Professional Documents
Culture Documents
Purpose
The purpose of this lab was to determine both quantitatively and qualitatively how various gases deviate from the Ideal Gas Law in their behavior.
2HCl(aq)+NaCO3(s)= 2NaCl(aq)+H2O(l)+CO2 Trial 1: Pi=1.01 atm 83.33% Trial 2: Pi=1.01 atm 89.67% Pf=1.275 atm Pf=1.279 atm P=0.265 atm Yield: P=0.269 atm Yield:
*We omitted the trials when we were using a defective beaker that leaked. Pressure did not change as hydrogen gas was produced to the leak Airbag Results Na2CO3(s)+2CH3COOH(aq)2CH3COONa(aq)+H2O(l)+CO2(g) 3.339 grams of Na2CO3 was needed to theoretically inflate the airbag We observed in the airbag reaction that the airbag inflated and became very full, but not as full as it could be. This is due to carbon dioxide not being an ideal gas. A milky white solution was also produced, and the bag
Calculations
Part 1 Mg(s)+2HCL (aq)MgCl2(aq)+H2(g) Theoretical V=0.13 L T=298 K Pi=1.00 atm Pf=1.3 atm N=(PV)/(RT)=0.00159 moles of gas produced 0.00159 moles H2*(1 mol Mg/1 mol H2)=0.00159 moles Mg needed 0.00159 moles H2*(2 mol HCl/1 mole H2)=0.00318 moles of HCl needed n(theoretical)=0.00159 moles H2 Actual n(actual)=((0.26 atm)(0.13L))/(0.0821*298 K)=0.00138 moles percent yield: 0.00138/0.00159=86.9% Part 2 Na2CO3(s)+2CH3COOH(aq)=2CH3COONa(aq)+H2O(l)+CO2(g) Theoretical n=(PV)/(RT)=((1.01 atm)(0.75 l))/(0.0821 mol L*atm/mol*K)(293 K)=0.0315 moles of gas needed to fill the bag. By molar proportions, 0.0315 moles of Na2CO3 would be needed as well, and 0.063 moles of CH3COOH would be needed 0.00315 moles Na2CO3=3.34 g needed 0.063 moles CH3COOH*(1 Liter/6 mol CH3COOH)=0.0105 L of CH3COOH needed. Actual 3.339 g of Na2CO3 used, and excess acetic acid (0.015L) Van der Waals correction shown below
Discussion
1. Although we should expect to see that both reactions yield a pressure of 0.3 atm, the pressure produced by the reaction with sodium carbonate was higher than the pressure produced by the reaction where magnesium was used. The yield for the experiment where sodium carbonate was used was also much higher. With magnesium, the average yield over the two trials was 78.35%. The average yield where sodium carbonate was used was 86.5%. This indicates that either higher proportion of sodium carbonate reacted, or that the carbon dioxide produced 2. One source of error could be the reactions not going to completion before pressure readings were recorded. After we recorded our final pressures, we noticed that the pressure continued to rise, albeit slowly. This would result in a recorded pressure that was lower than the true pressure after the reaction went to completion. This might account for the low yields. 3. The yield in the sodium carbonate reaction where carbon dioxide was produced was much higher than the yield in the magnesium reaction where hydrogen was produced. This is due to the size of the carbon dioxide molecules. Since carbon dioxide molecules take up more space than hydrogen molecules, the effective volume of the rigid container is smaller when it is filled with carbon dioxide than when it is filled with hydrogen. The smaller volume available in the beaker filled with carbon dioxide gas translates to a higher observed pressure, and a higher observed yield.