You are on page 1of 9

TD62801P/F

TOSHIBA BIPOLAR DIGITAL INTEGRATED CIRCUIT SILICON MONOLITHIC

TD62801P,TD62801F
8BIT SHIFT REGISTER / LATCH / DRIVER
The TD62801P, TD62801F are specifically designed for thermal printing head drivers utilizing a new high speed, high voltage I2L process.

FEATURES
l 8bit serialin parallelout shift register / latch / 8bit driver transistors. l Output current (Single Output) IOUT = 70 mA MAX. l High output voltage VOUT = 24 V MIN. l Input compatible with TTL l Internal auto reset function l Standard supply voltage l Package typeP : DIP16 pin l Package typeF : HSOP16 pin

PIN CONNECTION (TOP VIEW)

Weight DIP16P3002.54A : 1.11 g (Typ.) HSOP16P3001.00 : 0.50 g (Typ.)

2001-07-05

TD62801P/F
BLOCK DIAGRAM

TIMING DIAGRAM

2001-07-05

TD62801P/F
TRUTH TABLE
CK E H H H L * * * * H CK = CLOCK E = ENABLE R = RESET LATCH = LATCH SIN = SERIAL IN OUT = PARALLEL OUT SOUT = SERIAL OUT R H H H H * L
LATCH

SIN L H * * * * *

OUT
O1 On On - 1 On - 1

SOUT Q7 Q7 Q7 Q7 Q7 L L

H H L * * H L

OFF ON NC OFF NC OFF NC

NC OFF NC OFF NC

* = DONT CARE NC = NO CHANGE L = LOW LEVEL H = HIGH LEVEL

MAXIMUM RATINGS (Ta = 0~75C)


CHARACTERISTIC Supply Voltage Input Voltage Output Voltage Output Sustaining Voltage Input Current Output Current Power Dissipation Operating Temperature Storage Temperature P F SYMBOL VCC VIN VOUT (Note 1) VCE (SUS) (Note 2) IIN IOUT2 (Note 2) PD (Note 4) Topr Tstg RATING 0.3~6.0 0.3~VCC + 0.3 0.3~VCC + 0.3 0.3~26 1 70 1.47 1.4 (Note 3) 0~70 55~150 UNIT V V V V mA mA / ch W C C

Note 1: Note 2: Note 3: Note 4:

SOUT O1~O8 On PCB (60 30 1.6 mm Cu 30%) Delated above 25C in the proportion of 11.7 mW / C (PType), 11.2 mW / C (FType)

2001-07-05

TD62801P/F
RECOMMENDED OPERATING CONDITIONS (Ta = 0~70C)
CHARACTERISTIC Supply Voltage Output Voltage H Level Input Voltage H Level Output Current L Level SOUT SOUT On On SYMBOL VCC VOH VIN IOH IOL IOL fCLOCK fw CLOCK tsetup thold TEST CONDITION MIN 4.5 0 0 0 0 0 0 1 100 100 TYP. 5.0 MAX 5.5 24 VCC 0.4 8 60 500 kHz s s s mA UNIT V V V

Clock Frequency Clock Pulse Width Data Set Up Time Data Hold Time

ELECTRICAL CHARACTERISTICS (Ta = 0~70C)


CHARACTERISTIC Input Voltage H Level L Level H Level L Level H Level Output Voltage L Level Output Current H Level ShortCircuit Output Current Supply Current SOUT SOUT On On H Level SYMBOL VIH VIL IIH IIL VOH TEST CIR CUIT VCC = 5.5 V TEST CONDITION VIN = 2.4 V VIN = 5.5 V MIN 2.0 4.0 2.4 5 TYP. 0.14 0.37 20 2.8 0.2 0.2 16 55 MAX 0.8 0.3 0.7 50 0.4 0.6 100 50 80 A mA mA V UNIT V

Input Current

mA A

VCC = 5.5 V, VIL = 0.4 V VCC = 5.0 V, VOH = 10 A VCC = 4.5 V, IOH = 400 A VCC = 4.5 V, IOL = 8 mA VCC = 4.5 V, IOL = 60 mA VCC = 4.5 V, VOH = 2.4 V VCC = 5.5 V VCC = 5.5 V

VOL IOH IOS ICC

2001-07-05

TD62801P/F
SWITCHING CHARACTERISTICS (Ta = 25C)
CHARACTERISTIC CKSOUT CKOn H Level LOn ROn Propagation Delay Time EOn CKSOUT CKOn L Level LOn RSOUT EOn Maximum Clock Frequency CK Minimum Pulse Width CK L R Data Set Up Time Data Hold Time Rise Time Fall Time fMAX twCK twCK twL twR tsetup thold tr tf tpHL VCC = 5.0 V VIH = 3.0 V VIL = 0 V Duty = 50% RL SOUT = 2 k RL On = 82 CL = 15 pF tpLH SYMBOL TEST CIR CUIT TEST CONDITION MIN TYP. 0.6 2.5 2.1 2.2 1.5 0.35 0.6 0.32 0.3 0.1 1.6 250 280 230 300 20 20 70 70 MAX 1.5 6.5 5.0 6.0 4.0 1.0 1.5 1.0 1.0 0.3 600 700 600 1000 50 50 ns ns ns ns ns MHz s UNIT

PRECAUTIONS for USING


This IC does not integrate protection circuits such as overcurrent and overvoltage protectors. Thus, if excess current or voltage is applied to the IC, the IC may be damaged. Please design the IC so that excess current or voltage will not be applied to the IC. Utmost care is necessary in the design of the output line, VCC and GND line since IC may be destroyed due to shortcircuit between outputs, air contamination fault, or fault by improper grounding.

2001-07-05

TD62801P/F
PACKAGE DIMENSIONS
DIP16P3002.54A Unit: mm

Weight: 1.11 g (Typ.)

2001-07-05

TD62801P/F
PACKAGE DIMENSIONS
HSOP16P3001.00 Unit: mm

Weight: 0.50 g (Typ.)

2001-07-05

TD62801P/F

RESTRICTIONS ON PRODUCT USE

000707EBA

TOSHIBA is continually working to improve the quality and reliability of its products. Nevertheless, semiconductor devices in general can malfunction or fail due to their inherent electrical sensitivity and vulnerability to physical stress. It is the responsibility of the buyer, when utilizing TOSHIBA products, to comply with the standards of safety in making a safe design for the entire system, and to avoid situations in which a malfunction or failure of such TOSHIBA products could cause loss of human life, bodily injury or damage to property. In developing your designs, please ensure that TOSHIBA products are used within specified operating ranges as set forth in the most recent TOSHIBA products specifications. Also, please keep in mind the precautions and conditions set forth in the Handling Guide for Semiconductor Devices, or TOSHIBA Semiconductor Reliability Handbook etc.. The TOSHIBA products listed in this document are intended for usage in general electronics applications (computer, personal equipment, office equipment, measuring equipment, industrial robotics, domestic appliances, etc.). These TOSHIBA products are neither intended nor warranted for usage in equipment that requires extraordinarily high quality and/or reliability or a malfunction or failure of which may cause loss of human life or bodily injury (Unintended Usage). Unintended Usage include atomic energy control instruments, airplane or spaceship instruments, transportation instruments, traffic signal instruments, combustion control instruments, medical instruments, all types of safety devices, etc.. Unintended Usage of TOSHIBA products listed in this document shall be made at the customers own risk. The products described in this document are subject to the foreign exchange and foreign trade laws. The information contained herein is presented only as a guide for the applications of our products. No responsibility is assumed by TOSHIBA CORPORATION for any infringements of intellectual property or other rights of the third parties which may result from its use. No license is granted by implication or otherwise under any intellectual property or other rights of TOSHIBA CORPORATION or others. The information contained herein is subject to change without notice.

2001-07-05

This datasheet has been download from: www.datasheetcatalog.com Datasheets for electronics components.

You might also like