Contents
Introduction .. 1
‘Symbols. 2
Installation.. 3
Unpacking the machine 3
Warning 3
Procedure 3
Removing external clamps 6
Removing te motor elaping screws 6
Conditions 6
Procedure 6
Removing the shipping rails 7
Conditions 7
Procedure 7
Handling the covers 8
Removing the covers 8
When? 8
How? .. 8
Replacing the covers 8
Removing the internal clamps 9
Removing the set screws. 9
Preparing the bench u
Machine dimensions. "
Floor space and dling required 12
Water connections 13
Specifications. 13
Generales 13
Filtration tank with pump 13
Pump .. 13
Pipe connections 13
Find the openings on the chassis... 13
Procedure 14
Electrical connections 16
Specifications. 16
Edger wiring. 16
Procedure 16
Starting the edger 7Procedure W7
Switching the machine on/ott 18
Safety precautions ..
Safety
Operator
Machine,
Useful hints
Using your Edge 550
Presentation.
Presentation of the machine
Presentation of the application screen,
Work interface...
Zone identification...
Reading sequence
Visual references
General principles of use
Usual procedure
Flow chart
Calling up a job
Inserting / Removing the lens
To place the lens in the edging chamber...
To remove the lens from the edging chamber
Starting / Interrupting an edging cycle.
To start an edging cycle...
To interrupt an edging cycle
Normal edging cycle sequence
Important notes.
When job data are received
During edging of the second lens
Application screen icons
General
Lens materials
Types of lenses
Finishings
Sub-finishings and associated parameters
Bevel...
Groove ....
Drilling .
Safety-bevels
Safety-bevel Parameters...
Polishing
Lens edging
Normal use.
Producing a job with bevel finishing
Object voces
Procedure.
Hints
Limits... .
Producing @ job with rimless finishing.
Object .nense
Procedure.Hints .
Limits ....
Producing a job with groove finishing...
Object .. .
Procedure
Hints .
Limits
Producing a job with Nitng tinshing
Object ..
Procedure
Producing a job with grooving ani
Object .. cece
Procedure
Driling: facts werth knowing
Hints .
Limits
Special cases
Retouching a lens
Why? ..
How? ..
Hints -
Important notes
Limits
Applying an oversize to the lens
Why? ..
How? ..
Hints -
Important notes
Edging the left lens with different parameters from those of the right lens
Principle...
Procedure
Edging several lenses identically
Principle...
Procedure
Checking a finishing before the lens is edged
Principle...
Presentation . -
Visualise a finishing
Place a finishing manually
Produce a manual bevel
Produce a manual groove
Feel the lens again ..
Operating range
Points to remember
Illustration of finishing limits,
Rimless Finishing
Bevel Finishing...
Inclined groove finishing ..
Drilling
Conditions...
Limits of hole positioning -
Limits related to the thickness of the lens
51
52
53
53
53
53
54
55
55
55
57
87
87
58
58
59
60
sa» 60
.. 60
60
61
61
62
sae 62
2 62
62
62
63
63
63
64
64
64
64
64
65
67
68
69
7
74
75
75
7
7
7
77
73
78
78
79