You are on page 1of 3

VITAE

MUHAMMAD AFNAN
Postal Address: House No 3 Street No 3 Mehboob Colony Mian Channu Distt. Khanewal Punjab (Pakistan) Current Address: Dammam, Saudi Arabia Cell # +966-599450067 E-mail: itsafnan@hotmail.com Skype: itsafnan OBJECTIVE To get chance in your esteemed organization to build my career and utilize my technical expertise to fulfil the organizational requirements. ACADEMIC QUALIFICATION:

Examination
S.S.C (Science) D.A.E Petroleum (Oil & Gas) Graduation

Year
2006 2009 2011

Marks
833 / 1050 2587 / 3500 503 / 800

Board
B.I.S.E Multan P.B.T.E Lahore B.Z.U Multan

PROFESSIONAL SKILLS
Gulf Chemicals and Industrial oil Company (Dammam) Saudi Arabia Presently I am performing duties as a Process Operator from (13-03-2013 till now)
Following process known well. Dewaxing of Transformer Oil Dehydration Evaporation Extraction

PROFESSIONAL EXPERIENCE (Pakarab Fertilizer (Pvt) Ltd Multan) I have working experience as a Plant operator/Process operator from September 2009 to 01-03-2013 in Pakarab Fertilizer (Pvt) Ltd Multan Pakistan . (03 years & 6 month) AIR COMPRESSOR Manufactured by GHH GERMANY Discharge Pressure 5Kg/Cm2 Flow 98000 NMC/Hr Type Centrifugal Axial Compressor is driven by Steam Turbine And Flue Gases Turbine Power 9.0MW.

STEAM TURBINE Manufactured by AEG-KANIS. Steam Turbine Is Impulse Reaction & Condensing Type. Power 5.9 MW RPM 6630 Temp 490 C0 Control System Hydraulic Governor Control HEAT RECOVERY STEAM GENERATION UNIT (La-Mont Boiler) Capacity 34 Ton/hour Pressure 42 kg/cm2 Temperature 490 C0 Furnace Forced Circulation FLUE GASES TURBINE Manufacture by GHH GERMANY. Power 3.1 MW Inlet temp 250 C0 Inlet pressure 3.5 Kg/Cm2 Driver of Air Compressor by shearing the load of Steam Turbine. Gas Turbine is driven by tail gas (NO2). Nitric Acid is being prepared by under Ostwards Process and following optional parameter are used as under Absorption Towers (bubble caps, sieve trays & packed column) NH3 Evaporator Air Blowers NH3 Separator Centrifugal Pumps (single/multi stages) NH3 strippers Hydraulic Pumps Heat Exchangers Turbine Pumps NH3 & CHEMICAL HANDLING Handling of Ammonia (240 Ton/Day) through Centrifugal Pumps (Discharge Pressure 12 Kg/Cm2) and NH3 Evaporator, NH3 Separator and NH3 Stripper are also used. Handling of Nitric Acid (1200 m3/Day) by the Centrifugal Pumps (Discharge Pressure 10 kg/cm2) transfer to storage tank. SKILL IMPROVEMENT COURSES ATTENDED I also got special training of following equipment Centrifugal Pumps Heat And Heat Exchangers Steam Turbine Centrifugal Compressor Energy Conservation HSE SAFETY CONSCIOUS I have also got special safety training and attended lectures about safety & skill improvement. I have also got fire fighting and I am the member of fire fighting squid. I know the use of Ammonia Mask, Chlorine Mask, NO2 Mask and SCABA. 2

PTW SYSTEM I have good knowledge of handling over and take over off all kind of work permits that is cold WP, hot WP, vessel entry, examination & etc. I have plenty of potential to develop and read to work under stress and strain. I assure you that if I had been given a chance I would prove you, myself worth of the charge.

TURNAROUND EXPERIENCE I have participated in the activities of Air blowing of Process Gas and Fuel Gas Circuits. Steam blowing of HP, MP & LP. Flushing of Cooling Water. Demin Water and Boiler Feed Water Lines. I have worked in Annual Shut Down at PAKARAB FERTILIZER (Pvt) Ltd MULTAN, TA- 2009, TA-2010 & TA-2011 I have got vessel attendant training as well and performed duty as a Stand By Man. COMPUTER SKILLS I have sufficient knowledge of the operation of Computers. I am experienced in the Installation of Windows, 98 & XP, 2002 & 2004. I have sufficient knowledge of use of MS. Office, 97, XP-2002 &2004. PERSONAL INFORMATION Fathers Name Date of Birth Religion N.I.C # Domicile Marital Status Passport No. Peer Bakhsh 19-07-1991 Islam 36104-3199310-5 Khanewal (Punjab) Single B43188826

You might also like