Professional Documents
Culture Documents
Installation by CD-ROM
To install the ADSL2+ router, you can run the Starter Kit CD-ROM and follow the instructions. The following table describes the meaning of the LEDs.
(7) RJ-11 telephone line (8) MT880 (9) RJ-45 Ethernet cable
Installing the ADSL2+ Router by CD-ROM
1. Insert the Starter Kit CD-ROM into the CD-ROM drive of your PC.
2. Wait until you see the dialog box as shown in Figure(2) is displayed automatically.
3. Choose English language from the Language list-down box at the upper right
corner of the dialog box.
Figure(3)
Troubleshooting
If there is any problem with the ADSL2+ router, try the following operations to fix the problem:
1. Make sure that all the cables and the power adapter are conected properly.
2. Make sure that the TCP/IP settings of your PC are correct.
That is, the PC is set to obtain an IP address automatically from the DNS server.
Figure(2)
3. Repeat the CD-ROM Installation procedures.
After the ADSL2+ router is connected to the Internet, the Internet Explorer is launched
automatically. Then you can surf the Internet as you wish.
Installation Through Web Page 4. After setting the router, enter your username and password again and click Save
to save the changes.
This is an alternative way to set up the ADSL2+ router. It is more suitable for someone who has
Now the ADSL2+ router will automatically connect to the TT&T network and is ready for Internet
networking expertise.
services.
Connecting Cables
Connect the cables and the power adapter of the ADSL2+ router in the same way as described
previously.
Figure(5)
Troubleshooting
If there is any problem with the ADSL2+ router, try the same operations described previously to
fixed the problem.
Issue: 01 (2008-05-23)
Figure(4)
Part Number: 102085