You are on page 1of 12

MWorks THX S750 CLE.

book Page i Friday, September 5, 2003 12:05 PM

Safety & Regulatory Information


The following sections contain notices for various countries:

Notice for the USA this device must be installed with computer equipment

FCC Part 15: This equipment has been tested and


certified to comply with the Class B limits.
All cables used to connect the computer and
CAUTION
found to comply with the limits for a Class B digital peripherals must be shielded and grounded. Take care to prevent accidental operation of your new
device, pursuant to Part 15 of the FCC Rules. These Operation with non-certified computers or non- loudspeaker system at excessive sound pressure
limits are designed to provide reasonable protection shielded cables may result in interference to radio or levels!
against harmful interference in a residential television reception. In a typical personal computer installation, the
installation. This equipment generates, uses, and can Modifications GigaWorks S750 satellite speakers are less than a
radiate radio frequency energy and, if not installed Any changes or modifications not expressly approved meter from the listener.
and used in accordance with the instructions, may by the grantee of this device could void the user’s If you do not hear sound from your new speaker, keep
cause harmful interference to radio communications. authority to operate the device. the GigaWorks S750's volume control at a low level
However, this notice is not a guarantee that
(two Level Indicators lit on the wired remote control)
interference will not occur in a particular installation. If
while trying to restore sound to your system. This will
this equipment does cause harmful interference to
radio or television reception, which can be determined Notice for Canada prevent accidental operation at uncomfortably loud
levels.
by turning the equipment off and on, the user is This apparatus complies with the Class B limits for
encouraged to try one or more of the following radio interference as specified in the Canadian
measures:
❒ Reorient or relocate the receiving antenna.
Department of Communications Radio Interference European Compliance
Regulations.
❒ Increase the distance between the equipment This product conforms to the following:
and receiver. Cet appareil est conforme aux normes de CLASSE EMC Directive 89/ 336/ EEC as amended by 92/ 31/
❒ Connect the equipment to an outlet on a circuit “B” d’interference radio tel que spe’cifie’ par le EEC and 93/68/EEC and the LVD Directive 73/ 23/
different from that to which the receiver is Ministère Canadien des Communications dans les EEC amended by 93/68/EEC.
connected. règlements d’interfèrence radio.
❒ Consult the dealer or an experienced radio/ TV
technician. Important Notice
CAUTION: To comply with the limits for the Class B
digital device, pursuant to Part 15 of the FCC Rules, The serial number for the GigaWorks S750 is located
on the subwoofer. Please write this number down and
keep it in a secure area. This is for your security.

Safety Warnings
The lightning flash arrowhead within an
equilateral triangle is intended to alert the WARNING CAUTION:
user to the presence of uninsulated, “danger- TO PREVENT THE RISK OF ELECTRIC
DO NOT OPEN SHOCK, MATCH WIDE BLADE OF PLUG
ous voltage” within the product’s enclosure,
that may be of sufficient magnitude to TO WIDE SLOT. INSERT CAREFULLY.
constitute risk of electric shock to persons. TO PREVENT THE RISK OF ELECTRIC
SHOCK, DO NOT REMOVE SPEAKER ATTENTION:
COVERS (OR BACKS). NO USER-
SERVICEABLE PARTS INSIDE. REFER POUR EVITER LES CHOCS ELECTRIQUES,
The exclamation point within an equilateral SERVICING TO QUALIFIED SERVICE INTRODUIRE LA LAME LA PLUS LARGE
triangle is intended to alert the user to the PERSONNEL. DE LA FICHE DANS LA BORNE
presence of important operating and CORRESPONDANTE DE LA PRISE ET
maintenance (servicing) instructions in the POUSSER JUSQU AU FOND.
literature accompanying this product.

CAUTION:
This symbol indicates that the marked item may AVISQUE IMPORTANT NOTICE:
be Hot and should not be touched without POUR EVITER TOUT RISQUE DE THE SERIAL NUMBER FOR THE
proper care. CHOC ELECTRIQUE, NE PAS SPEAKER IS LOCATED ON THE
DEMONTER LE COUVERCLE DU SUBWOOFER. PLEASE WRITE THIS
HAUT PARLEUR. AUCUN ENTRETIEN NUMBER DOWN AND KEEP IT IN A
❒ To minimise the risk of burns and other injuries to DES PIECES INTERIEURES N EST SECURE AREA. THIS IS FOR YOUR
children, position the device such that hot surfaces are REQUIS. TOUT SERVICE D SECURITY.
out of their reach. ENTRETIEN NE DOIT ETRE EFFECTUE
❒ To minimise the risk of fire, keep flammable materials like QUE PAR DU PERSONNEL D
paper and cloth (for example, curtains) away from the hot ENTRETIEN QUALIFIE.
surface.

WARNING:
Do not expose this apparatus to dripping or
splashing fluids, and ensure that no objects filled
with liquids — such as vases — are placed on
the apparatus.

READ AND HEED IMPORTANT SAFETY WARNING ON REAR OF SPEAKER ENCLOSURE

i
MWorks THX S750 CLE.book Page ii Friday, September 5, 2003 12:05 PM

IMPORTANT SAFETY INSTRUCTIONS


READ INSTRUCTIONS - All safety and operating ventilation is provided or Creative Technology’s OBJECT AND LIQUID ENTRY - Never push objects
instructions should be read before the GigaWorks S750 instructions have been adhered to. of any kind into the subwoofer through openings as
amplified subwoofer/satellite system is operated. HEAT - The subwoofer should be situated away from they may touch dangerous voltage points or short out
RETAIN INSTRUCTIONS - The safety and operating heat sources such as radiators, heat registers, stoves, parts that could result in a fire or electric shock. Never
instructions should be retained for future reference. and other products (including amplifiers) that spill liquid of any kind on the subwoofer.
HEED WARNINGS - All warnings on the subwoofer and produce heat. SERVICING - Do not attempt to service the subwoofer
in the operating instructions should be adhered to. POWER SOURCES - The subwoofer should be yourself as opening or removing covers may expose you
operated only from the type of power source indicated to dangerous voltage or other hazards. Refer all
FOLLOW INSTRUCTIONS - All operating and usage
on the marking label. If you are not sure of the type of servicing to qualified service personnel.
instructions should be followed.
power supply to your home, consult your product DAMAGE REQUIRING SERVICE - Unplug the
CLEANING - Unplug the subwoofer from the wall outlet or
dealer or local power company. For products intended subwoofer from the wall outlet or other power source
other power source before cleaning. Do not use liquid
to operate from battery power or other sources, refer and refer servicing to qualified service personnel under
cleaners or aerosol cleaners. Use a damp cloth for cleaning.
to the operating instructions. the following conditions:
ATTACHMENTS - Do not use attachments not
POLARIZATION - The subwoofer may be equipped a) When the power-supply cord or plug is damaged.
recommended by Creative Technology as they may
with a polarised alternating-current line plug (a plug b) If liquid has been spilled, or object have fallen into the
cause hazards.
having one blade wider than the other). This plug will fit subwoofer.
WATER AND MOISTURE - Do not use the subwoofer into the power outlet only one way. This is a safety
near water—for example, near a bath tub, wash bowl, c) If the subwoofer has been exposed to rain or water.
feature. If you are unable to insert the plug fully into the
kitchen sink, or laundry tub; in a wet basement; or near outlet, try reversing the plug. If the plug should still fail d) If the subwoofer does not operate normally by
a swimming pool; and the like. to fit, contact your electrician to replace your obsolete following the operating instructions; or exhibits a
ACCESSORIES - Do not place the GigaWorks S750 outlet. Do not defeat the safety purpose of the distinct change in performance.
system on an unstable cart, stand, tripod, bracket, or polarised plug. e) If the product has been dropped or damaged in any way.
table. The subwoofer or satellites may fall, causing POWER-CORD PROTECTION - Power-supply cords REPLACEMENT PARTS - When replacement parts are
serious injury to a child or adult, and serious damage to should be routed so that they are not likely to be required, be sure the service technician has used
the product. Use only with a cart, stand, tripod, walked on or pinched by items placed upon or against replacement parts specified by Creative Technology, or
bracket, or table recommended by Creative them, paying particular attention to cords at plugs, have the same characteristics as the original part.
Technology, or sold with the product. Any mounting of convenience receptacles, and the point where they exit Unauthorised substitutions may result in fire, electric
the satellites or subwoofer should follow the from the subwoofer. shock, or other hazards.
manufacturer’s instructions, and should use a mounting
LIGHTNING - For added protection for the GigaWorks SAFETY CHECK - Upon completion of any service or
accessory recommended by Creative Technology.
S750 system during a lightning storm, or when it is left repairs to the GigaWorks S750 system, ask the service
VENTILATION - Slots and openings in the cabinet are unattended and unused for long periods of time, unplug technician to perform safety checks to determine that
provided for ventilation, to ensure reliable operation of it from the wall outlet. This will prevent damage to the the GigaWorks S750 system is in proper operating
the subwoofer and to prevent it from overheating; and subwoofer due to lightning and power-line surges. condition.
these openings must not be blocked or covered. The
OVERLOADING - Do not overload wall outlets, WALL OR CEILING MOUNTING - The GigaWorks
openings should never be blocked by placing the
extension cords, or integral convenience receptacles as S750 satellites should be mounted to a wall or ceiling
product on a bed, sofa, rug, or other similar surface.
this can result in a risk of fire or electric shock. only as recommended by Creative Technology.
The subwoofer should not be placed in a built-in
installation such as a bookcase or rack unless proper

ii
MWorks THX S750 CLE.book Page 3 Friday, September 5, 2003 12:05 PM

Contents
Creative GigaWorks S750

Safety and Regulatory Information and Warnings ... 1

Important Safety Instructions .................................... 2

Contents and copyright notice .................................. 3

Introduction ............................................................... 4

Speaker Connection ................................................ 5

Speaker Placement Options / Stand Attachment...... 6


GigaWorks THX S750
Audio Control Pod and Remote Control.................... 7

Indicators and Controls ............................................. 8

Connecting to Audio Devices................................... 9

Understanding Upmixing......................................... 11

Using Multiple Inputs............................................... 12

Controlling Noise and Distortion ............................. 12

Specifications and Upgrade option ......................... 12

Information in this document is subject to change without notice and does not represent a commitment on the part of
Creative Technology Ltd. No part of this manual may be reproduced or transmitted in any form or by any means, electronic
or mechanical, including photocopying and recording, for any purpose without the written permission of Creative
Technology Ltd.
Version 1.0
September 2003
Copyright © 2000-2003 Creative Technology, Ltd. All rights reserved. The Creative logo, GigaWorks, EAX, Audigy, Live!
and Sound Blaster are registered trademarks or trademarks of Creative Technology Ltd in the USA and/or other countries.
THX and the THX logo are trademarks or registered trademarks of THX Ltd. Lucasfilm is a trademark of Lucasfilm Ltd.
Used under authorisation. All other logos, brand and product names are trademarks or registered trademarks of their
respective holders. All specifications are subject to change without prior notice. Actual contents may differ slightly from
those pictured.

3
MWorks THX S750 CLE.book Page 4 Friday, September 5, 2003 12:05 PM

Introduction

Four steps to enjoying your GigaWorks speakers ...

Connect your Place the speakers Learn to operate Connect and upmix
speakers correctly the system audio sources

Page 5 contains Page 6 contains Pages 7 and 8 Pages 9 –11 help


the set up placement tips show you how to you to connect
instructions for that maximise the operate the Audio audio devices to
Creative surround-sound Control Pod and your speakers,
GigaWorks S750. effects of your Remote Control. and “upmix” audio
speaker system. for better sound.

Thank you for purchasing the through this User’s Guide in the your Dolby Digital Surround EX
GigaWorks S750 speakers by order shown above. titles on your PC.
Creative Technology. Remember to ensure that all
The GigaWorks S750 features a plugs are securely fastened to their
powerful 7.1 channel amplifier, respective sockets before operating
driving 7 satellite speakers and a your speaker system.
subwoofer.
Your GigaWorks S750 speaker
system feature precision THX Certification
supertweeters suitable for DVD- Lucasfilm-THX Certified
Audio playback. Additionally, this GigaWorks THX S750 multimedia products carry the THX
series of high-quality amplified mark of excellence in consumer
With its seven powerful satellite
multimedia speaker systems home entertainment. When you
speakers and a separate subwoofer
features the finest drivers, precision purchase a THX Certified
with 8-channel amplification, the
internal crossover and amplifier multimedia product you will be
Creative GigaWorks THX S750 is
circuitry in an elegant enclosure confident knowing that it has been
an incredible 7.1 speaker system
design. developed, evaluated and tested to
for use with Creative’s EAX-
GigaWorks S750 supports the meet rigorous performance
enabled products. This high power
very latest in audio technology requirements established by THX
speaker system delivers a thrilling,
today. This includes: EAX™, certification specifications. These
high quality PC home theater audio
DirectSound®3D, DVD-Audio and specifications include power
experience that meets the
multichannel gaming. The powerful handling, frequency response and
prestigious THX multimedia
speakers also support the 5.1, 6.1 dispersion characteristics. The THX
certification standard. Combine this
or 7.1 analog output from the the logo on your product is your
speaker system with the 24-bit
latest Sound Blaster® Live!™ and
Sound Blaster Audigy® 2 series guarantee of performance,
Audigy® series audio cards. To promising many years of crisp and
sound cards and you will
experience the full potential of your clear sound.
experience the ultimate in high-
GigaWorks system, we recommend
powered, high definition playback of
that you take a few minutes to read

4
MWorks THX S750 CLE.book Page 5 Friday, September 5, 2003 12:05 PM

Speaker connection

1 Front Right Satellite Speaker 5


5 Side Left Satellite Speaker 99 Subwoofer Back Panel

2 Front Left Satellite Speaker 6


6 Rear Right Satellite Speaker 10
10 Audio Control Pod

3 Center Satellite Speaker 77 Rear Left Satellite Speaker 11


11 Connect the red wire to the red
terminal of each speaker for correct
polarity
4 Side Right Satellite Speaker 88 Subwoofer 12 Main Power Socket/Switch
Ensure power rating is suitable for
your country

5
MWorks THX S750 CLE.book Page 6 Friday, September 5, 2003 12:05 PM

Speaker placement options

* Floor stands are available from the Web.

6
MWorks THX S750 CLE.book Page 7 Friday, September 5, 2003 12:05 PM

Audio Control Pod and Remote Control


Your GigaWorks THX S750 Control Pod can be used as a buttons are also found on the
speaker system is controlled via guide when adjusting your speaker Remote Control for convenient
the Audio Control Pod and Remote settings, as well as relaying the operation.
Control. operational status of the system.
The indicators on the Audio Many of the Audio Control Pod

17
1

18

2 3 4

Audio Control Pod — Top Panel

5 6 7 8 9 10 11 12

16 15 14 13

Remote Control
Audio Control Pod — Front Panel

7
MWorks THX S750 CLE.book Page 8 Friday, September 5, 2003 12:05 PM

Indicators and Controls

No. Button/Indicator Description Notes

Standby/Power Turns the system on or off the Standby Previous user settings are restored when system
1 button mode is turned on.

Volme Adjust Decreases or increases the selected Use the Select button to choose Master, Center,
2
buttons output level. Side, Rear speaker and Sub/Treble output levels.

Select button Selects Master, Center, Side, Rear, Sub Use the Volume Adjust buttons to adjust the
3 or Treble modes for adjustment. selected output levels.

Upmix button Selects 5.1 → 7.1 upmixing See Page 11, “Understanding Upmixing” for
4 6.1 → 7.1 upmixing details.
OFF (No upmix)

5 Power indicator Displays the power status of the system Red denotes system standby mode.

6 Master Volume Illuminates when the Master Volume The output levels of all speakers are adjusted
Mode indicator adjustment mode is selected. simultaneously, including headphones volume.

7 Center Mode Illuminates when the Center Volume The output level of the Center speaker is
indicator adjustment mode is selected. adjusted.

8 Side Mode Illiuminates when the Side Mode Volume The output levels of the Side speakers are
indicator adjustment mode is selected. adjusted.

9 Rear Mode Illuminates when the Rear Volume The output levels of the Rear speakers are
indicator adjustment mode is selected. adjusted.

10 Subwoofer Mode Illuminates when the Sub Volume The output level of the Subwoofer is adjusted.
indicator adjustment mode is selected. Also adjusts bass level for headphones.

11 Treble Mode Illuminates when the Treble Volume The output level of the Treble is adjusted for all
indicator adjustment mode is selected. speakers. Also adjusts treble levels
for headphones.

12 Upmix status Illuminates when upmixing is active. 5.1 → 7.1 For 5.1 source devices
indicator 6.1 → 7.1 For 6.1 source devices

13 Headphone Connects to any headphones with a 3.5 All speakers are muted when headphones are
output mm (1/8 inch) plug. connected.

14 Line input Allows connection of an analog stereo Connect to the line output of a Jukebox, MD
device. Player and other portable audio devices.

15 M-PORT Portable Audio Docking Point. Allows direct connection of your Creative Digital
Audio Player or any device featuring the M-PORT
logo for streaming audio.

16 Volume Indicate volume or output level being Dependent on mode setting.


Level indicators adjusted.

17 Mute button Silences the speaker and headphones In mute mode, all illuminated indicators will blink
outputs. continuously.

18 Select Directly select Sub or Treble volume These buttons on the remote control let you
buttons adjustment modes, as well as level directly select Side, Center, Rear, Sub and Treble
adjustment modes for Center, Side, or modes for adjustment.
Rear speakers.

Table 1: Overview of the Audio Control Pod and Remote Control

8
MWorks THX S750 CLE.book Page 9 Friday, September 5, 2003 12:05 PM

Connecting to Audio Devices


Your GigaWorks S750 speaker cards, external audio devices, figures below show you how to
system can be connected to a wide external decoders and other connect them.
range of devices, including audio multichannel audio products. The

5.1, 6.1 and 7.1-Channel Audio Cards


7.1 channel: Creative Sound Blaster Audigy 2 ZS series GigaWorks S750

1 Front L/R
(Lime Green)
1 Lime Green Subwoofer
2 Rear L/R Black back panel
Side Right (Black) 2
Orange
3
Center/ Grey
3 Sub/
Side Left (Orange)
use supplied 7.1
analog audio cable

6.1 channel: Creative Sound Blaster Audigy 2 series GigaWorks S750

1 Front L/R
(Lime Green)
Lime Green
2 Rear L/R 1
(Black) Black
Subwoofer
2 back panel
Orange
3 Center/ 3
Sub/ Grey
Rear Center
(Orange)
use supplied 7.1
analog audio cable

5.1 channel: Creative Sound Blaster Audigy or Live! 5.1 series GigaWorks S750

3
3 Center/ Lime Green
Sub (Orange) Subwoofer
Black
back panel
Orange
1
Grey
2
1 Front L/R
(Lime Green)

2 Rear L/R use supplied 7.1


(Black)
analog audio cable

9
MWorks THX S750 CLE.book Page 10 Friday, September 5, 2003 12:05 PM

External Set top devices


DDTS-100 External 6.1 channel decoder GigaWorks S750
1 Front L/R (Lime
Green)
use supplied 7.1 analog
2 Rear L/R (Black) audio cable
Center/Sub/
Subwoofer
3
Rear Center 1 Lime Green
back panel
(Orange) Black
2
Orange
3
Grey

Creative USB Sound Blaster Audigy 2 NX GigaWorks S750


4 x stereo-miniplug to stereo-miniplug
cables (available separately)
1 Front L/R

2 Rear L/R 3 2 1
1 3
3 Center/Sub
Rear Center
Subwoofer
4 Side L/R
back panel
4
2 4

Creative Sound Blaster Audigy 2 ZX Pro GigaWorks S750

4 sets stereo RCA to stereo miniplug cables (available separately) 1 3

1 Subwoofer
1 Front L/R 2
3 back panel
2 Rear L/R 4
3 Center/Sub 4 pairs stereo RCA-to-miniplug
Rear Center 2 4
converters (available separately)
4 Side L/R

External Surround decoder, or DVD Player with built-in 5.1 decoder GigaWorks S750

Lime Green
1 Black

2 Orange Subwoofer
3
Grey
back panel
1 Front L/R use supplied 7.1 analog
audio cable
2 Rear L/R
3 Center/Sub 1 2 3
Rear Center 3 pairs stereo RCA-to-miniplug converters (available separately)

10
MWorks THX S750 CLE.book Page 11 Friday, September 5, 2003 12:05 PM

Understanding Upmixing
on other Creative audio products;
you should only enable upmixing
on either your audio device or your
GigaWorks S750 (but not both).
The table below shows you when
With the Upmix feature, the 5.1 you should bypass the upmixing
or 6.1-channel content can be feature on your speakers. The
played through all seven satellite upmix feature only applies to a 5.1
speakers on your GigaWorks. This and 6.1 signal from the output
creates a 7.1-channel sound field source device. Auxiliary and
that improves side and rear M-PORT analog stereo inputs are
imaging. unaffected.
This Upmix feature is also found

No. of audio channels Recommended GigaWorks Number of speakers


Source Device
on source device Upmix settings utilised

Audigy 2 ZX Up to 7.1 No upmix required. Up to 7.1


(Upmixing from the source device (depending on source)
recommended)

Audigy 2 Up to 6.1 6.1 → 7.1 7.1

Audigy or 5.1 SB Up to 5.1 5.1 → 7.1 7.1


Live!

USB Sound Up to 7.1 No upmix required. Up to 7.1


Blaster Audigy 2 (Upmixing from the source device (depending on source)
NX recommended)

Audigy 2 ZX Up to 7.1 No upmix required. Up to 7.1


Platinum (Upmixing from the source device (depending on source)
recommended)

Creative Decoder Up to 6.1 6.1 → 7.1 7.1


DDTS-100
(Speaker configu-
ration set to 6.1 or
7.1)

DVD player with Up to 5.1 5.1 → 7.1 7.1


built-in surround
decoder

Table 2: How upmixing maximises the usage of your GigaWorks S750

11
MWorks THX S750 CLE.book Page 12 Friday, September 5, 2003 12:05 PM

Using Multiple Inputs


The Audio Control Pod’s Auxiliary portable digital audio player, with- hear when using multiple inputs in
input connector allows you to mix out routing through a computer. different ways.
an audio program source (Auxiliary The main 7.1 channel output is
Analog Input) with the main 7.1- always audible; if both the Auxiliary
channel program source. and M-PORT inputs are used, the Note: In certain situations, you may
In addition, the M-PORT input Auxiliary input will be heard instead require additional cables that are
lets you hear audio directly from an of the M-PORT input. available separately.
M-PORT compatible Creative Table 3 lists what sounds you will

Table 3: Mixing audio through the Auxiliary inputs


7.1 Analog Input Auxiliary Input M-PORT Result
Connected Not connected Connected 7.1 Analog input and M-PORT input mixed
Connected Connected Not connected 7.1 Analog input and Auxiliary input mixed
Not connected Connected Connected Auxiliary input only
Connected Connected Connected 7.1 Analog input and Auxiliary input mixed

Controlling Noise and Distortion

The Creative GigaWorks S750 ❒ Use the remote control as your as Microphone, and set the
speakers have moderately high master volume control. remaining input controls to about
input sensitivity, so they may ❒ If your speaker system is 70% of their maximum volume.
amplify the hum and hiss inherent connected to a computer, adjust the ❒ Adjust the master output volume of
settings of your computer’s sound your sound control software, such
in some audio program sources.
control software. (If you are using that your speaker system reaches a
Any background noise you hear is
Creative Sound Blaster software, comfortably loud volume in its
not due to a fault in the speaker this would be the Surround Mixer default volume settings.
system. You can minimise application). Turn off any input
background noise as follows: controls that you do not need, such

Specifications and Upgrade Option

GENERAL SPECIFICATIONS Input Voltage


For Europe/Asia:
Satellite Power 220-240Vac 50/60 Hz 3A
70 Watts RMS per channel Magnetic Shielding
Subwoofer Power All satellite speakers are shielded
210 Watts RMS to allow placement close to display
Frequency Response devices that are sensitive to
25 Hz ~ 40 kHz magnetic fields.
Signal-to-Noise Ratio (SNR)
99 dB

12

You might also like