Professional Documents
Culture Documents
Thank you for purchasing the Gizzmo TachRecall Shift Light. This manual contains operating instructions and installation procedures that are needed for the fitting and operation of this product.
Instruction Manual
gizzmo
ELECTRONICS
www.gizzmoelectronics.com
gizzmo
ELECTRONICS
gizzmo
ELECTRONICS
Warnings:
1: Incorrect installation can damage this product 2: Gizzmo Electronics will not warranty any item that has been damaged due to incorrect installation or misuse of product. 3: Never disassemble, modify, or tamper with unit. Failure may cause injury fire and void warranty.
Setting shiftlight
1. 2. 3. 4. Start engine Press and hold both buttons down for 2 seconds, once the buttons are released the first stage shiftlight will illuminate. Use the two buttons (up/down) to move the tacho needle to the desired rpm for the first stage. Press and hold down both buttons for 2 seconds once more. On releasing the buttons the final stage shiftlight will illuminate. Use the two buttons (up/down) to move the tacho needle to desired rpm for the final stage. Once the final stage rpm is correct, press both the buttons once more, the tacho will return to the normal running mode. The shift points are now set.
5. 6.
gizzmo
ELECTRONICS
Start up Sequence
When ignition is turned on the tacho will... 1. Display peak saved rpm then... 2. Display final stage shift point and flash final stage shiftlight then... 3. Display first stage shift point and flash first stage shiftlight then... 4. Return to running mode.
gizzmo
ELECTRONICS
Installation Instructions
Red Black Green Blue White Yellow 12v ECU Positive ECU Negative Tacho Signal in (from ECU) Tacho Signal out (to tacho) Com One (for Gizzmo Launch Interface) Com Two (Not used)
The signal to the tacho runs in series through the Gizzmo Tach Recall shiftlight. The tacho signal enters the shiftlight via the green wire. The signal then passes through the shiftlight and continues out through the blue wire to the tacho. Power and earth are best taken from the engine ECU. tacho signal is best taken from the rear of the dash cluster or engine ECU where applicable. An auto electrician should carry out the installation of this product.
NOTE: The following ECU wiring information is to be used as a guideline only. On various makes and models ECU pin outs may differ from those illustrated. Please have the installation carried out by a professional auto electrician.
4
gizzmo
ELECTRONICS
Troubleshooting Guide The shiftlight does not flash when ignition switched on. Check to make sure power and earth are connected, to the correct wires and that the connections are sound. The tacho does not work, or does not move as per the operating instructions, but the shiftlight does flash the opening ceremony. Check the connections between the tacho and the shift light are correct. The vehicle may be fitted with and impulse type tacho and may require a Gizzmo Spike Generator. The shiftlight flashes erratically and/or at the wrong time. The unit is receiving excessive ignition noise. Try a different 12v ignition source and/or tacho input signal. The shiftlight does the opening ceremony but does not operate with engine RPM. Check the Tachometer input signal with a scope. Try fitting the supplied resistor between the tach recalls Green & Red wires. If this does not work, try fitting the resistor between the Green & Black wires, if still the tachometer not work, Please contact your Gizzmo national distributor.
gizzmo
ELECTRONICS
Notes
Diagram GH5 GH1 GH2 GH1 GH2 GH1 GH2 GH9 GH9 GH5 GH10
SOHC VTEC
CIVIC
ES1 ES2 EU1 EU2 EU3 EU4 ES3 ET2 ES3 EU3 EU4 EG8 EG4 EG6 EG9 EM1 si EJ6 EJ7 EJ8 EJ1 EF9 EF3
M/T A/T
gizzmo
ELECTRONICS
Notes
93.9~97.8
DOHC SOHC
ACCORD WAGON
GH6
gizzmo
ELECTRONICS
INTEGRA
DA5 DA7 ZC PGM-FI DB7 DB1 BB8 BB6 BB5 BB7 BB1 BB4 B18B B18B H22A F22B H22A F22B B20A F20C B16A D15B B16A ZC PGM-FI L15A
PRELUDE
BA8 BA9 BA4 BA5
gizzmo
ELECTRONICS
INSPIRE
GH4
LEGEND
KA8 KA7 RB1 RB1 RB2 RA8 RA9 RA6 RA7 RA5 RA3 RA4 RA1 RA2 GD3 GD4 GD1 GD2 GD8 GD9 GD6 GD7 NA2 NA1
ODYSSEY
gizzmo
ELECTRONICS
GH1
32p Power
25p
31p
16p
Earth
GH2
32p Power
31p
16p
Earth
GH3
26p
16p Power
12p
22p
Earth
GH4
26p RPM
16p Power
12p
22p
Earth
10
gizzmo
ELECTRONICS
GH5
Power
31p
24p
22p 17p
31p
RPM
GH6
26p
16p Power
22p
Earth
GH7
18p Power
20p
16p
Earth
GH8
Power
31p
24p
22p 17p
31p
Earth
11
gizzmo
ELECTRONICS
GH9
26p Power
22p
Earth
GH10
Power
31p
24p
22p 17p
31p
Earth
GH11
18p Power
20p RPM
16p
Earth
GH12
Power
31p
24p
22p 17p
31p
Earth
12
gizzmo
ELECTRONICS
GH13
Power
31p
24p
22p 17p
31p
Earth
GH14
32p Power
25p
31p
16p
Earth
GH15
31p
24p
22p 17p
31p Power
Earth
GH16
26p
16p Power
12p
22p
Earth
13
gizzmo
ELECTRONICS
14
gizzmo
ELECTRONICS
GZ1
26p Earth
22p Power
GZ2
26p Earth
16p
22p
Power
GZ3
26p
16p Earth
22p Power
15
gizzmo
ELECTRONICS
Notes A/T
GM2
LANCER
CA4A CB4A CC4A CB4A CB6A CC4A CA4A C83A C73A C63A C53A CA3A CB3A CA2A CB2A C52A C62A CJ1A CK1A CK2A CA1A
GM2
gizzmo
ELECTRONICS
Engine 4G72 4G64 4G64 4G63 4G64 4G63 4G64 4G93 4G63 4G63 4G93 4G93 4G94 4G93 6G72 6G72 6G73 6G73
Year 99.10~ 99.2~ 97.10~99.1 92.7~97.10 92.7~97.1 91.5~92.6 97.10~02.8 99.10~02.8 97.10~02.8 91.2~92.9
Notes
N33W N34W
N74WG N73WG
RVR
N64WG
N71W N61W N23W N13W
92.10~97.10 DOHC 92.10~97.10 DOHC 91.6~97.10 SOHC 00.5~ 00.11~ 00.5~ 98.4~00.5 95.1~97.7 90.5~94.12 95.1~97.7 90.5~94.12 DOHC SOHC MIVEC DOHC WAGON
N23WG
N11W N21W
CS5A CS5W EA7A EC7A EC1A EC1A F36A F36A F46A F17A F27A F31A F41A F13A F15A F25A
DIAMANTE
gizzmo
ELECTRONICS
Diagram GM5 GM1 GM5 GM1 GM2 GM5 GM1 GM2 GM1 GM1 GM5 GM1 GM5 GM1 GM2 GM2 GM4
LANCER
CM2A CK2A
GTO
Z16A Z16A
FTO
GALANT
GM2
gizzmo
ELECTRONICS
ECLIPSE
MIRAGE
MIRAGE DINGO
CQ2A CQ1A CD5W CB5W CD5W CB4W CB2W CU2W CU4W EA3W EC3W EA3A EC3A EA7W EC7W
LIBERO
AIRTREK
LEGNUM
gizzmo
ELECTRONICS
GM1
26p
16p Earth
12p
22p
Power
GM2
26p
16p
22p
Power
Earth
GM3
Earth
10p
18p
24p
Power
GM4
10p Earth
18p
24p
Power
20
gizzmo
ELECTRONICS
GM5
35p Power
26p Earth
28p
30p
GM6
35p
28p
30p
Earth
Power
GM7
35p
28p Earth
30p
Power
GM8
35p Earth
28p
30p
Power
GM9
27p
28p Earth
29p
30p
26p
Power
21
gizzmo
ELECTRONICS
BCNR33 RB26DETT
SKYKINE
R33
R32
RB20DE RB20E CA18I RB20DET RB20ET RB20DE RB20E VG30DETT VG30DE VG30DE VG30ET RB20DET VG20ET
R31
85.8~89.5
GN5
Z32
300ZX/ FAIRLADY
Z31
gizzmo
ELECTRONICS
180SX
SILVIA
S14
STAGEA
350Z
Z33
PULSER
N15
gizzmo
ELECTRONICS
Year 90.8~94.12
Notes
Diagram GN2
PULSER
97.6~
GN8
LAUREL
CEFIRO
gizzmo
ELECTRONICS
CEDRIC GLORIA
gizzmo
ELECTRONICS
CIMA
FHY33 FPY32
PRIMERA
P11
gizzmo
ELECTRONICS
GN1
16p
20p
20p
20p Earth
Power
GN2
16p
14p
16p
18p Earth
Power
GN3
9p 9p
19p
18p Earth
33p Power
GN4
16p
12p
20p
GN5
15p
12p
20p
27
gizzmo
ELECTRONICS
GN6
8p
38p
19p Earth
38p
8p
Power
GN7
6p
22p
25p Earth
22p
6p
Power
GN8
24p
37p Power
Earth
GN9
Earth
Power
GN10
Power
Earth
28
gizzmo
ELECTRONICS
GN11
15p
20p
GN12
8p
38p
19p Earth
38p
8p
Power
GN13
8p
38p
19p Earth
38p
8p
Power
GN14
8p
38p
19p
38p 8p Power
Earth
GN15
8p
38p
19p Earth
38p
8p
Power
29
gizzmo
ELECTRONICS
LEGACY
IMPREZA
FORESTER SF5
30
gizzmo
ELECTRONICS
GS1
26p
16p
12p
22p
Earth
Power
GS2
26p
16p
22p Power
Earth
GS3
32p
32p
Power
32p
Earth
GS4
Earth
31p
24p Power
17p
28p
22p
GS5
34p Power
35p Earth
35p
31p
31
gizzmo
ELECTRONICS
MARK2
MR-2
AW11
3S-GE 4A-GZE 4A-GE 1ZZ-FE 2ZZ-FE 1ZZ-FE 3S-GTE 3S-GE 3S-GE 3S-GE 1G-FE
MR-S
CELICA
ALTEZZA
gizzmo
ELECTRONICS
Model
Engine 4A-GE 4A-GE 4A-GE 4A-GE 4E-FTE 4E-FTE 4E-FTE 1MZ-FE 2AZ-FE 1MZ-FE 2AZ-FE 3S-GTE 1NZ-FE 2NZ-FE
Year 95.5~00.7 91.6~95.4 93.5~95.8 83.5~87.4 95.12~97.12 89.12~95.11 92.1~95.11 89.12~91.12 00.1~ 00.3~ 01.11~ 02.5~ 02.9~ 97.9~02.7 00.10~05.1 99.8~05.1 99.1~05.1 00.2~ 02.5~
LEVIN
AE92 AE86 EP91
STARLET
EP82 MCR30
ESTIMA
MCR40 ACR30 ACR40 MNH10 MNH15 ANH10 ANH15 ST246W ST215W NCP13 NCP10 NCP15 SCP10
ALPHARD
CALDINA
VITZ
GH9
bB ist
GH9 GH16
33
gizzmo
ELECTRONICS
GT1
26p
16p
22p
Earth
GT2
10p
18p
Earth
GT3
10p
18p
24p
Earth
GT4
Earth
GT5
26p
Earth
Power
34
gizzmo
ELECTRONICS
GT6
26p
16p
12p
Earth
GT7
26p
Earth
GT8
26p
16p
12p
22p
Earth
GT9
26p
GT10
34p
22p
16p
28p
Earth
Power
35
gizzmo
ELECTRONICS
GT11
31p
24p
28p
22p
Earth
Power 40p
GT12
40p
40p Earth
Power
GT13
34p Earth
22p
16p
28p
Power
GT14
34p
22p
16p
28p
Earth
GT15
31p
24p
17p
Earth
Power
36
gizzmo
ELECTRONICS
GT16
34p
35p
35p
31p Power
Earth
GT17
31p Earth
24p
28p
22p
Power
GT18
31p
24p
28p
22p
Earth
GT19
31p
24p Earth
GT20
31p
24p
28p
22p
Earth
Power
37
gizzmo
ELECTRONICS