
Adjust Needle and Spring,
Mounting Gaskets, Adjust
Limit Caps, Throttle Stop
Screw and Spring)
Begin Spec K
Kit, Choke Bimetal (Includes
Holder, Thermostat Cover,
Set Plate and Case Set
Screw)

1460589

7
8

1460590
1460591

1
1

1460592

Kit, Choke Breaker (Includes


Piston Rod, Link Washer,
Snap Pin and Breaker)
Kit, Vacuum Sustain Valve
Kit, Vacuum Valve Hose
(Includes Valve and Hoses)
Kit, Choke Shaft (Includes
Choke Shaft, Collar, Arm
Return Spring, Valve, Set
Screw and Lever)

23

Carburetor Components
(LP)

15
8
12
6

14

16

13

11
10

REF
NO.

1
2
3
4
5
6

PART
NO.

QTY
USED

1410932
1460723
1460727
1410708
1410906
1410919
1410940
1410935

1
1
1
1
2
1
1
1

1410938
1410978

1
1

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

Carburetor, Complete
Spec FK
Spec L & Up (LPG Liquid)
Spec L & Up (LPG Vapor)
Bowl, Fuel
Screw, Head Round Washer
Plate, Throttle
Seal, Dust
Spring, Needle Idle
Tube, Idle Rubber
Spec FK
Begin Spec L

7
8
9
10
11
12
13
14
15
16

1410701
1410700
1410711
1410736
1410077
1410934
1410936
1410939
1410937
1410924

1
1
1
1
1
1
1
1
1
1

24

PART
DESCRIPTION
Gasket, Bowl
Screw, Stop Throttle
Spring, Stop Throttle
Plug, Bowl
Washer, Plug Bowl
Screw, Adjust Main Jet
Lever, Shaft Throttle
Spring, Screw Main Jet
Needle, Adjust Idle
Seal, Rubber Dust

Electronic Ignition
Begin Spec G
12

11
7
2

14
5

18
15

4
17

10

16

13
6

REF
NO.
1
2

PART
NO.
1601368
160134501

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

1
1

Gasket, Plate
Plate, Cover Ignition Plunger
Zinc Plated
Coil, Ignition (Includes Nuts)
Through S/N G923938483
During Spec J
Begin S/N G923938484
During Spec J
Screw, Head Hex Washer
Thread Form (1/420 x 5/8)
Rotor Assembly, Ignition
(Includes Rotor and Magnet)
Plug, Spark
Cable, Plug Spark
9 Long
23 Long
Washer, Flat (M6)
Nut, Flange Hex (M4)
(Positive Terminal)
Bracket, Control Ignition

11

8000004

12

1660771

1660821
166082101
8150650

1
1
2

8700328

166078901

1660747

17

8150770

18

3323198

3
1660761

1660820

8150290

1660842

6
7

167026301

167161501
1671602
7401004
1660770

1
1
2
1

1660793

8
9
10

13

14
15
16

25

PART
DESCRIPTION
Screw, Cap Hex Head
(1/420 x 5/8)
Nut, Flange Hex (M5)
(Negative Terminal)
Control, Ignition
15.0 Lead
28.5 Lead
Screw, Head Hex Washer
(1/420 x 1)
Nut, SelfLock (1032)
Bracket, Coil Ignition
Through S/N G923938483
During Spec J
Begin S/N G923938484
During Spec J
Screw, Head Hex Washer
Thread Form
Connector

Ignition System
Spec E, F

9
1
12
2
6

10

11

4
8

REF
NO.

PART
NO.

QTY
USED

1660772

2
3

1660747

1671602
1671602
8150261

1
1
1
1
1

5
6

3120249
8502005

1
2

PART
DESCRIPTION
Coil, Ignition (Includes Nuts and
Washers)
Clamp, Coil
Cable, Plug Spark
9 Long
26 Long
Screw, Head Hex Washer
Thread Cutting (1/420 x 1/2)
Condenser, Ignition
Washer, Lock (M8)

26

REF
NO.

PART
NO.

QTY
USED

1601325

1601368

9
10

1670272
8020034

2
2

11
12

8500038
1660554

2
2

PART
DESCRIPTION
Box, Breaker (See Separate
Page For Components)
(Includes Mounting Gasket)
Gasket, Mounting Breaker
Box
Plug, Spark
Screw, Cap Socket Head
(1/420 x 3/4)
Washer, Lock Spring (1/4)
Nut, Hex (8 MM)

Breaker Box
Spec E, F

11

8
9

10
4

REF
NO.

1
2
3

4
5

PART
NO.

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

1601325

1601317
1601316

1
1

2
1
1
1
1

6
7
8
9
10
11

8500038
1601183
1601314
1601368
3362378

3120246
3120256

8150358
8150340

1
1

1601151
8020034

1
2

Box Assy, Breaker (Includes


Parts Marked *)
*Clip, Cover Breaker Box
*Cover, Box Breaker
Condenser, Ignition
Units Built Prior to 9/87
Mounts Inside Breaker Box
Units Built Beginning 9/87
Mounts Remote Attached to
Generator Adapter
Plunger, Points Breaker
*Screw, Cap Socket Head
(1/420 x 3/4)

PART
DESCRIPTION
*Washer, Lock Spring (1/4)
*Points, Breaker
*Base, Box Breaker
*Gasket, Box Breaker
Lead, Box Breaker
*Screw, Hex Head Slotted
Thread Form (#832 x 5/16)
Use Prior to 9/87
Begin 9/87

* Parts Included In Breaker Box.

27

Starter

4
1

7
6
7

5
2

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

Starter, 12 Volt (See Separate


Page For Components)
Lead, Starter (Includes Tube)
Screw, Hex Head Cap
(3/816 x 11/2)

4
5
6
7
8

8500050
3320942
8500040
8620001
8620003

2
1
1
2
2

1911667

2
3

2263457
8000052

1
2

28

PART
DESCRIPTION
Washer, Lock (3/8)
Tie, Cable
Washer, Lock (1/4)
Nut, Hex (1/420)
Nut, Hex (3/816)

Starter Components

2, 4
3,5

REF
NO.

PART
NO.

QTY
USED

1911667

1912158

1
2
3

1911781
1911776
1912129

1
1
1

4
5

1912186
1912187

1
1

PART
DESCRIPTION
Starter, 12 Volt (Spec FK Thru S/N
1933079632 During Spec K) (Includes
Parts Marked*)
Starter, 12 Volt (Begin S/N 1933079633
During Spec K) (Includes Parts
Marked #)
*Cap, End (Includes Brushes)
*Cap, End Drive
*Kit, Drive Starter (Includes
Spring Cover, Clutch Retainer,
Clutch, Spline, Gear, Roll Pin
and Hardware)
#Cap, Drive
#Kit Assembly, Drive (Includes Washers,
Retainers, Spring, Cover, Roll Pin, Pinion
Gear, and Drive Clutch)

* Parts Included in Starter Units Thru S/N 1933079632 During Spec K.


# Parts Included in Starter Units That Begin S/N 1933079633 During Spec K.

29

LP Vapor Fuel System


Field Conversion Kit 1480913 (Spec FL)

19
4
20

8
14

13

23

17
11

19
15

16
3

12

10
6

18
9
21
22

5
2

REF
NO.

PART
NO.

11

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

Kit, LP Conversion (Spec FL)


(Includes all Parts on this
Page)
Bracket, Regulator Gas
Regulator, Gas
Clamp, Insulated (1/4 OD)
Hose, Oil (Vent ) 12 Long
Hose, Fuel 30 Long
Clamp, Hose (#4)
Connector, Hose
Nut, Hex (1/420)
Connector, Hose
Elbow, Street 90
Nipple, Pipe (3/4 x 3.00 Lg)
Solenoid and Terminal

14
15
16

5050057
8540010
8130117

1
3
3

17
18
19
20

1402308
8500040
5260018
1140023

2
2
2
2

21

8000028

22

8700257

23

1480912

Plug, Head Square


Washer, Lock IT (#10)
Screw, Machine Round Head
(#1032 x 15/8)
Gasket, Adapter Air Intake
Washer, Lock (1/4)
Washer, Flat (1/4)
Screw, Cap Hex Head
(1/420 x 11/4)
Screw, Cap Hex Head
(5/1618 x 1)
Nut, Hex Self Locking
(5/1618)
Adapter, Carburetor

1480913

2
3
4
5
6
7
8
9
10
11
12
13

1480843
1480311
5180350
5031016
5031048
5030183
5020238
8620001
5020395
5050051
5050332
3071881

1
1
1
1
1
2
1
2
1
2
1
1

30

LP Vapor Fuel System


Field Conversion Kit 148105701 & 148110801 (Begin Spec M)
23

22
27
15

23
24

28

21

23

27
24
23

17
22

26
25
16

30

11
12

29

21
17
29
7
16

19
18

20
REF
NO.

PART
NO.

QTY
USED

1
148105701

148110801

2
3
4
5

G267
98731508
1402308
1410958

1
1
2
1

1460727

1481107

8
9
10
11

G328
986455
5050120
8000028

1
1
1
2

12

8700257

13

8530013

PART
DESCRIPTION

Kit, Conversion
LPG Vapor (Begin Spec M)
(Includes Parts Marked #)
LPG Vapor (Begin Spec M)
(Includes Parts Marked <)
#<Instruction Sheet (Not Shown)
#<Label, Kit Number (Emissions)
#<Gasket, Airhorn
#<Gasket, Carburetor
(Not Shown)
#<Carburetor, LPG (Emissions)
(Not Shown)
#< Kit, LP Accessory (Includes
Parts Marked *)
*Instruction Sheet (Not Shown)
* Label, LP Kit
*Elbow, Street (3/8) (Not Shown)
*Screw, Hex Head Cap
(5/1618 x 1)
*Nut, Self Locking Hex
(5/1618)
*Washer, ET Lock (1/4)
(Not Shown)

3, 9

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

14

8210009

15
16
17
18
19
20
21
22
23
24
25
26
27
28

5180350
5031016
5020395
5050101
5050131
3072880
5050057
5031048
5030183
5020238
8620001
8500040
5260018
8000008

1
1
1
1
1
1
1
1
2
1
2
2
2
2

29
30

1480843
1481020

1
1

*Screw, Self Locking Hex Head


(1/420 x 3/8) (Not Shown)
*Clamp, Insulated
*Hose, Oil (Vent) 12 Long
*Connector, Hose
*Nipple, Close (3/8)
*Bushing, Reducer
*Valve, Fuel Shutoff
*Plug, Square Head
*Hose, Fuel
*Clamp, Hose
*Connector, Hose
*Nut, Hex (1/420)
*Washer, Lock (1/4)
*Washer, Flat (1/4)
*Screw, Hex Head Cap
(1/420 x 11/4)
*Bracket, Gas Regulator
*Regulator, Gas

# Parts Included in 148105701 LPG Vapor Conversion Kit.


< Parts Included in 148110801 LPG Vapor Conversion Kit.
* Parts Included in 1481107 LP Accessory Kit.

31

Air Housing

1
9

13

11

5
14

4
10

10
12

32

Air Housing
REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

Screw, Head Hex Washer


Selflocking (1/420 x 1/2)
Scroll (Includes Baffle)
Screw, Hex Head Flanged
SelfLocking (5/1618 x 1)
Backplate, Scroll
Screw, Hex Head
SelfTapping (1/420 x 1/2)
Housing, Air Cylinder (Lt)
Housing, Air Cylinder (Rt)
Guard, Scroll
Shield, Noise (BGE Sets Only)
Spec FG
Begin Spec H

10
11
12

8560010
5170283
8000048

3
1
1

13
14

403152301 2
8700415
6
8210009
11

Washer, Lock EIT (3/8)


Plug, Button Dot
Screw, Cap Hex Head
(3/816 x 3/4)
Bracket, Lifting
Nut, SelfTapping (1/8)
Screw, Head Hex Washer
SelfLocking (1/420 x 3/8)
Not Shown

8210010

2
3

1344463
8150759

1
2

4
5

1344354
8150261

1
4

6
7
8
9

1344353
1344352
1344348

1
1
1

1552579
155255551

1
1

33

Exhaust System Above Floor Models

18 19

27

22
16

28

23
24

25

10

25
5
6

26

9
17

15

21

3
12
1

11

8
13

20

30
29
21

6
20

15

14
5
34

Exhaust System
Above Floor Models
REF
NO.

PART
NO.

QTY
USED

1
2

1542551
1542627

1
1

3
4

7401006

1552049
155204902
1542542

1
1
1

7
8

1542540
1542683
1542718
155202502
8000730

1
1
1
1
2

8000007

8000026

8000036

11
12
13

8700212
7401004
1551258

1
1
1

14

1551485

5
6

10

PART
DESCRIPTION
Manifold, Exhaust Gasoline
Manifold, Exhaust LP
(Includes Fuel Line and Heat
Shield)
Washer, Lock (5/16)
Bracket, Exhaust
Spec FJ
Begin Spec K
Gasket, Exhaust
Adapter, Exhaust (Flange
Type)
41/4 Long
61/4 Long
8 Long
Strap, Muffler (5.77 Long)
Screw, Cap Hex Head
(5/1618 x 1)
Screw, Cap Hex Head
(1/420 x 1)
Screw, Cap Hex Head
Use without Spacer
(5/1618 x 3/4)
Use with Spacer
(5/1618 x 23/4)
Nut, SelfLock (1/420)
Washer, Flat (M6)
Muffler, Arrester Spark
(Inlet/Outlet on Opposite Ends)
Muffler, Arrester Spark

REF
NO.

PART
NO.

QTY
USED

15
16
17
18

1551239
1552174
1551015

1
1
1

8150261
8150290
155202602
1542746
8000026

2
2
1
2
4

23

1552036
1542538
8000005

1
1
1

24
25

5260018
8210029

1
2

26
27
28

1542662
1542663
3704027

1
1
1

29

1552449

30

1542537

19
20
21
22

35

PART
DESCRIPTION
(Inlet/Outlet on Same End)
Clamp, Muffler (15/8)
Hanger, Exhaust
Clamp, Muffler (11/2)
Screw, Head Hex Washer
Thread Form
Spec EF(1/420 x 1/2)
Begin Spec G (1/420 x 5/8)
Strap, Muffler
Gasket, Manifold Exhaust
Screw, Cap Hex Head
(5/1618x3/4)
Bracket, Manifold Exhaust
BGEL (1.97 Long)
BGE (2.31 Long)
Screw, Cap Hex Head
(1/420 x 3/4)
Washer, Flat (1/4)
Screw, Hex Washer Head
SelfLocking (3/816 x 3/4)
Tube, Exhaust 11 Long
Bracket, Exhaust
Spacer, Muffler 2 Long
(Used Only On RVs With
61/4 Long Exhaust Adapter)
Resonator, Exhaust Gasoline
Units Only
Flange, Exhaust Manifold

Exhaust System
Below Floor Models

4
8

3
13

11
12
6

17

18

16

11

15
14

12
2

16

19

19
12

13

10

36

Exhaust System
Below Floor Models
REF
NO.

PART
NO.

QTY
USED

1
2

1542551
1542627

1
1

1552086

1552085

1552164

8000004

7
8

1552049
1551256

1
1

PART
DESCRIPTION
Manifold, Exhaust Gasoline
Manifold, Exhaust LP
(Includes Fuel Line and Heat
Shield)
Muffler, Arrestor Spark
(Inlet/Outlet on Opposite Ends)
Muffler, Arrestor Spark
(Inlet/Outlet on Opposite Ends)
Muffler, Arrestor Spark
(Inlet/Outlet on Same End)
Screw, Cap Hex Head
(1/420 x 5/8)
Bracket, Manifold Exhaust
Clamp, Muffler (11/4)

37

REF
NO.

PART
NO.

QTY
USED

PART
DESCRIPTION

9
10

8500040
8000730

2
2

11

8000026

12
13
14
15
16
17

8500045
1542539
1551015
1552174
1542746
8210029

6
1
1
1
2
2

18
19

5260130
1542542

2
1

Washer, Lock (1/4)


Screw, Cap Hex Head
(5/1618 x 1)
Screw, Cap Hex Head
(5/1618 x 3/4)
Washer, Lock (5/16)
Tube, Exhaust
Clamp, Muffler (11/2)
Hanger, Pipe Exhaust
Gasket, Manifold Exhaust
Screw, Hex Washer Head Self
Lock (3/816 x 3/4)
Washer, Flat (1/4)
Gasket, Exhaust

Housing Below Floor Models


(19851992)
(Specs 26101, 26104, 26111, 29237, 31814)

21

19
7

22

20

16

22
17

16
24

24

10
6

17
1
12

25 14

23

13

11

15
6

8 10

18
25
23

28

21

26
19

27
28

29
4

REF
NO.

PART
NO.

QTY
USED

1
2
3
4
5
6
7

4053332
4053333
4053334
4053401
5080071
5080008
8210014

1
1
1
1
3
2
2

8000002

9
10
11
12
13
14
15

5260130
8500040
4032280
4060566
4060567
4060568
8000005

2
2
1
2
2
2
6

PART
DESCRIPTION
Panel, Right Hand
Panel, Left Hand
Panel, Rear
Support, Housing
Grommet, Rubber (.62 ID)
Grommet, Rubber (.50 ID)
Screw, SelfLocking
(5/1618 x 1/2)
Screw, Cap Hex Head
(1/420 x 3/8)
Washer, Flat (1/4)
Washer, Lock (1/4)
Pan, Drip
Pin, Hinge
Plate, Hinge
Support, Hinge
Screw, Cap Hex Head
(1/420 x 3/4)

38

REF
NO.

PART
NO.

QTY
USED

16

8000048

17
18
19
20
21

5261518
4053405
4053611
4053612
8210033

4
1
2
1
2

22
23
24
25
26
27
28

8700437
8700257
5260174
5260382
5260122
98640201
8000026

2
2
4
6
4
1
4

29

5080051

26

PART
DESCRIPTION
Screw, Cap Hex Head
(3/816 x 3/4)
Washer, Flat (7/16)
Bracket, Housing
Brace, Side (22.2 Long)
Brace, Rear (27.35 Long)
Screw, Lock Hex Head
(7/1614 x 3/4)
Nut, Hex (7/1614)
Nut, Hex (5/1618)
Washer, Flat (3/8)
Washer, Flat (1/4)
Washer, Flat (5/16)
Label, Warning
Screw, Cap Hex Head
(5/1618 x 3/4)
Grommet, Rubber (1.75ID)

Housing Below Floor Models


(Begin 1992)
(Specs 26101, 26104, 26111, 29237, 31814)

12
1

15
9

11
8
9
19
21
7

10
4

23

12
11

17
4
13

10

14
4
12

15

20
14

18

16

13

22
REF
NO.
1
2
3
4
5
6
7
8
9
10
11
12

PART
NO.

QTY
USED

405476302
405476202
5080071
5260382
4060568
4060567
4060566
5260174
8000048

2
1
3
8
2
2
2
4
4

8700257
5260017
8000533

2
2
8

PART
DESCRIPTION
Brace, Side
Brace, Rear
Grommet, Rubber (.62 ID)
Washer, Flat (1/4)
Support, Hinge
Plate, Hinge
Pin, Hinge
Washer, Flat (3/8)
Screw, Cap Hex Head
(3/816 x 3/4)
Nut, Lock (5/1618)
Washer, Flat (7/16)
Screw, Cap Hex Head
(1/420 x 3/4)

39

REF
NO.

PART
NO.

QTY
USED

13
14

5260122
8000026

4
4

15

8210014

16
17
18
19
20
21
22
23

5080051
4053405
4053401
4053334
4053333
4053332
98640201
4032280

1
1
1
1
1
1
1
1

PART
DESCRIPTION
Washer, Flat (5/16)
Screw, Cap Hex Head
(5/1618 x 3/4)
Screw, Lock Head
(5/1618 x 1/2)
Grommet, Rubber (13/4 ID)
Bracket, Housing
Support, Housing
Panel, Rear
Panel, Left Hand
Panel, Right Hand
Label, Warning
Pan, Drip

Housing Below Floor Sets


(Specs 26109, 37593)

21

22

20

16

17

22
10

16

24

24

19

31

17
1
12

25 14

11

30

26

23

13

28
29

15
6

8 10

21

19

26
28

25
23

27

18

26

2
32

28
4
26

REF
NO.

PART
NO.

QTY
USED

1
2
3
4
5
6
7

4053397
4053400
4053394
4053401
5080071
5080008
8210014

1
1
1
1
3
2
2

8000002

9
10
11
12
13
14
15

5260130
8500040
403255703
4060566
4060567
4060568
8000005

2
2
1
2
2
2
6

16

8000048

PART
DESCRIPTION
Panel, Right Hand
Panel, Left Hand
Panel, Rear
Support
Grommet, Rubber (.62 ID)
Grommet, Rubber (.50 ID)
Screw, SelfLocking
(5/1618 x 1/2)
Screw, Cap Hex Head
(1/420 x 3/8)
Washer, Flat (1/4)
Washer, Lock (1/4)
Pan, Drip
Pin, Hinge
Plate, Hinge
Support, Hinge
Screw, Cap Hex Head
(1/420 x 3/4)
Screw, Cap Hex Head
(3/816 x 3/4)

40

REF
NO.

PART
NO.

QTY
USED

17
18
19
20
21

5261518
4053406
4053607
4053608
8210033

4
1
2
1
2

22
23
24
25
26
27
28

8700437
8700257
5260174
5260382
5260122
098640201
8000026

2
2
4
6
6
1
6

29
30
31
32

4053597
4053596
0985543
5080051

1
1
1
1

PART
DESCRIPTION
Washer, Flat (7/16)
Bracket
Brace, Side (251/4 Long)
Brace, Rear (291/4 Long)
Screw, Lock Hex Head
(7/1614 x 3/4)
Nut, Hex (7/1614)
Nut, Hex (5/1618)
Washer, Flat (3/8)
Washer, Flat (1/4)
Washer, Flat (5/16)
Label, Warning
Screw, Cap Hex Head
(5/1618 x 3/4)
Bracket
Support
Label, Caution
Grommet, Rubber (1.75ID)

Housing Below Floor Models


(Commercial Applications)

19
11
16

17

18
11
5

14 17
1

3
9

10

12
17
18
11
15
19

7
2
13

11
18

17

19
20
19

4
17

REF
NO.

PART
NO.

QTY
USED

1
2
3
4

4053993
4053988
4053986
4053974

1
1
1
1

5
6
7

5080071
4053996
4053955S0

3
2
1

4032727
4060655
4060657
5260122

1
2
2
8

8
9
10
11

PART
DESCRIPTION
Panel, Right Hand
Panel, Left Hand
Panel, Rear
Support (Includes Warning
Label)
Grommet, Rubber
Spacer, Brace
Support, Housing (Includes
Caution Label)
Pan, Drip
Pin, Hinge
Support, Hinge
Washer, Flat (5/16)

41

REF
NO.

PART
NO.

QTY
USED

12
13
14

4054037
4053999
8000589

1
1
4

15
16

4054000
8000029

1
2

17
18

5260174
8000026

23
6

19

8000517

20

98533401

PART
DESCRIPTION
Bracket, Housing
Bracket, Housing
Screw, Cap Hex Head
(3/816 x 11/2)
Brace, Rear (27.22 Long)
Screw, Cap Hex Head
(5/1618 x 1.12)
Washer, Flat (3/8)
Screw, Cap Hex Head
(5/1618 x 3/4)
Screw, Cap Hex Head
(3/816 x 1)
Label, Warning

42

Remote Start Control

7
4
4

REF
NO.

PART
NO.

QTY
USED

3002313

3002314

8150385

2
3
4
5
6

8600006
3013566
3080341
3013606
3020885

2
1
1
1
1

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

Kit, Control Standard


Remote Starting (Includes
Parts Marked*)
Kit, Control Deluxe Remote
Starting (Includes Parts
Marked +)
+Screw, Machine Round Head
(#632 x 1/2)
+Nut, Hex Head (#632)
*Panel, Control
*+Switch, Rocker
+Panel, Control
+Meter, Totalizing Time

7
8
9

3020888
3590034

1
1

3381082
3381080
3381081
3230400
3230500

1
1
1
1
5

PART
DESCRIPTION
+Meter, Condition Battery
+Diode
Harness, Wiring Remote
(Includes Housing and Pins)
6 Long
10 Feet Long
30 Feet Long
Housing, Connector
Pin, Contact

* Parts Included In Standard Control.


+ Parts Included In Deluxe Control.

43

Generator

38
25

36

29

21

20

28
13

37
25

10

11
25

16
17

26

25
24
8

39
14

4
23
9
44

34

19

23

35

44
27

31

15
42
9

43

33

30

41

19

12
1

40

18

32

22

44

Generator
REF
NO.
1

PART
NO.

QTY
USED

201338803

2
2204133
220453201

1
1

231028801
231038101

1
1

4
220413504

1
1
1

5
6

220413504
220413505
220413503
5100099
2121285

8150788

8
9
10
11
12
13

5090196
232295502
2140103
226349201
2040134
815069101

1
3
2
1
1
1

14
15

2121284
8021038

1
1

17

8000575
8150908
8500050

4
4
4

18

8620003

19

8150646

1
1

16

PART
DESCRIPTION

REF
NO.

QTY
USED

PART
DESCRIPTION

212127603
2121286
2050165
5080272

2
1
1
2

3040794
3040797

1
1

26

3040796
3040796
8150660

4
2
1

27
28

3320941
3040798

1
1

29

8150712

30
31

3231298

32
33
34
35

3320819
3320819
5180460
5180533
8530013
8150661

2
3
1
1
1
1

36

3050718

37

3383010

38

8150788

39
40

3323328
520096102

1
1

41
42
43
44

5260032
8500055
8700203
3310536

1
1
1
1

Spring, Brush Generator


Block, with Terminal
+Fan and Gear, Rotor
Grommet, Nylon (.68 ID)
Resistor, Charger Battery
(25 Watts)
Spec FJ
Begin Spec K
Washer, Center Resistor
Gasoline
LP Gas
Screw, Head Hex
(#1032 x 21/2)
Tie, Cable 50 Hz
Resistor, Pump Fuel
(Gasoline)
Screw, Head Pan
(#1032 x 1/2)
Connector, Tab
Connector, Receptacle
60 Hz
50 Hz
Ring, Tolerance
Clip Below floor Models
Washer, ET (#1032)
Screw, Pan Head Thread
Form (#1032 x 1/2)
Bridge, Rectifier (Begin
Spec K) (CR10)
Harness, Charger Battery
(Begin Spec K)
Screw, Pan Head
(#1032 x 7/8) (Begin Spec K)
Stud, Grounding
Stud 13.125 Long
Extended Shaft
Washer, Flat (7/16)
Washer, Lock (7/16)
Nut, Hex (7/1620)
Connector, Conduit

20
21
22
23
24

Rotor, Generator (Includes Fan,


Ball Bearing and Collector
Ring)
Housing, Stator
Spec FK
Begin Spec L
Adapter, Generator
Spec FK
Begin Spec L
Stator, Generator
60 Hz
Spec FG
Begin Spec H
120 Volts
100 Volts
50 Hz
Bearing, Ball
Block, Brush Genertor
(Includes Spring, Block, Brush)
Screw, Head Pan
(#1032 x 7/8)
ORing, Housing Stator
Clamp, Stator
Brush, Block
Lead, Resistor
Ring, Collector Rotor
Screw, Pan Head
(#1032 x 23/64)
Cover, Block Brush
Screw, Socket Rotor
Through (7/1614 x 101/4)
Screw, Hex Flange Head
Spec FK (3/816 x 11/8)
Begin Spec L (3/816 x 11/2)
Washer, Lock Spring (3/8)
(Spec FK Only)
Nut, Hex (3/816)
(Spec FK Only)
Screw, Cap Hex Washer Head
(1/420 x 3/4)

PART
NO.

25

45

Control

22

13

17
30
40

15

20
16

12
11

29

31

23
18

9
24
10
27

25

39

19

13

14

21
33
26

38

6
37

28

35
36
1

32

34

46

Control
REF
NO.

PART
NO.

QTY
USED

319123803
319123709
319123807
319123819
319123702

1
1
1
2
1

3003950
300376301
300490101
8150791

1
1
1
4

4
5
6

3080995
3210298
3210295

1
3
1

3382040

338263601
338263602

1
2

8
9
10

338276801 1
338276802 1
3382895
1
3383479
1
3382040
1
3231486
12
3231200
1
323148703 1

11

3231312

12

3231440

13

8150661

14

3072570

15

320156102

16

3201323
3201683

1
2

3201323
3201683
320154802

1
1
1

PART
DESCRIPTION

REF
NO.

Cover, Control
60 Hz
4.0
Volt Code 1R,FA
Volt Code FR
5.0
30 Amp Breakers
50 Hz
Board, Circuit Printed
Spec EG
Spec HM
Begin Spec N
Screw, Pan Head Cross
Recessed (#632 x 3/8)
Switch, Rocker
Fuse, 5 Amps SloBlow
Holder, Fuse (Holds Spare
Fuses)
Harness, Wiring PCB#1
BGE
Spec F,G
Spec H
Gas
LP
Spec J
Gas
LP
Begin Spec K
Begin Spec M & Up
BGEL
Socket, Contact (Spec H,J,K)
Socket, Contact
Housing, Connector (Spec
H,J,K)
Housing, Connector (BGE Spec
F,G, and BGEL)
Pin, Contact (BGE Spec F,G,
and BGEL)
Screw, Pan Head Thread
Forming (#1032 x 1/2)
Solenoid, Start (Includes
Nuts and Washers)
Guard, Breaker Circuit (Use
with Single Pole Breakers
Only)
Breaker, Circuit
60 Hz
4.0
30 Amp Volt Code 1R,FA
20 Amp Volt Code FR
5.0
30 Amp (CB1)
20 Amp (CB2)
50 Hz

PART
NO.

QTY
USED

8150550

815055001

3320941

305080901
305080903
8210003
8700131
2323265

1
1
1
1
1

3382076
3382083
338208301

1
1
1

17

18
19

20
21
22
23

24
25
26
27
28

3231314
3231200
3231371
3231199

1
6
1
12

332285902
332285901

1
1

30

3382045
3382058
3382058
815069202

1
1
1
1

31

3323075

32
33
34

3080949
3210287
815069101

1
1
1

35

8150385

36
37
38

5170133
3030276
8700183

1
1
1

39
40

3322112
321032302

1
1

29

47

PART
DESCRIPTION
Screw, Slotted Head IT
Use with Single CB
(#632 x 3/8)
Use with Double CB
(#632 x 5/16)
Tie, Cable
Regulator, Voltage
60 Hz
50 Hz
Screw, Hex Head (#1032 x 1)
Nut, Hex W/ET (#1032)
Clamp, Conduit
Harness, Wiring Voltage
Regulator
60 Hz Volt Code 1R,FA
60 Hz Volt Code FR
50 Hz, 120/240 Volt,
Single Phase
Housing (12 Pin)
Socket, Contact 60 Hz
Header (12 Pin)
Pin, Contact
Block, Terminal
60 Hz
50 Hz
Harness, Wiring AC Outlet
60 Hz
4.0
5.0
50 Hz
Screw, Torx Pan Head
(1/420 x 1)
Insulator,Board PC (.005
Thick)
Cover, Switch Rocker
Insulator, Fuse
Screw, Head Pan
(#1032 x 23/64)
Screw, Machine Round Head
(#632 x 1/2) 50 Hz
Plug, Hole 50 Hz
Potentiometer 50 Hz
Nut, Hex W/ET (#6)
50 Hz
Insulator, Terminal Start
Bracket, Holder Fuse (Begin
Spec K)

Breather Tube Bypass


(Cold Weather Use Only)

REF
NO.
1
2
3

PART
NO.
5031551
5021026
5170260

QTY
USED
1
1
1

PART
DESCRIPTION
Tube, Breather
Elbow, 90
Plug, Cap

48

Wiring Harness
PCB #3

REF
NO.

PART
NO.

QTY
USED

3382041

3382635

3382634
3382086

1
1

3231302

PART
DESCRIPTION

REF
NO.

Harness, Wiring
6 Pin Housing 5 Wire
Gasoline Volt Code FA
LP Liquid Begin Spec H
Volt. Code FA,FN
Gasoline Begin Spec H
6 Pin Housing BGEL
Pin, Contact
Use With 6 Pin Housing

PART
NO.

QTY
USED

3231440

3231329
3231312
323148703
3570067
3231486

1
1
1
1
1

3
4

49

PART
DESCRIPTION
Gasoline Units
Use With 8 Pin Housing
LP Liquid/Vapor
Housing
6 Pin
8 Pin
12 Pin
Rectifier BGEL
Socket, Contact

Remote Wiring Harness

1
2

10

11

5
3
5

1
REF
NO.

1
2

3
4
5

PART
NO.

QTY
USED

3381082

3382137
3382046

1
1

3231304

3230500
3230500
3230440
3231303
3230400

6
5
1
1
1

PART
DESCRIPTION
Harness, Wiring Remote
Without Socket 6 Long
(Includes 5 Connector Pins)
With Socket 6 Long
Without Socket (Includes
5 Contact Pins)
Housing, Connector
Pin, Connector Male
Use with 6 Pin Harness
Use with 5 Pin Harness
Housing, Socket Pin
Connector, 6 Pin
Housing, Connector Pin

REF
NO.

PART
NO.

QTY
USED

6
7
8
9

3230488
3320942
3231199
3383572

1
1
5
1

10
11

3231342
3231200

1
5

PART
DESCRIPTION
Socke,t Connector Female
Tie, Cable
Pin, Contact
Harness, Adapter (Includes
Parts Marked *) (Use With
Gasoline and LP Kits
3004936, 3004937, &
3002938)
*Housing, Terminal
*Socket, Contact

* Parts Included in Adapter Harness.

50

Wiring Harness
Begin Spec J

REF
NO.

PART
NO.

QTY
USED

2
3

3382766
3382767
3383054

1
1

321032201
321032106

1
1

PART
DESCRIPTION

REF
NO.

PART
NO.

QTY
USED

Harness, Wiring Engine


Spec J
Gasoline Engines
LP Liquid Engines
Begin Spec K (Includes Parts
Marked *)
*Holder, Fuse
*Fuse (F2) (Mounts Between
K1 and K4)

4
5

3071886
8150181

1
1

PART
DESCRIPTION
*Relay (K4)
*Screw, Thread Cutting
Hex Head (w/ET)
(1032 x 1/2)

* Parts Included in 3383054 Wiring Harness.

51

25Labels, Paint, Thread Sealant, Gasket Kits, and Carburetor Kits

REF
NO.

PART
NO.

QTY
USED

985313
985142
985626
985852
98616401

1
1
1
1
3

985755

985958
98577701

1
1

985815
98607402

1
1

98628502

986276
98661801
986041
98638802
98628503

1
1
1
1
1

985821
986284

1
1

986661

5180452
5180602
5250305

1
1
1

1680189

1103709
1103181
1542542
1542800
1103604
1542746
5090289
1542495
1460616

3
2
1
1
2
2
2
2
1

G0194

PART
DESCRIPTION

REF
NO.

Label, Warning (Battery Cables)


Label, Warning (Fire Hazard)
Decal (Emerald I) 60 Hz
Decal (Emerald I) 50 Hz
Label, Performer 18 Horse
power
Label, Warning (Hazardous
Voltage)
Label, LP Kit
Label, Warning (Improper
Operation)
Service Instructions BGE
Label, Warning (Operation,
Maintenance and Service)
(2.38 Size)
Decal (Onan 4000 Gen Set)
(Begin Spec H)
Label, Warning RV Units
Label, Oil Fill
Label, Warning (VoltageGas)
Label, Phone Information
Silkscreen, Model Identification
(4000)
Label, Listed RV 60 Hz
Silkscreen, Model Identification
(Emerald One)
Decal, Model Ident (Onan 5000
GenSet
Sealant, Thread (50cc. Bottle)
Loctite, Bottle (250cc)
Paint, Enamel TouchUp
Green (NonMetallic) 13 oz.
Pressurized Can
Kit, Gasket Carbon Removal
(Includes Parts Marked *)
*Gasket, Valve Box
*Gasket, Cylinder Head
*Gasket, Exhaust Manifold
*+Gasket, Exhaust Manifold
*+Seal, Intake Valve
*Gasket, Exhaust Manifold
*Seal, Valve Stem
*Gasket, Intake Manifold (BGE)
Kit, AutoChoke Carburetor
(Includes Parts Marked #)
#Instruction Sheet

PART
NO.

QTY
USED

PART
DESCRIPTION

986566
98658703
98661801
1231961
1402308
1402725
1410958
1450667
1460577
1502421
1502589
1670272
2264599
3040797
3050718
321035702
3321445
3382895
3383010
3383054
5020028
5090096
5090313
5180606
8150181

1
1
1
1
1
1
1
1
1
1
2
2
1
1
1
1
5
1
1
1
1
1
1
1
1

8150590
8150788
8620015
1460663

3
1
1
1

1460630

1410958
1402308

1
1

#Label, Fuse
#Label, Kit Number
#Label, Oil Fill
#Cap, Oil Fill
#Gasket, Airhorn SubAssembly
#Adapter Assembly
#Gasket, Carburetor
#Rod, Air Inlet
#Carburetor, Auto Choke
#Spring, Compression
#Washer, Friction
#Plug, Spark
#Lead Assembly, Engine
#Resistor
#Bridge, Rectifier
#Bracket, Fuse Holder
#Tie, Cable
#Harness, PCB #1
#Harness, Battery Charging
#Harness, Engine
#Plug, Hex Head Pipe
#Seal, ORing
#ORing
#Clip, Linkage
#Screw, Hex Head Thread
Cutting With ET
#Screw, Special
#Screw, Pan Head Torx
#Nut, Hex
Kit, Emissions AutoChoke
Carburetor (Includes Parts
Marked ~)
~Carburetor, Emissions and Auto
Choke
~Gasket, Carburetor
~Gasket, Air Horn

* Parts Included in 1680189 Gasket Kit.


+ Parts Included in 1680187 Gasket Kit.
# Parts Included in AutoChoke Carburetor Kit.
~ Parts Included in Emissions AutoChoke Carburetor Kit.

52

Numerical Index
Part No.

Page

Part No.

Page

Part No.

Page

Part No.

Page

0985142, 52

101080530, 7

1103709, 7, 52

1231174, 7

0985313, 52

1010809, 7

1120229, 7

1231175, 7

098533401, 41

1020743, 13

1120264, 7

1231615, 17, 21

0985543, 40

1021286, 13

112026401, 7

1231616, 13

0985626, 52

1021387, 13

112026402, 7

1231649, 7

0985755, 52

1021458, 13

112026403, 7

1231871, 9

098577701, 52

1030772, 15

112026405, 7

1231961, 13, 52

0985815, 52

1030810, 15

1130310, 9

1344342, 11

0985821, 52

1040032, 11

113031001, 9

1344348, 33

0985852, 52

1040043, 11

113031002, 9

1344352, 33

0985958, 52

1040170, 11

113031003, 9

1344353, 33

0986041, 52

1040575, 7

113031005, 9

1344354, 33

098607402, 52

1040776, 7

1130314, 9

1344463, 33

098610501, 17

1041735, 11

113031405, 9

1401894, 17, 21

098616401, 52

1050541, 10

113031410, 9

140191970, 17

0986276, 52

1050637, 10

113031420, 9

0986284, 52

1050700, 10

113031430, 9

1402308, 17, 21, 30, 31,


52

098628502, 52

1100197, 7

1140022, 15

098628503, 52

110019710, 7

1140023, 30

098638802, 52

1101824, 7

1140392, 7

098640201, 38, 39, 40

110182402, 7

1140397, 9

0986455, 31

110182405, 7

114039710, 9

0986566, 52

110182410, 7

114039720, 9

098658703, 52

110182425, 7

114039730, 9

098661801, 52

110187901, 7

1150006, 7

0986661, 52

1103181, 7, 52

115000602, 7

098731501, 31

1103479, 7

115000605, 7

1010405, 7

1103480, 7

1200140, 7, 17

101043901, 7

1103485, 7

1200161, 7

1010804, 7

1103487, 7

1200398, 7

101080402, 7

1103508, 7

1200491, 7

101080410, 7

1103509, 7

1201320, 7

101080420, 7

1103510, 7

122036050, 14

101080430, 7

1103511, 7

1220502, 14

1010805, 7

1103515, 7

1220645, 14

101080502, 7

1103526, 7

1220771, 14

101080510, 7

1103527, 7

1220814, 14

101080520, 7

1103604, 52

1231173, 7

53

1402379, 17, 21
1402725, 52
1402782, 17, 21
1402962, 17
1403093, 17
1410077, 24
1410281, 21
1410700, 24
1410701, 24
1410708, 24
1410710, 15
1410711, 24
1410736, 24
1410906, 24
1410919, 24
1410924, 24
1410932, 21, 24
1410934, 24
1410935, 24
1410936, 24
1410937, 24

Numerical Index
Part No.

Page

Part No.

Page

Part No.

Page

Part No.

Page

1410938, 24

148110801, 31

1530557, 17

155255551, 33

1410939, 24

1491353, 17

1530558, 17

1552579, 33

1410940, 24

149203201, 21

1530561, 17

1601151, 27

1410950, 17

1492080, 17

1530576, 17

1601183, 27

1410958, 17, 31, 52

1492140, 17

1530577, 17

1601314, 27

1410978, 24

1492226, 17

1530578, 17

1601316, 27

1450561, 17

1492269, 17

1530579, 17

1601317, 27

1450667, 17, 52

1492279, 17

1542447, 17, 21

1601325, 26, 27

1450704, 17

1492293, 17

1542495, 17, 21, 52

160134501, 25

1460449, 23

1492319, 17

1542537, 35

1601368, 25, 26, 27

1460450, 23

1492331, 17

1542538, 35

1660554, 26

1460453, 23

1492333, 17

1542539, 37

1660747, 25, 26

1460455, 17, 23

1492334, 17

1542540, 35

1660761, 25

1460457, 23

1500075, 10

1542542, 35, 37, 52

1660770, 25

1460577, 17, 23, 52

1500078, 10

1542551, 35, 37

1660771, 25

1460588, 23

1500096, 22

1542627, 35, 37

1660772, 26

1460589, 23

1500939, 22

1542662, 35

166078901, 25

1460590, 23

1501187, 15

1542663, 35

1660793, 25

1460591, 23

1501519, 10

1542683, 35

1660820, 25

1460592, 23

1501520, 10

1542718, 35

1660821, 25

1460616, 52

1501612, 22

1542746, 35, 37, 52

166082101, 25

1460630, 17, 23, 52

1501957, 22

1542800, 52

1660842, 25

1460663, 52

150195802, 22

1543026, 21

167026301, 25

1460723, 21, 24

1501998, 15

1551015, 35, 37

1670272, 26, 52

1460727, 24, 31

150200204, 15

1551239, 35

1671602, 25, 26

1480311, 30

1502079, 22

1551256, 37

167161501, 25, 26

1480843, 30, 31

1502294, 22

1551258, 35

1680189, 7, 52

1480890, 21

1502295, 22

1551485, 35

1680192, 7

1480893, 21

150229801, 22

155202502, 35

1911667, 28, 29

1480896, 21

1502421, 22, 52

155202602, 35

1911776, 29

1480897, 21

1502428, 22

1552036, 35

1911781, 29

1480898, 21

1502454, 22

1552049, 35, 37

1912129, 29

1480903, 21

1502468, 22

155204902, 35

1912158, 29

1480912, 30

1502493, 22

1552085, 37

1912186, 29

1480913, 30

1502589, 22, 52

1552086, 37

1912187, 29

1481020, 21, 31

1530554, 17

1552164, 37

201338803, 45

148105701, 31

1530555, 17

1552174, 35, 37

2040134, 45

1481107, 31

1530556, 17

1552449, 35

2050165, 45

54

Numerical Index
Part No.

Page

Part No.

Page

Part No.

Page

Part No.

Page

212127603, 45

3072501, 21

3231314, 47

3382634, 14, 49

2121284, 45

307255901, 21

3231329, 49

3382635, 14, 49

2121285, 45

3072570, 47

3231371, 47

338263601, 47

2121286, 45

3072880, 31

3231440, 21, 47, 49

338263602, 47

2140103, 45

3080341, 43

3231486, 21, 47, 49

3382644, 21

2204133, 45

3080949, 47

323148703, 47, 49

3382766, 51

220413501, 45

3080995, 47

3310536, 45

3382767, 51

220413503, 45

3090322, 14

3320147, 21

338276801, 47

220413504, 45

3120246, 27

3320806, 21

338276802, 47

220413505, 45

3120249, 26

3320819, 45

3382895, 47, 52

220453201, 45

3120256, 27

3320941, 45, 47

3383010, 45, 52

2263457, 28

319123702, 47

3320942, 28, 50

3383054, 51, 52

226349201, 45

319123709, 47

3321445, 52

3383479, 47

2264599, 52

319123803, 47

3321992, 21

3383572, 50

231028801, 45

319123807, 47

3321993, 21

3570067, 21, 49

231038101, 45

319123819, 47

3322112, 47

3590034, 43

232295502, 45

3201323, 47

332285901, 47

3704027, 35

2323265, 47

320154802, 47

332285902, 47

3704052, 17

3002313, 43

320156102, 47

3323075, 47

4020547, 13

3002314, 43

3201683, 47

3323198, 25

4020549, 13

300376301, 47

3210287, 47

3323328, 45

4020597, 13

3003950, 47

3210295, 47

3362378, 27

403152301, 33

300490101, 47

3210298, 47

3369679, 21

403221801, 13

3013566, 43

321032106, 51

3372311, 13

4032280, 38, 39

3013606, 43

321032201, 51

3381080, 43

403255702, 13

3020885, 43

321032302, 47

3381081, 43

403255703, 40

3020888, 43

321035702, 52

3381082, 43, 50

4032727, 41

3030276, 47

3230400, 43, 50

3382040, 47

4053332, 38, 39

3040794, 45

3230440, 50

3382041, 14, 49

4053333, 38, 39

3040796, 45

3230488, 50

3382045, 47

4053334, 38, 39

3040797, 45, 52

3230500, 43, 50

3382058, 47

4053394, 40

3040798, 45

3231199, 47, 50

3382076, 47

4053397, 40

3050718, 45, 52

3231200, 47

3382083, 47

4053400, 40

305080901, 47

3231298, 45

338208301, 47

4053401, 38, 39, 40

305080903, 47

3231302, 49

3382086, 14, 49

4053405, 38, 39

3071881, 30

3231303, 50

3382137, 50

4053406, 40

3071886, 21, 51

3231304, 50

3382285, 17

4053596, 40

3072478, 21

3231312, 47, 49

3382317, 21

4053597, 40

55

Numerical Index
Part No.

Page

Part No.

Page

Part No.

Page

4053607, 40

5021108, 17

5100099, 45

4053608, 40

5021164, 17

5150001, 10, 11

4053611, 38

5030170, 19

5150263, 11

4053612, 38

5030183, 17, 21, 30, 31

5160072, 7

4053955S0, 41

5030633, 21

5160130, 15

4053974, 41

5030813, 17

5160141, 7

4053986, 41

5031016, 30, 31

517004801, 7

4053988, 41

5031048, 30, 31

5170067, 7

4053993, 41

5031133, 17, 21

5170133, 47

4053996, 41

5031190, 21

5170223, 17

4053999, 41

5031252, 17

5170260, 48

4054000, 41

5031313, 17

5170283, 33

4054037, 41

5031351, 17

5180006, 22

405476202, 39

5031365, 21

5180014, 11

405476302, 39

5031551, 48

5180311, 7

4060566, 38, 39, 40

5040150, 13

5180350, 30, 31

4060567, 38, 39, 40

5050051, 30

5180387, 17

4060568, 38, 39, 40

5050057, 30, 31

5180450, 17

4060655, 41

5050101, 31

5180452, 52

4060657, 41

5050120, 31

5180459, 17

5010525, 21

5050131, 31

5180460, 45

5020002, 17

5050266, 13

5180466, 17

5020028, 19, 52

5050332, 30

5180515, 19

5020054, 21

5051426, 21

5180533, 45

5020065, 19

5080008, 38, 40

5180582, 22

5020238, 30

5080051, 38, 39, 40

5180602, 52

5020313, 17

5080071, 38, 39, 40, 41

5180606, 22, 52

5020395, 30, 31

5080272, 45

520096102, 45

5020838, 21

5090008, 15

5250305, 52

502092701, 21

5090040, 15

5260002, 17

502092801, 21

5090041, 7

5260003, 21

502092901, 21

5090096, 13, 52

5260017, 11, 39

502093201, 21

5090196, 45

5260018, 7, 30, 31, 35

502093301, 21

5090289, 7, 52

5260021, 17, 21

5020935, 21

5090313, 52

5260032, 45

502096501, 21

5100013, 15

5260063, 7

5021026, 48

5100014, 15

5260065, 14, 15

5021105, 17

5100015, 10

5260066, 7

56

Part No.

Page

5260122, 7, 38, 39, 40,


41
5260130, 37, 38, 40
5260174, 38, 39, 40, 41
5260240, 13
5260251, 13
5260324, 13
5260325, 13
5260356, 11
5260382, 38, 39, 40
5260402, 7
5261518, 38, 40
5410532, 21
7401004, 7, 25, 35
7401006, 17, 19, 21, 35
8000002, 38, 40
8000004, 25, 37
8000005, 35, 38, 40
8000007, 7, 35
8000008, 31
8000010, 7
8000017, 17, 21
8000026, 35, 37, 38, 39,
40, 41
8000028, 14, 30, 31
8000029, 41
8000033, 17, 19, 21
8000036, 35
8000048, 33, 38, 39, 40
8000051, 7
8000052, 28
8000058, 13
8000517, 41
8000533, 39
8000545, 15
8000571, 7
8000575, 7, 45
8000589, 41

Numerical Index
Part No.

Page

Part No.

Page

Part No.

Page

Part No.

Page

8000730, 35, 37

8150592, 17

8210003, 47

8560008, 13

8010049, 7

8150646, 45

8210005, 21

8560010, 33

8020034, 26, 27

8150647, 21

8210009, 31, 33

8600006, 43

8021038, 45

8150650, 25

8210010, 13, 33

8620001, 28, 30, 31

8030071, 7

8150657, 13

8210014, 13, 38, 39, 40

8620003, 28, 45

8130117, 30

8150660, 45

8210016, 13

8620015, 17, 21, 52

8150046, 15

8150661, 45, 47

8210029, 35, 37

8700131, 22, 47

8150176, 21

8150664, 17, 21

8210031, 13

8700183, 47

8150181, 51, 52

815069101, 45, 47

8210033, 38, 40

8700203, 45

8150261, 21, 26, 33, 35

815069201, 17, 21

8500038, 26, 27

8700212, 35

8150290, 17, 25, 35

815069202, 17, 47

8700221, 21

8150340, 14

8150712, 45

8500040, 21, 28, 30, 31,


37, 38, 40

8150358, 27

8150759, 33

8150385, 43, 47

8150770, 25

8150550, 47

8150782, 19

815055001, 47

8150788, 45, 52

8150587, 17, 21

8150791, 47

8150590, 17, 21, 52

8150908, 45

8150591, 17, 21

8201077, 15

8500045, 37

8700257, 15, 30, 31, 38,


39, 40

8500050, 7, 28, 45

8700328, 15, 25

8500055, 45

8700415, 33

8502005, 26

8700421, 17

8510031, 15

8700437, 38, 40

8530013, 17, 31, 45

8700533, 7

8540010, 30

57

You might also like