Professional Documents
Culture Documents
Base Board
Rev. 2
Doc #1.0
User's Guide
Digital Signalprocessing Technology D.SignT GmbH & Co. KG Marktstr. 10 D - 47647 Kerken Tel: Fax: +49 (0) 2833 / 570 977 +49 (0) 2833 / 33 28
D.Module.Base Board
RS 232
Reset Button
Setup Button
Test Pin
1 A B
16
32
PWM Out
-AVCC +AVCC
T U V
D.SignT 2001
Doc #1.1
D.Module.Base Board
RS232 Connector
9pin D-Sub connector, female, 0-Modem wiring. Connect to a PC-COM port using a 1:1 cable, male - female connectors. The D-Sub is connected to the DSP module as follows:
A3 A4 A5 A2
GND A6
PWM Output
A Pulse Width Modulation output can be implemented in the D.Module's userprogrammable CPLD. The associated programming file is part of the D.Module's Board Support Package. The PWM output is mapped to PRG_IO0 on the D.Module. This output is available filtered and AC-coupled on the 3.5mm jack.
1K PRG_IO0 (B2) 22 nF 22uF
D.SignT 2001
Doc #1.1
D.Module.Base Board
Push-buttons
Reset: Setup: connected between GND and pin A9 (nRESIN) on the DSP module connected between GND and pin A11 (IN0) on the DSP module
To reset the DSP module press the Reset Button, to put the module in Setup mode, press Reset and Setup simultaneously, release the Reset button first, then the Setup button.
Indicators
Power: Test: green LED, connected to GND and - via 820 Ohms series resistor - to +VCC yellow LED, connected to GND and - via 820 Ohms series resistor - to the Test-Pin next to it. Can be connected to any signal on the DSP module ( except the RS232 signals ! ) to indicate it's logic state.
D.SignT 2001
Doc #1.1