Professional Documents
Culture Documents
(LS40, LS50)
LG Electronics
1. Push the battery latch in the direction shown below; then slide the battery pack out of the slot.
1. Remove a screw as indicated in the picture, then pull the HDD Assy out in the direction shown below.
No. 1
EA 1
1030 Keyboard
Remove the battery pack (1010) before replacing this part
1. Remove 2 screws.
No. 1
EA 2
2. To remove three hooks, insert a (-) type screwdriver into a hook located at the lower end of keyboard, and pull it up.
No aplique fora excessiva, uma leve presso nas travas para trs, ser o suficiente para liberar o teclado
1. Pull up the retainer, and remover the connector using a (-) type screwdriver.
Evite o uso de chaves metlicas nesta parte, por marcar facilmente use ferramenta plstica ou somente as mos.
1. After removing a screw and the connector, pull up and remove the fan Assy using a (-) type screwdriver.
1 1
No. 1
EA 3
1. After removing a screw and the connector, pull up and remove the fan Assy using a (-) type screwdriver.
No. 1
Qty 3
1. Remove a screw, insert a screwdriver into the back side of ODD and push it out.
No. 1
Qty 1
10
1. Remove a screw, insert a screwdriver into the hole located at the rear of ODD and push it out.
No. 1
Qty 1
11
1. Remove two wireless LAN card connector, open card knob to take out the card.
12
1. Remove two screws and insert a screwdriver below the modem. Pull it up to disassemble.
Cuidado ao retirar a placa modem, se possvel use somente chaves plasticas ou as mos.
No. 1
Qty 2
13
No. 1
Qty 2
1 1
No. 1
Qty 2
14
Nesta parte desloque o LCD para trs levemente, com a chave de fenda plstica aplique uma LEVE presso, ao mesmo tempo desloque o LCD para trs..
No. 1
Qty 2
15
16
7. Hold the LCD with your both hands, and pull it up to remove.
17
3 1
1 1 1
Screw Specification
1
2
1 1 1
1
Referncia de parafusos.
No. 1 2 3
Qty 9 2 2
18
No. 1
Qty 2
No. 1
Qty 2
19
Apenas desencaixe o parte superior sem retira-la totalmente, desconecte o cabo dos alto-falantes primeiro (como mostrado abaixo) e somente ento remova o gabinete.
20
21
1 1
No. 1
Qty 3
22
Nesta placa,existem duas "chapinhas" de metal que ficam entre a PCMCIA B/D e o gabinete, atente para no perde-las.
23
24
25
1 2 1
No. 1 2
Qty 3 1
26
27
1. Remove a screw.
1 1
1 1
14.1
15
No. 1
28
29
1. Using a knife, remove the logo and rubbers that are covering the screws. Then remove all 7 screws.
1 1 1 1
No. 1 2
Qty 5 2
30
31
3. Remove cable connector. Remove the cable that is arranged around LCD from the LCD frame.
32
2 2
2 2
No. 1 2 3
Qty 4 4 2
33
5. Press the hook on the both side of LCD with a (-) type screwdriver and remove from the LCD rear panel.
34
35