Professional Documents
Culture Documents
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 45
Make: Model: Year:
Jeep Cherokee 1983
FUNCTON COLOR LOCATON
Start: LGHT BLUE GNTON SWTCH HARNESS
gnition #1: RED/TAN GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: L GREEN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: D GREEN GNTON COL *
Parking Lights: WHTE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Carburated Engine!!
Jeep Cherokee 1983
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATORS N ALL DOORS **
Power Unlock: ADD ACTUATORS N ALL DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH OR COURTESY LGHT
NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 45
Make: Model: Year:
Jeep Cherokee 1984-1987
FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/TAN AT GNTON MODULE *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * 1987 4.0L Engine s Electronic Fuel njection, Rest Are Carburated Or Throttle Body
njection.
Jeep Cherokee 1984-1987
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL **
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT PN SWTCH OR COURTESY LGHT
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below
Passenger Dash And See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 45
Make: Model: Year:
Jeep Cherokee 1988-1990
FUNCTON COLOR LOCATON
Start: DARK GREEN GNTON SWTCH HARNESS
gnition #1: YELLOW GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: LGHT BLUE/BLACK OR LGHT BLUE (+) AT SWTCH
Tach Signal: GREEN/TAN OR GREEN AT GNTON MODULE OR DASH TACH *
Parking Lights: DARK BLUE (+) AT LGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * 4.0L Engine Only s Electronic Fuel njection. Rest Are Carburated Or Throttle Body
njection.
Jeep Cherokee 1988-1990
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/TAN OR BLACK/WHTE (-) AT PN SWTCH
OEM Horn: GRAY/RED OR BLACK (-) STEERNG COLUMN HARNESS
Power Lock: WHTE LOCATED N DRVER'S KCK PANEL **
Power Unlock: DARK GREEN LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/TAN OR BLACK/WHTE (-) AT PN SWTCH
NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry: Lock - L GREEN, Unlock - TAN, Find Wires At Relays Below
Passenger Dash And See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 45
Make: Model: Year:
Jeep Cherokee 1991-1992
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS (BLOWER)
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: GRAY AT COL OR PN 19 AT PCM *
Parking Lights: DARK BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module (PCM) Located On Driver nner Fender Panel, Behind
Duct. GRAY Tach Wire At Pin #19, Second Tach Wire GRAY/L BLUE At Pin #43.
Jeep Cherokee 1991-1992
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: PURPLE/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET DRVER KCK PANEL OR AT RELAYS
Power Unlock: PNK/VOLET N PASSENGER KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 45
Make: Model: Year:
Jeep Cherokee 1993-1995
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: DARK BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HANNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: BLACK/GRAY AT COL OR PCM *
Parking Lights: DARK BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module (PCM) Located On Driver nner Fender Panel, Behind
Duct. GRAY Tach Wire At Pin #19, Second Tach Wire GRAY/L BLUE At Pin #43.
Jeep Cherokee 1993-1995
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GN SWTCH HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: PURPLE/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET LOCATED N DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET LOCATED N DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH OR COURTESY LGHT
NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 45
Make: Model: Year:
Jeep Cherokee 1996
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: D BLUE GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: VOLET GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/GRAY AT COL *
Parking Lights: D BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * GRAY Wire At Powertrain Control Module (PCM) Or GRAY/L BLUE Wire At PCM Can
Also Be Used For Tach Signal. PCM Located On Driver Fender Shield On Driver Side Of Engine
Comaprtment.
Jeep Cherokee 1996
FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
YELLOW (-) AT ANY PN SWTCH
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: ORANGE/VOLET LOCATED N DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET LOCATED N DRVER'S KCK PANEL **
Trunk Release: PNK/BLACK (+) (LFTGATE UNLOCK)
Alarm nput Wire: YELLOW (-) AT ANY PN SWTCH
NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 45
TACH GRAY
@ PCM, BLACK Plug, See
NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A
EXTRA NFORMATON
NOTE *1 When testing the LOCK and UNLOCK wires, make sure the doors are closed. NOTE *2 the
PCM (Powertrain Control Module) is located on the DRVERS SDE nner Fender well near the
Radiator Support.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 45
TRUNK RELEASE
ORANGE/PURPLE (-) See
NOTE *4
N DRVERS KCK PANEL or
CLUSTER, Connector 3, Pin 8
SLDNG POWER DOOR N/A
HORN DARK GREEN/ORANGE (+)
@ HORN or MP, Connector 2,
Pin 35, See NOTE *5
TACH
ANY wire NOT RED/TAN or
DARK GREEN/LGHT GREEN
@ ANY GNTON COL or
FUEL-NJECTOR
WAT TO START LGHT N/A
BRAKE WHTE/TAN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!
ANT-THEFT
CHRYSLERS SENTRY
TRANSPONDER ANT-THEFT
SYSTEM
@ GNTON TUMBLER
EXTRA NFORMATON
NOTE *1 THE STARTER #2 AND ACCESSORY WRE are the same, The STARTER #2 wire
requires a (-) Negative thru a 180 Ohm resistor, and an extra Relay , the ACCESSORY wire requires
a (-) Negative thru a 560 Ohm resistor and an extra relay to connect NOTE *2 This vehicle uses a 1-
Wire Door Locking System, the LOCK requires a (-) Negative thru a 330 Ohm resistor the UNLOCK
requires a (-) Negative thru a 100 Ohm resistor. Some units will also require extra relays Part 778 to
connect S. NOTE *3 The DRVERS DOOR is a PURPLE (-) at Pin 6, the PASSENGER DOOR is a
PURPLE/WHTE (-) Pin 7, the DRVERS REAR DOOR is a PURPLE/GRAY (-) Pin 4 and the
PASSENGER REAR DOOR is a PURPLE/YELLOW Pin 5 when connecting to an ALARM SYSTEM
use all 4 wires ans DODE SOLATE NOTE *4 TEST this wire while opening the REAR GLASS from
the SWTCH on the REAR HATCH NOTE *5 The PM (ntegrated Power Module) is located on the
DRVERS FENDER, behind the BATTERY
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 45
Make: Model: Year:
Jeep Grand Cherokee 1993-1995
FUNCTON COLOR LOCATON
Start: YELLOW/DARK BLUE GNTON SWTCH HARNESS
gnition #1: DARK BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: ORANGE/BLACK GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE/TAN (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal:
GRAY/WHT OR
GRAY/BLACK
AT COL OR PCM *
Parking Lights: DARK BLUE/RED (+) HEADLGHT SWTCH OR AT FUSE BOX
Headlights: TAN/BLACK (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module (PCM) Located n Passenger Rear Corner Of Engine
Compartment Near A/C Receiver/Dryer. Tach Wire At Pin #19, GRAY/L BLUE At Pin #43 Can
Also Be Used For Tach.
Jeep Grand Cherokee 1993-1995
FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE FUSED AT
40
AMP AND PNK/BLACK FUSED AT 60 AMP
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) DRVER KCK PANEL OR COURTESY
LGHT
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: ORANGE/VOLET DRVER'S KCK PANEL **
Power Unlock: PNK/VOLET DRVER'S KCK PANEL **
Trunk Release: ORANGE/BROWN (+) LFT GLASS RELEASE (AT SWTCH)
Alarm nput Wire: YELLOW (-) DRVER KCK PANEL OR COURTESY
LGHT
NOTES: ** See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 45
Make: Model: Year:
Jeep Grand Cherokee 1996
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: D BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: RED/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY/WHTE AT GNTON COL
Parking Lights: BLUE/RED (+) AT HEADLGHT SWTCH
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Jeep Grand Cherokee 1996
FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER KCK PANEL
Dome
Lights/Superv:
YELLOW (-) BLACK 10 PN CONNECTOR AT FUSE
BLOCK
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: D\ ORANGE/VOLET P\ BLACK/WHTE *
Power Unlock: R/ PNK/BLACK S/ PNK/BLACK *
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) BLACK 10 PN CONNECTOR AT FUSE
BLOCK
NOTES: * See Note #230 - Jeep Grand Cherokee Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 45
Make: Model: Year:
Jeep Grand Cherokee 1997-1998
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: D BLUE/GRAY GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: RED/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/TAN (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GRAY/WHTE AT GNTON COL OR PCM *
Parking Lights: D BLUE/RED (+) AT HEADLGHT SWTCH ***
Headlights: TAN/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module (PCM) Located On Passenger Rear Of Engine.
Jeep Grand Cherokee 1997-1998
FUNCTON COLOR LOCATON
Constant +12 Volts: RED/WHTE (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: VOLET/YELLOW (-) DRVER'S KCK PANEL
Dome
Lights/Superv:
YELLOW (-) AT COURTESY LGHT **
OEM Horn: GRAY/ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/
ORANGE/VOLET
PASSENGER/ BLACK/WHTE ****
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ****
Trunk Release: N/A
Alarm nput Wire: YELLOW (-) AT COURTESY LGHT **
NOTES: ** YELLOW (-) Wire Also Located n 12 Pin Yellow Connector At Fuse Block. *** Body
Control Module (BCM) Located Behind Driver Dash. **** See Note #230 - Jeep Grand Cherokee
Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 45
Make: Model: Year:
Jeep Grand Cherokee 1999-2002
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: DK. BLUE GNTON SWTCH HARNESS
gnition #2: BLACK/ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/WHTE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking Lights: BLACK/YELLOW (-) N DRVER'S KCK PANEL ****
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System
Only f The gnition Key s Gray. Use a universal alarm bypass module. **** The Parking Lights
Are Activated By A Ground Pulse Through A 240 Ohm Resistor. See Note #145 for parking light
shortcut
Jeep Grand Cherokee 1999-2002
FUNCTON COLOR LOCATON
Constant +12 Volts:
OEM Alarm Disarm: LT.GREEN/ORANGE (-) AT SWTCH N DRVER'S DOOR **
Dome
Lights/Superv:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/
ORANGE/VOLET
PASSENGER/ BLACK/WHTE ***
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ***
Trunk Release:
Alarm nput Wire: YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
NOTES: **This wire requires a negative trigger through a 465 ohm resistor. *** See Note #230 -
Jeep Grand Cherokee Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 45
Make: Model: Year:
Jeep Grand Cherokee 2003
FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Dk.Blue (+) gnition switch harness*
gnition #2: gnition switch harness
gnition #3: gnition switch harness
Accessory: Red/Black (+) gnition switch harness
Brake Light: White/Tan (+) Drivers kick panel
Tach Signal:
Parking Lights: Yellow (-) Headlight switch
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System
only if the ignition key is gray. Use a universal alarm bypass module.
Jeep Grand Cherokee 2003
FUNCTON COLOR LOCATON
Constant +12 Volts: Red & Pink/Black (+) gnition switch harness
OEM Alarm Disarm: Lt.Green/Orange (-) Drivers door lock switch
Dome
Lights/Superv:
OEM Horn: Gray/Orange (-) Steering column harness
Power Lock: See Note **
Power Unlock: See Note **
Trunk Release:
Alarm nput Wire:
NOTES: **Use a vehicle specific doorlock module.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 45
Jeep Grand Cherokee 2003-2004
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: DK. BLUE GNTON SWTCH HARNESS
gnition #2: RED/BLACK GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLACK/ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE/TAN AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
Parking
Lights:
YELLOW (-) HEADLGHT SWTCH****
Headlights:
Diesel Glow
Plug:
Clutch
Bypass Wire:
Notes: * This vehicle may be equipped with Chrysler's Smart Key Transponder Theft System Only f The
gnition Key s Gray. Use a universal alarm bypass module. **** The Parking Lights Are Activated By
A Ground Pulse Through A 1300 Ohm Resistor.
Jeep Grand Cherokee 2003-2004
FUNCTON COLOR LOCATON
Constant +12
Volts:
OEM Alarm
Disarm:
LT.GREEN/ORANGE (-) AT SWTCH N DRVER'S DOOR **
Dome
Lights/Superv:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
OEM Horn: BLACK/RED (-) STEERNG COLUMN HARNESS
Power Lock: DRVER/ ORANGE/VOLET PASSENGER/ BLACK/WHTE ***
Power Unlock: DRVER/ PNK/BLACK PASSENGER/ PNK/BLACK ***
Trunk Release:
Alarm nput
Wire:
YELLOW (-) 3 PN PLUG N FUSE PANEL ON DR. SDE
Notes:
**This wire requires a negative trigger through a 465 ohm resistor. *** See Note #230 - Jeep
Grand Cherokee Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jeep - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 45