You are on page 1of 11

McKinna 57 Pilothouse

Make: Model: Length: Price: Year: Location: McKinna 57 Pilothouse 57 ft $ 449,000 2003 Marina Del Rey, CA, United States Hull Material: Draft: Fuel Type: Number: Fiberglass 4 ft 2 in Diesel 4140372

Number of Engines: 2

Condition: Used

Description
The McKinna 57 Pilothouse is a stylish and well-built boat that is perfect for coastal cruising, or long weekends at the islands. It has a three stateroom interior, a large flybridge, and an expansive cockpit with a built in grill. I bought this boat for a client earlier in 2012, so it has had a recent survey and all the surveyor's recommendations addressed. It is now in excellent condition and ready to be sailed away by its next owner.

Denison Yacht Sales - Tom Hugh-Jones


Downtown Yachting Center, 401 S.W. 1st Avenue, Ft. Lauderdale, FL 33301, United States Toll-free: 888-802-5382 Tel: (310) 658-0700 Tel: (954) 763-3971 Tom@DenisonYachtSales.com http://www.denisonyachtsales.com

Measurements
Cruising Speed: Max Speed: LOA: Beam: Max Draft: Dry Weight: 20 mph 26 mph 62 ft 15 ft 5 in 4 ft 2 in 55500 lb Electrical Circuit: Fuel Tanks Capacity: Holding Tank Capacity: Number of single berths: Number of double berths: Number of Cabins: Number of Heads: Deadrise at Transom: Windlass: 18.5 Electric Windlass 110V 850 gal 70 gal 2 2 3 2

Length on Deck: 57 ft

Fresh Water Tanks Capacity: 250 gal

Cabin Headroom: 6 ft 6 in

Propulsion
Number of Engines: 2 Primary Engines: Drive Type: Engine Make: Engine Model: Inboard Direct Drive Cummins Diamond Series Engine Year: 2003 Total Power: 900 hp

Features
Electronics

Depthsounder Log-Speedometer TV Set - Sea Tel satellite TV Plotter - Furnuo Navnet Autopilot - Robertson AP20 w/
remote

CD Player Cockpit Speakers


Inside Equipment

Radar - Furuno 6k/W open array Repeater(s) - Upper & Lower helms VCR DVD Player Radio Compass GPS - Furuno Navnet VHF - Horizon Spectrum Washing Machine - GE washer &
dryer

Bow Thruster - Wesmar 12

McKinna 57 Pilothouse

Page 2 of 11

Electric Bilge Pump Microwave Oven - GE microwave/


convection

Heating Refrigerator - Sub Zero Deep Freezer - Sub Zero


Electrical Equipment

Oven Air Conditioning - Marine Air Electric Head Hot Water Fresh Water Maker - HRO Battery Charger Generator - Onan 21 k/W Cockpit Shower Tender - 11 Swimming Ladder

Shore Power Inlet Inverter - Heart 2500 Watt


Outside Equipment/Extras

Teak Cockpit Davit(s) Cockpit Cushions - Foredeck sun


cushions Covers

Bimini Top
Accommodations
This 57' McKinna is a three stateroom model with a handcrafted maple interior. Forward is a VIP stateroom with a berth offset to port. Aft in the passageway is a cupboard with stacked washer & dryer to port followed by a guest cabin with over & under bunks. Opposite to starboard is the guest head. The heads feature marble vanity and sole with Newport Brass faucets and fixtures. The master cabin is midships with cedar lined cabinets for storage, a vanity, and a private head with a bathtub Up a few steps takes you into the pilothouse with a fully equipped inside helm station. Behind the captains chair is an L-shaped seat & table for guests. Down a couple of steps takes you into the salon. There you will find a galley to port that has an electric range, microwave, refrigerator & freezer and a trash compactor Aft of the galley is a sofa to port, while opposite is another L-shaped sofa with a table Stepping outside through stainless steel doors leads you into the cockpit.

McKinna 57 Pilothouse

Page 3 of 11

Electrical
Onan 21.5 kw generator w/sound shield Heart 2500 watt inverter General Electric clothes dryer General Electric clothes washer Nutone central vacuum system HRO watermaker Marine Air heat/air conditioning ZF engine controls (3 stations) Wesmar 12" bow thruster (3 stations)

Additional Information
Sun mattress on foredeck Fiberglass radar arch w/spreader lights Flybridge wet bar Brower low profile 800# davit 11' McKinna RIB w/four stroke outboard (serviced '08) Underwater lights (6) NEW canvas flybridge seat/settee, cockpit and dinghy covers Pilothouse mesh window covers Maxwell VWC-2200 windlass w/300' chain Glendinning shore power cord Cablemaster Nautical Structure bimini top and Barret Bonded enclosure ($20,000) Fresh anti-fouling paint ('08) ACR searchlight

disclaimer
The Company offers the details of this vessel in good faith but cannot guarantee or warrant the accuracy of this information nor warrant the condition of the vessel. A buyer should instruct his agents, or his surveyors, to investigate such details as the buyer desires validated. This vessel is offered subject to prior sale, price change, or withdrawal without notice.

McKinna 57 Pilothouse

Page 4 of 11

Photos

In the slip

Salon forwards

Salon aft to starboard

Salon aft to port

Galley

Pilothouse

McKinna 57 Pilothouse

Page 5 of 11

Pilothouse helm

Manufacturer Provided Image

Electrical panel

Master stateroom

Master stateroom vanity

Master head & shower/bath

McKinna 57 Pilothouse

Page 6 of 11

Master head

VIP stateroom

Guest cabin

Guest head

Cockpit seating & BBQ

Flybridge helm

McKinna 57 Pilothouse

Page 7 of 11

Flybridge seating

Wetbar on flybridge

Foredeck seating area

Starboard engine

Dripless shaft seals

Port engine

McKinna 57 Pilothouse

Page 8 of 11

Dripless shaft seals

Generator in soundshield

Watermaker

Salon forwards

Washer & Dryer

Flybridge aft

McKinna 57 Pilothouse

Page 9 of 11

Dinghy & Brower Davitt

Flybridge helm instruments

Furuno Navnet

Bow Thruster

Autopilot

VHF

McKinna 57 Pilothouse

Page 10 of 11

Salon aft

McKinna 57 Pilothouse

Page 11 of 11

You might also like