Professional Documents
Culture Documents
5 A Continuous On-State Current 30 A Surge-Current Glass Passivated Wafer 400 V to 800 V Off-State Voltage Max IGT of 200 A
This series is currently available, but not recommended for new designs.
TO-220 PACKAGE (TOP VIEW)
K A G
MDC1ACA
absolute maximum ratings over operating case temperature (unless otherwise noted)
RATING Repetitive peak off-state voltage (see Note 1) TIC106M TIC106N Repetitive peak reverse voltage Continuous on-state curr ent at (or below) 80C case temperature (see Note 2) (see Note 3) TIC106S TIC106D SYMBOL VDRM VALUE 400 600 700 800 400 VRRM IT(RMS) IT(AV) ITSM PGM TC TL IGM 600 700 800 5 3.2 0.2 1.3 -40 to +110 -40 to +125 230 0.3 30 V A A A A V UNIT
TIC106D
Average on-state current (180 conduction angle) at (or below) 80C case temperature
Surge on-state current at (or below) 25C (see Note 4) Peak gate power dissipation (pulse width 300 s) Average gate power dissipation (see Note 5) Storage temperature range Operating case temperature range Peak positive gate current (pulse width 300 s)
PG(AV) Tstg
W C C C W
NOTES: 1. These values apply when the gate-cathode resistance RGK = 1 k. 2. These values apply for continuous dc operation with resistive load. Above 80C derate linearly to zero at 110C. 3. This value may be applied continuously under single phase 50 Hz half-sine-wave operation with resistive load. Above 80C derate linearly to zero at 110C. 4. This value applies for one 50 Hz half-sine-wave when the device is operating at (or below) the rated value of peak reverse volta ge and on-state current. Surge may be repeated after the device has returned to original thermal equilibrium. 5. This value applies for a maximum averaging time of 20 ms.
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
6: This parameter must be measured using pulse techniques, tp = 300 s, duty cycle 2 %. Voltage sensing-contacts, separate from the current carrying contacts, are located within 3.2 mm from the device body.
thermal characteristics
PARAMETER RJC RJA Junction to case thermal resistance Junction to free air thermal resistance MIN TYP MAX 3.5 62.5 UNIT C/W C/W
PRODUCT
2
INFORMATION
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
THERMAL INFORMATION
AVERAGE ANODE ON-STATE CURRENT DERATING CURVE
IT(AV) - Maximum Average Anode Forward Current - A 6 Continuous DC 5 PA - Anode Power Dissipated - W
TI20AA
4 = 180 3
10
Figure 1.
Figure 2.
10
Figure 3.
Figure 4.
PRODUCT
INFORMATION
3
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.
TYPICAL CHARACTERISTICS
GATE TRIGGER VOLTAGE vs CASE TEMPERATURE
1 VAA = 12 V VGT - Gate Trigger Voltage - V 08 RL = 100 tp(g) 20 s 06 IH - Holding Current - mA RGK = 1 k
TC20AB
04
02
0 -50
-25
25
50
75
100
125
0.1 -50
-25
25
50
75
100
125
TC - Case Temperature - C
TC - Case Temperature - C
Figure 5.
Figure 6.
2.0
1.5
1.0
0.5
0.0 01
10
Figure 7.
PRODUCT
4
INFORMATION
APRIL 1971 - REVISED SEPTEMBER 2002 Specifications are subject to change without notice.