Professional Documents
Culture Documents
1. Creating Offset 2D Sketch for Base of Bottle 1. 2. 3. Open a Bottle.sldprt, and in the Feature Manager design tree, select the Top plane. Click Plane on Feature Toolbar.
Set Distance
to 2.9.
4.
Click OK
5.
Select Panel3 in FeatureManager design tree, right click then select Insert Sketch
6. 7.
Click Bottom
8.
to 1.5.
9.
Click OK on the Standard View Toolbar. on the Standard View Toolbar, then Click Exit Sketch
2. Creating 3D Sketch
1. 2. 3.
Click
Sketch a two point spline coincident between the mid point of Sketch2 and mid point of base
4.
5.
Click Centerline
6. 7.
8. 9.
Repeat step 8 with the other spline and the adjacent construction line, then click OK
1. 2.
3. 4.
In the SelectionManager, click Select Closed Loop Select the Sketch3 for Profiles and click .
Right-click in the graphics area and choose SelectionManager. In the SelectionManager, click Select Group Select the edge of base bottle for Profiles edge and then click . . , click Tangent to select complete all
8. 9.
In the PropertyManager, click in Guide Curves.. In the graphics area, right-click and choose SelectionManager. Use the Select Open Loop tool to select the four splines for Guide Curves .
10. Click OK 4.
3. 4.