Professional Documents
Culture Documents
Technical Note
Input Data
This Technical Note describes the composite beam design input data for AISCASD89. The input can be printed to a printer or to a text file when you click the File menu > Print Tables > Composite Beam Design command. A printout of the input data provides the user with the opportunity to carefully review the parameters that have been input into the program and upon which program design is based.
Page 1 of 7
Input Data
Beam Properties
Composite Type
Shoring Provided
b-eff Left
b-eff Right
Beam Fy
Beam Fu
Page 2 of 7
Input Data
Cover Plate
This information is included on the Beam tab of the overwrites. Plate Width Plate Thick Plate Fy Consider Cover Plate Width of the cover plate. Thickness of the cover plate. Yield stress of the cover plate. If this item is "Yes," the specified cover plate is considered in the design of the beam. Otherwise, the cover plate is not considered in the beam design.
Unbraced L22
L22 Absolute
Cb Factor
Page 3 of 7
Input Data
Point Braces
The heading of the point braces data table specifies whether the point braces are program calculated or user-defined, and whether the distances used to locate the point braces (Location item) are absolute (actual) distances or relative distances. A relative distance is the distance divided by the length of the beam. Location This is the distance from the I-end of the beam to the point brace. As described in the preceding paragraph, it may be an absolute or a relative distance. The choices for this item are TopFlange, BotFlange or BothFlngs. TopFlange means only the top flange is braced at this point. BotFlange means only the bottom flange is braced at this point. BothFlngs means both the top and bottom flanges are braced at this point.
Type
Uniform Braces
The heading of the uniform braces data table specifies whether the point braces are program calculated or user-defined, and whether the distances used to define the extent of the uniform braces (Start and End items) are absolute (actual) distances or relative distances. A relative distance is the distance divided by the length of the beam. Note: Details about the location and type of program calculated point and uniform braces is only reported after you have run the design. Before you run the design, this information is not available. Start This is the distance from the I-end of the beam to the starting point of the uniform brace. As described in the preceding paragraph, it may be an absolute or a relative distance. This is the distance from the I-end of the beam to the ending point of the uniform brace. This distance is always larger than the Start item. As described previously, it may be an absolute or a relative distance. The choices for this item are TopFlange, BotFlange or BothFlngs. TopFlange means only the top flange is uniformly braced along the specified length. BotFlange means only the bottom flange is uniformly braced along the specified length. BothFlngs means both the top and bottom flanges are uniformly braced along the specified length.
End
Type
Page 4 of 7
Input Data
Deck Properties
Beam Side
Deck Label
Deck Direction
Page 5 of 7
Input Data
End
Length Number
Other Restrictions
Limit Beam Depth
Page 6 of 7
Input Data
EQF
1/3 Increase
Page 7 of 7