Professional Documents
Culture Documents
Hansen
Lab 5 Transistors II
Section 5-2 Grounded Emitter Amplifier. Purpose: The purpose of this section is to observe the behavior of the Grounded Emitter Amplifier with a capacitor parallel to RE and then without the capacitor. Schematic:
Fig 5-2 Grounded emitter amplifier Analysis of data: We construct a voltage divider with a 10 k ohm and a 100 ohm resistor and calculate
the gain, which was about 100.
(1) We measure the voltage gain with the capacitor. GAIN= 4.32/.0186=232.25
Fig 5-2-2 screen shot with capacitor (2) We removed the 15F capacitor and measured the voltage gain. GAIN=.1385/.0192=7.21
Conclusion: In this section we observed that without the 15F capacitor, the distortion decreased.
Section 5-3 Current Mirror Purpose: The purpose of this section is to observe the behavior of a current mirror circuit. Schematic:
Iprogramming = 0.9893mA 2) Iout = 1.69mA It is somewhat close to the measured value of 0.9893mA. There is a difference of 1.69mA 0.9893mA = 0.70067mA. 3) As you warm Q1, Iout decreases. As you warm Q2, Iout increases.
A.2) 1) Iout = 1.24mA It is closer to the measured value of 0.9893mA than 1.69mA measured from A.1) (2) There is a difference of 1.24mA 0.9893mA = 0.2507mA. 2) We measure Iout as we increase the resistance starting from zero ohms. Iout (mA): 1) 1.21 2) 1.16 3) 1.14 4) 1.13 5) 1.10 6) 1.08 7) 1.07 Conclusion: Over the 10k load, Iout varied by 1.21mA 1.07mA = 0.14mA.
Section 5-6 Push-Pull Purpose: The purpose of this section is to observe the crossover distortion by building a PushPull circuit. Schematic:
2) We used the Dynamic Signal Analyzer to take these measurements. The source channel was ACH1. THDoutput = 17.80%
THDoutput = 1.47% Conclusion The THDinput in section 5-6 (3) is much less than the THDoutput in section 5-6 (2). difference = 17.80 1.47 = 16.33%.