Professional Documents
Culture Documents
Especially designed for tough jobs. High capacities when requested. Driven by an unbalanced motor. Reduced energy consumption and maintenance. Possibility of incorporating cooling or heating processes. Made following the EC directives.
Elastic elements
Drive unit
The functioning is based on obtaining a common frequency between the elastic system and the drive unit. The used system relies on the energy conservation theorem. If an elastic element, supporting a certain mass, is pressed or stretched with a certain force, it absorbs and supplies the same energy. Though the number of oscillations will be the same with the same force. The drive unit is formed by a vibrator whose eccentric defines the whole oscillation amplitude. The transmission between the motor and the vibrator axle is made through a belt. When changing the pulleys diameters the driving frequency is syntonized with the system's natural frequency. The elastic system is composed by a range of springs that hold the conveying trough. Helicoidal springs -made of special tempering steel and shoot peening treated- are normally used as elastic elements. The drive unit is composed by a crankshaft equipped by one or more elastic connecting rods, driven by an electric motor through trapezoidal belts. The whole system can be installed either on an isolated reaction mass, supported by a concrete block or anchored to the floor incorporating a structure able to absorb the transmitted dynamic efforts, in order to reduce them.
Frequency (I)
Frequency (II)
Total energy requirements Energy absorbed by the drive unit
The power requirement to maintain a natural frequency vibrating conveyor is extremely low since the elastic elements themselves act as accumulators of energy. The energy supplied by the electric motor is only the energy required to replace losses caused by the friction. The conveying t r o u g h s or channels can be produced in various shapes, allowing dust-tight or open elements, adapted to the installation requirements. In some specific applications, clutch sections can be eventually installed, acting as lung, keeping the product on the trough. Besides of this, the trays can be equipped with different elements in order to separate or classify the product to be handled, or even to cool (by injecting air or circulating water) or heat (through infrared radiation or electric resitance).
The natural frequency vibrating conveyors are especially used for big lengths, reaching up to 30 meters with one vibrating group. They solve very different problems, offering elegant and simple solutions. The production is remarkably improved, thanks to their important flows, their long life, their high reliability and their low energy consumption. Their rough design assures a continuous service, free of troubles, even in the most exigent conditions, with a high efficiency and a minimum maintenance.
FL conveyor for mould sand, in casting. Its width is of 620 mm and its length 24 m. It reaches a flow of 10 tons per hour.
FX vibrating conveyor used for recycling aluminum shapes. Its width is of 900 mm and the total length of 220 m. The installation transports a 4 ton flow and is made by 10 independent parts.
Ashes recuperation, after coal combustion in a thermal station, for cement production.
Waste recycling.
Waste recycling.
Casting.
Clinker.
Ashes.
Casting pieces.
Ctra. Villabona-Asteasu, km 3 Apartado 247 Tel. (+34) 943 691 500 Fax (+34) 943 692 667 E-20159 Asteasu http://www.adegi.es/urbar E-mail: export@urbar.com F N / 2 2000.08