You are on page 1of 5

HOMEMADE KENTUCKY BEER (15 gallons) Use 15 gallon plastic garbage can with clip on lid.

You need: Approximately 6 oz. hops 3 lbs. extract of malt 9 lbs. granulated sugar 1 tablespoon molasses 1-1/2 teaspoons granulated yeast. Place in vessel with approximately 2 gallons water, or more if vessel is large enough, and bring to boil. Then turn down to simmer for about 45 minutes, steeping hops into liquid during this period as hops will sit on top of the water; otherwise, flavor will be too weak. Put malt, raw sugar and molasses into plastic bin. Then strain hops liquid through parachute silk or cheesecloth to remove all sediment and add liquid to contents of bin. Stir thoroughly with wooden paddle to completely dissolve malt and sugar into liquid. Place the bin in a position where it can be kept for a week undisturbed at 70F. Fill up with lukewarm water to within 2 inches of top of container. Temperature of brew now be about 70 to 80F. Sprinkle yeast evenly over surface and seal. Beer will work for 7 to 10 days. A thick white broth will appear after the first 8 hours and gradually die, towards the end of the time. When working has ceased, take 8 dozen clean 26 oz. bottles and put one level teaspoon of white sugar into each bottle. Drain off liquid into bottles taking care not to disturb too much. (This will disturb sediment and make liquid cloudy). Cap bottles tightly and correctly and store upright for 3 weeks minimum. Cool in refrigerator in upright position and pour gently into glass mug for serving. Sediment also forms in bottle If beer is too lively, too much yeast has been added or if bottled before, it had ceased working. Flavor of beer can be softened by adding 4 oz. of barley to the hops when bottling. Color can be darkened by increasing amount of molasses. Your local health food store is where you can buy your ingredients. Follow directions and be careful - this is very potent. ----------------------------------------------------------------------------------------ROOT BEER, SPRUCE BEER, GINGER SODA

ROOT BEER

1 gallon water 1-1/2 cups molasses 1 tsp. dry yeast 1/2 ounce each of hops, dried burdock, yellow dock, sarsaparilla, dandelion, sassafras and spikenard roots Wash the herbs and bruise them thoroughly with a potato masher or pastry blender. Cover with the water, bring to a boil and simmer for 20 minutes over low heat. Strain into a large crock. Add the molasses and cool to lukewarm. When the mixture is lukewarm, add 1 teaspoon dry yeast and stir. Cover the crock with a cloth and put it in a warm, draft-free place 70-80 degrees F. After 2 hours, pour into clean bottles to within 1/2 inch of the tops. Cap with capper and metal caps, but not corks. Place the capped bottles on their sides in a warm and draft-free spot (70-80 degrees F) for 5 days, then set upright in a cool place. The root beer will be ready to drink in 10 days, but will keep for the whole summer.

SPRUCE BEER 5 gallons fo water 1/8 pound of hops 1/2 cup of dried, bruised ginger root 1 pound of the outer twigs of spruce fir 3 quarts of molasses 1/2 yeast cake dissolved in 1/2 cup of warm water or 1/2 cup of liquid homemade yeast In a large kettle combine the water, hops, ginger root and spruce fir twigs. Boil together until all the hops sink to the bottom of the kettle. Strain into a large crock and stir in the molasses. After this has cooled add the yeast. Cover and leave to set for 48 hours. Then bottle, cap and leave in a warm place (70-75 degrees F) for 5 days. It will now be ready to drink. Store upright in a cool place.

GINGER SODA 2 gallons of water 2 ounces of ginger root, thinly sliced and bruised with the back of a knife 4 cups of light raw sugar 1/4 cup lemon juice 1 tablespoon cream of tartar 1 cup liquid homemade yeast or 1 yeast cake dissolved in a cup of warm water Combine in a large pot the ginger, sugar, lemon juice, cream of tartar, yeast and water. Let the mixture stand in a warm place for 24 hours. Line a funnel with cheesecloth and strain the liquid into two clean gallon jugs. Cover them tightly and let them stand overnight. Chill well before drinking. -----------------------------------------------------------------------------------------GRANDMA'S MOONSHINE GRAPE WINE RECIPE

2 - 12 oz. cans frozen grape juice 3 1/2 cups of white granulated sugar 1/3 cake of yeast (Fleishmann's is best) a large Balloon and some strong string one Gallon Jug First, set the grape juice out to thaw, until slushy. Next, mix the sugar thoroughly in with the grape juice. Pour the sugar and juice, into the gallon jug. Dissolve the yeast in a cup of lukewarm* water and add to the juice mixture in the gallon jug. (*If water is too warm, it will kill the active ingredient in the yeast that causes fermentation.) Mix everything thoroughly. Now add just enough lukewarm water to fill the gallon jug up to about 2 inches below the neck. When this is done, place the balloon over the top of neck and secure tightly with string. Note! This must be an air tight fit... If you have followed all directions carefully, the balloon will soon start to expand with the gas, caused by the fermentation. Store the mixture in a cool (but not cold) area, 60 to 75 degrees is ideal, for a period of from 3 to 6 weeks. Check the balloon every other day. If the balloon expands too large, untie and allow the gas to escape and then retie, but be sure to retie tightly to make it air tight again. When the balloon ceases to expand, the wine is done. NOTICE - Do not bottle the wine before it is done. Working wine (fermenting) can explode a bottle from the gas pressure of fermentation. Strain your wine with a cheese cloth or a tea towel and pour into a bottle, using a snap-on type of cap or use a cork. Store bottles on their sides in a cool, dark place. All that's left now to do, is ENJOY YOURSELF. ---------------------------------------------------------------------------------------------MAKE YOUR OWN LIQUEURS

BASIC EQUIPMENT 1. 1 quart saucepan 2. Measuring cup 3. Measuring spoons 4. 1 quart bottle (32 oz.) or a fifth (25.4 oz.), empty and clean

BASIC INGREDIENTS 1. Spirits: vodka, gin, brandy, Scotch or grain alcohol

2. White granulated sugar 3. Water 4. Fruit extracts. Various brands of extracts are available at home winemaking stores. The French brand "Noirot" is highly recommended. 5. Glycerine. Adds body and smoothness.

BASIC METHOD 1. Make your sweet or medium syrup in the following way: Sweet syrup - 2 cups sugar to 1 cup water Medium Syrup - 1 cup sugar to 1/2 cup water Combine the sugar and water in the saucepan and bring it just to a boil. Cool for few minutes. 2. Pour the required amount of syrup into your clean bottle. 3. Add the extract. 4. Add glycerine and coloring if required. 5. Fill the bottle to the top with the spirits. A liqueur made in a quart bottle will have a stronger alcoholic taste than one made in a fifth bottle. 6. Close the bottle and shake. Cool before drinking.

CHERRY BRANDY 1 bottle Noirot (or similar) Cherry Brandy Extract 1 cup medium sugar syrup Brandy

APRICOT BRANDY 1 bottle Noirot (or similar) Apricot Brandy Extract Brandy (no sugar syrup)

CREME DE COCOA 1 bottle Noirot (or similar) Cocoa Extract 2 cups sweet sugar syrup Vodka or grain alcohol

CREME DE MENTHE 1 bottle Noirot (or similar) Green Mint Extract 2 cups sweet sugar syrup Vodka or grain alcohol

HOMEMADE COFFEE LIQUEUR Ingredients: 3 cups granulated sugar 3/4 cup Yuban Instant Coffee 1 Vanilla bean (available at most health food stores if not at your local supermarket's spice section) (4) 1 1 Quart 100 proof vodka. Dissolve sugar into three and three quarter cups warm water. Bring syrup mixture to a boil and boil hard for 15 minutes. While syrup is boiling, dissolve coffee into three quarter cups of warm water. Add vanilla bean, split lengthwise. When syrup boiling time is up; remove from stove and allow to cool for five minutes. Then add coffee-vanilla bean mixture, and allow to cool to room temperature. When cool, add all the vodka, stir lightly and pour into clean gallon jug. Allow to stand for two weeks at room temperature before drinking. Enjoy! But be careful. This is a potent drink. -----------------------------------END-------------------------------------------------

You might also like