Professional Documents
Culture Documents
3—2004
(Incorporating Amendment No. 1)
AS 3007.3—2004
Australian Standard™
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
Australian Standard™
Electrical installations—Surface
mines and associated processing
plant
Originated as AS 3007.3—1982.
Second edition 1987.
Third edition 2004.
Reissued incorporating Amendment No.1 (May 2005).
COPYRIGHT
© Standards Australia
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Published by Standards Australia GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 6240 9
AS 3007.3—2004 2
PREFACE
This Standard was prepared by Standards Australia Committee EL-033, Electrical
Installations for Outdoor Sites Under Heavy Conditions, to supersede AS 3007.3—1987
which was based on IEC 60621-3:1979, Electrical installations for outdoor sites under
heavy conditions (including open-cast mines and quarries), Part 3: General requirements
for equipment and ancillaries, including Amendment 1 (1986).
This Standard incorporates Amendment No. 1 ( May 2005 ). The changes required by the
Amendment are indicated in the text by a marginal bar and amendment number against the
clause, note, table, figure or part thereof affected.
This Standard was produced from AS 3007.3—1987. Even though much of the technical
content is sourced from IEC 60621-3, this Standard is not equivalent to IEC 60621-3. It has
been updated to align with Standards Australia style including the following:
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Page
SECTION 4 TRANSFORMERS
4.1 CORE, COIL AND TANK BRACING...................................................................... 10
4.2 ENCLOSURES.......................................................................................................... 10
4.3 DUST EXCLUSION ................................................................................................. 10
4.4 PROTECTION FROM FIRE ..................................................................................... 10
4.5 POLLUTION BY COOLING MEDIUM (COOLANT)............................................. 10
Page
STANDARDS AUSTRALIA
Australian Standard
Electrical installations—Surface mines and associated processing plant
SE C T I ON 1 S CO PE A N D RE FE RE N CE D
DOCUMENTS
1.1 SCOPE
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
This Standard sets out requirements for the equipment and ancillaries associated with
electrical installations within the scope of AS 3007.1.