Professional Documents
Culture Documents
EME-403 50 2 hrs
Prepared by: MR
SECTION-B 2. Answer any three questions. Each question carries 5 marks. 1. Define error. What are the different types of errors? Also discuss in brief the causes/sources for these errors. 2. Define the term calibration. What is static calibration? 3. Define strain gauge and enumerate various types of strain gauges. Also explain the types the resistance strain gauges. 4. What is gauge? What are the limit gauges and state their classification. Also explain and give uses of plug gauge, ring gauge , snap gauge and combination sets. 5. Explain the principle of interferometry. State the uses of interferometry principle in measurement. Describe flatness measurement measurement by interferometry principal with neat sketch?
SECTION-C Answer all the questions. Each question carries 5 marks. 1. Sketch and describe the working principle of auto-collimator. Also state the uses of auto-collimator. OR What are interferometer? What are their advantages over optical flats? Describe the working principal of Michelson Interferometer. 2. Define circularity and roundness. What are the errors associated with them? State the various methods for measuring roundness/circularity and describe at least two of them in brief. OR Explain the working principle and application of Tool Makers microscope or Profile project autocollimator with neat sketch. 3. Discuss different numerical methods to find (or to represent or quantitative evaluation of) surface roughness. Name the stylus methods of measuring surface finish and explain any of them with neat sketch Tomlinson surface measurement method Talysurf surface measurement method. OR Describe surface texture and its elements with neat sketch. Also enumerate the various methods for measuring surface roughness. 4. What are the elements of screw thread measurement? Enumerate the various methods to measure those elements of screw thread. OR Explain two wire , three wire and thread micrometer method of measuring effective diameter of screw thread. 5. Discuss sensors and their types. OR Discuss transducers and their types.