Professional Documents
Culture Documents
1. Creating 2D Sketch for Base of Bottle 1. 2. Open a new part, and in the Feature Manager design tree, select the Top plane. Click Rectangle inside of rectangle. 3. Click Smart Dimension (Dimensions/Relations toolbar), and fully defined the sketch. on the Sketch toolbar, and create a rectangle by the origin
4. 5.
to 1.
In the graphics area select the entities, then click OK 6. Select all entities in the graphics area by left click and drag a rectangular as show n below .
7.
8.
Click OK
9.
September 4, 2008
10. On the one of inside entities, select start and end points, then drag the arc on the mid one of outside entities to set the radius.
11. Click OK
Set Radius
to 5.
14. Click OK
September 4, 2008
1. 2. 3. 4.
Click Isometric
In the Feature Manager design tree, select the Top plane. Click Plane on the Sketch toolbar.
5.
Click OK
6. 7.
Click Circle
Sketch a circle on Plane 2, w ith the center approximately along the same vertical axis as the sketch origin.
8. 9.
10. In the PropertyManager, under Add Relations click Concentric 11. Click Smart Dimension diameter to 21.
, then click OK
September 4, 2008
1. 2. 3.
Click Plane
In the FeatureManager design tree, select Front for First Reference. In the PropertyManager, under First Reference: click Coincident , then click OK .
4. 5. 6.
Click Spline
Sketch a tw o point spline coincident w ith the ends points of the tangent arc. Repeat step 5 w ith the points show n.
7. 8. 9.
Click Normal To
Select one of the tw o entities on the graphic area. Click the dot on head arrow and drag until became a curve.
September 4, 2008
to 60. to -100.
12. In the Property Manager, under Parameters: Set Tangent Weighting 1 Set Tangent Radial Direction . to 60. to -80.
13. Click OK
4. Creating the Second Splines 1. 2. 3. 4. Click Isometric Click Plane on the Standard Views toolbar. on the Sketch toolbar.
In the FeatureManager design tree, select Right for First Reference. In the PropertyManager, under First Reference: click Coincident , then click OK .
5. 6. 7.
Click Spline
Sketch a tw o point spline coincident w ith the ends points of the tangent arc. Repeat step 6 w ith the points show n.
September 4, 2008
8. 9.
Click Normal To
10. Click the dot on head arrow and drag until became a curve.
to 55.
September 4, 2008
to -10.
to 55. to -10.
15. Click OK
5. Creating Bottle by Lofted Boss 1. 2. 3. 4. 5. Click Isometric Click Lofted Boss on the Standard Views toolbar. on the Feature Toolbar.
Right-click in the graphics area and choose SelectionManager. In the SelectionManager, click Select Closed Loop Select the Sketch1 for Profiles and click . .
September 4, 2008
6.
7. 8.
In the PropertyManager, click in Guide Curves.. In the graphics area, right-click and choose SelectionManager. Use the Select Open Loop tool to select the four splines for Guide Curves .
9.
Click OK
Set Radius
to 1.5.
September 4, 2008
12. Click OK