Professional Documents
Culture Documents
Quantum dot (QD) is a conducting island of a size comparable to the Fermi wavelength in all spatial directions. Often called the artificial atoms, however the size is much bigger (100 nm for QDs versus 0.1 nm for atoms). In atoms the attractive forces are exerted by the nuclei, while in QDs by background charges. The number of electrons in atoms can be tuned by ionization, while in QGs by changing the confinement potential. This is similar by a replacement of nucleus by its neighbor in the periodic table.
Quantum dots
Comparison between QDs and atoms Parameter Level spacing Ionization energy Typical magnetic field Atoms 1 eV 10 eV 104 T Quantum dots 0.1 meV 0.1 meV 1-10 T
QDs are highly tunable. They provide possibilities to place interacting particles into a small volume, allowing to verify fundamental concepts and foster new applications (quantum computing, etc).
Quantum dots 3
The Au electrodes (bright) have a height of 100 nm. The two QPCs formed by the gate pairs F-Q1 and F-Q2 can be tuned into the tunneling regime, such that a QD is formed between the barriers. Its electrostatic potential can be varied by changing the voltage applied to the center gate Lateral quantum dot
Quantum dots 5
Conductances of all QPCs can be tuned by proper gate voltages. The F-Q1 and F-Q2 pairs behave as perfect quantized QPCs The contact F-C cannot be pinched off, but still shows depletion The central gate is designed to couple well to the dot, but with a weak influence on QPCs. Blue arrow shows the working point.
Quantum dots 6
Gate voltage characteristics Pronounced oscillations The reason of the oscillations was not clear in the beginning: Coulomb blockade? Resonant tunneling?
Quantum dots
The position of 22 consecutive conductance resonances as function of the gate voltage and the magnetic field. The QD has an approximately triangular shape with a width and height of about 450 nm. The upper inset shows peak spacings at B=0 as a function of QDs occupation. They are consistent with theory (FockDarwin- model)
center gate
Quantum dots 8
Why the peaks are not equidistant? There is a smooth dependence on the gate voltage, just because of change in the geometry (and consequently, in capacitances); In addition to a smooth dependence there are pronounced fluctuations a rather rich fine structure. This fine structure is shown in the next slide, where the smooth part is subtracted
Quantum dots
One can discriminate between three main regimes: 1. Weak magnetic fields the spacings fluctuate, with a certain tendency to bunch together for small occupation numbers; 2. Intermediate regime quasiperiodic cusps; 3. High magnetic fields
Level fine structure for up to 45 electrons on the dot
How does the stability diagram look? Resembles diamond structure for Coulomb blockage (SET) system. However, size of diamonds fluctuates. At low bias resembles usual CB oscillations; At larger bias a fine structure emerges, which is absent in SETs
Quantum dots
11
Finally, the amplitude of resonances can be tuned by magnetic field: Here we see amplitudes of five consecutive resonances versus magnetic field. The peak positions fluctuate by about 20% of their spacing, while the amplitude varies by up to 100%. Plenty of features are waiting for their explanation!
Quantum dots
12
What would follow from the picture of non-interacting particles? QD is a zero-dimensional system, its density of states consists of a sequence of peaks, with positions determined by size and shape of the confining potential, as well as by effective mass of the host material. To estimate the average spacing let us use the 2D model:
This energy should be compared with the typical charging energy, since for an isolated dot the Coulomb blockade must come into play. So we have to develop a way to find the electron addition energy.
Quantum dots 13
Quantum dots
14
How much do we pay to add an electron to a quantum dot? Suppose that the highest level in the dot is the next electron will occupy the level the lowest energy. . Then having
To find the addition spectrum one has to add this energy to the electrostatic gain, E. Correspondingly, if we want to remove an electron it is necessary to subtract . According to the CI model, one assumes that the kinetic energies are independent of the number electrons on the dot. The CI model disregards electron correlations
Quantum dots 15
The stability diagram consists of a semi-infinite set of diamonds of similar shape. However, their sizes (both along the V and VG axes) fluctuate due to variation of the level spacing. Therefore, the diamond structure is distorted.
Maximum extension in V-direction:
Electrostatic energy Kinetic energy
Quantum dots
16
What we have subtracted as a smooth part of the level spacing is just EC, so we are left with fluctuations of singleparticle energies. So far so good, but what should we do with magnetic field? Let us use an analytically solvable model (Fock, Darwin)
Then the energy terms are determined by the radial quantum number, n = 0,1,2 , and by the angular momentum quantum number, The spectrum has the form
Quantum dots 17
Each level has orbital degeneracy of j, in addition, there is a spin degeneracy 2. Similar to the atomic spectra, we can speak about jth Darwin-Fock shell. Filled shells correspond to N=2, 6, 12, 20, ..
Magnetic field will remove both orbital and spin degeneracy giving rise to rather complicated spectra.
Quantum dots 18
n, l, spin
Predicted evolution of conductance resonance versus gate voltage and magnetic field
19
Quantum dots
The Darwin-Fock model is a good starting point it gives an idea about spectrum in magnetic field - one can indicate filled shells at N=2, 6, 12, 20 - it predicts behavior of conductance resonances However, the agreement with experiment is not prefect
Quantum dots
20
We have explained the lowfield part of the curves by the Fock-Darwin model. Now we have to explain the cusps.
Quantum dots
21
Intermediate magnetic fields Since in a strong magnetic field confinement is not too important it is reasonable to come back to Landau levels. Let us define:
In large magnetic field the confinement can be neglected and m+1 is just the Landau level number.
Quantum dots 22
Different p
Quantum dots 23
Now let us assume that the filling factor is between 2 and 4, i. e., only two lowest Landau levels are occupied.
States with m=1 decrease in energy when magnetic field increases, while the states with m=2 increase. Since the number of particles is conserved, the Fermi level is switched between the Landau levels the electrochemical potential moves along the zigzag line.
Quantum dots
24
States belonging to LL1 are closer to the edge and better coupled to the leads
Quantum dots
25
The qualitative results are similar for dot with different shape. Below the results for hard wall confinement are shown
However, the shape can be to some extent reconstructed from the behavior of level spacings.
Quantum dots 26
angular moment
Quantum dots
28
The CI model does not include exchange and correlation effects, such as spin correlations, screening, etc. Here we discuss some of such effects. Hunds rules in quantum dots As known from atomic physics, Hunds rules determine sequence of the levels filling: 1. The total spin gets maximized without violation the Pauli principle (originates in exchange interaction keeping the electrons with parallel spins apart) 2. The orbital angular moment must be maximal keeping restrictions of the rule #1.
Quantum dots
29
Filling of the Fock-Darwin potential by first 6 electrons at B = 0. Configurations are labeled as in atomic physics, 2S+1LJ. Here S is the spin, J is the total moment, L is the orbital moment. What happens in strong magnetic field, above the threshold for cusps, i. e. for filling factor below 2? The CI model will fail and correlation effects become extremely important.
Quantum dots 30
Magnetic field dispersion of the levels from 30 to 50 Energy of 39th level The crossings are only due to spin no orbital crossings
Relatively rare crossing are expected, however, rapid oscillations in the peak positions were found. Experimental summary
Quantum dots
To explain the observed features let us revisit the picture of edge channels.
Guiding center lines for =2 (metallic states) Corresponding LLs Screening in the metallic regions Potential drops concentrate in the insulating regions Edge states evolve into metallic stripes (Chklovskii et al.)
Quantum dots 32
Density profile
Let us adapt this picture to circular dots. We arrive at a metallic ring and a disk separated by an insulating ring. The concrete structure depends on effective g-factor. Now we have to discuss the Coulomb blockade in such system. The electrostatic cost of the electron transfer between the spin-down and spin-up sublevels should be taken into account. It can be done using an equivalent circuit.
Quantum dots 33
The electrostatic is not simple since capacitances depend on magnetic field, coupling of the gate voltage to different island is different, etc. The theory turned out to be rather successful. Experiment Theory
Quantum dots
34
Thus we arrive at the following summary: In weak magnetic field Fock-Darwin model allows for the conductance resonances; In intermediate magnetic fields the fieldinduced repopulation of LLs becomes crucially important; In strong magnetic field the CI model fails, and correlation effects become important. The most important are spin correlations in combination with screening effects (stripes).
Quantum dots
35
Quasi-chaotic
The upper levels depend on magnetic field in a quasi-chaotic fashion. Sometimes people call such a behavior the quantized chaos.
Quantum dots
36
At large occupation numbers and in weak magnetic fields many levels are involved, and the energy spectrum becomes very complicated. Is it any way to find universal properties avoiding concrete energy spectrum? The proper theory is referred to as quantized chaos. The classical system is called chaotic if its evolution in time depends exponentially on changes of the initial conditions. Example - a particle in the box, classical dynamics with specular reflection. The trajectory depends on the initial condition, p(0) and r(0).
Quantum dots 38
Let us discuss how the difference between 2 trajectories, evolves in time for the time much larger then the elementary traversal time provided the position difference at the initial time is infinitesimally small. The answer strongly depends on the shape of the cavity. If it diverges exponentially, then the cavity is called chaotic. Otherwise it is called regular. Most shapes like the Sinai billiard show chaotic dynamics. Quantization of chaotic dynamics is a tricky business
Quantum dots 39
Universal distribution of the nearest-neighbor peak separations (NNS) and distribution of conductance resonances are the main topics discussed in context of QDs. The separations are plotted as a histogram, and then fitted by some distribution function. For the Fock-Darwin system at B=0 we obtain
For a regular system the distribution is non-universal. In chaotic systems the distributions are universal, but not random (Poissonian)! The concrete form of the distribution depends on the symmetry of the Hamiltonian.
Quantum dots 40
Random matrix theory Hamiltonian is presented as a matrix in some basis, the matrix elements being assumed random, but satisfying symmetry requirements. If the Hamiltonian is invariant with respect to time inversion, then the matrix should be orthogonal. If time reversal symmetry is broken, then the matrix is unitary. These two cases are called the Gaussian orthogonal ensemble (GOE) and Gaussian unitary ensemble (GUE), respectively.
Quantum dots
41
The results of rather complicated analysis shows that these cases are covered by universal Wigner-Dyson distributions. With spin-degeneracy
Quantum dots
42
that
Quantum dots
43
Splitting:
Quantum dots
44
Now,
It is assumed here that p1 and p2 are smooth functions. From the invariance with respect to unitary transformation one would get Then there are three independent variables, and h1=Re h, h2=Im h.
Quantum dots 45
Then we have
Though not strictly proved, RMT agrees with experiments in many systems (excitation spectra of nuclei, hydrogen atom in magnetic field, etc.), as well as with numerical simulations
Quantum dots 46
An example of numerical calculations for Sinai billiard (about 1000 eigenvalues) histogram. Comparison with GOE Wigner surmise and Poisson distribution is also shown NNS distributions know whether the states are extended or localized. This property is extensively used in numerical studies of localization.
Quantum dots 47
In quantum dots, one subtracts single-electron charging energy from the measured addition spectrum. There is no signature of bimodal distribution! Why?
Experiment
Studies of NNS distributions is a powerful tool for optimizing various model for residual interactions in small systems. This area is still under development.
Quantum dots
49
Quantum dots
50
Earlier we discussed only the information emerging from peak positions. What can be found form the amplitude and shape of conductance resonances? Clearly, the peak shape and amplitude depend on the coupling to the leads. This fact can be used to find the properties of the wave functions. This is in contrast to SET where many states are coupled to the leads and the peak amplitudes are almost constant.
Quantum dots
51
To illustrate new possibilities let us revisit the earlier discussed conductance resonances
No current flow, electrochemical potentials are inside Coulomb gap As VG increased, a new process emerges. That leads to the scenario shown below Now 2 levels contribute to transport
As VG is increased further
Quantum dots
52
Single-particle levels can be determined by high-bias transport measurements. In fact, gates are not necessary.
What about shape of resonances? This is a complicated problem since all important parameters kB, , and h - are usually of the same order of magnitude. No analytical expression for the shape in general case since Coulomb correlation of tunneling through different barriers; Electron distribution function inside the dot is nonequilibrium
Quantum dots
55
Quantum dots
56
Surface clusters
Individual grains
Quantum dots
Nano-pendulum
57
Nanocrystals
Nanocrystals are aggregates of anywhere from a few hundred to tens of thousands of atoms that combine into a crystalline form of matter known as a "cluster." Typically around ten nanometers in diameter, nanocrystals are larger than molecules but smaller than bulk solids and therefore frequently exhibit physical and chemical properties somewhere in between. Given that a nanocrystal is virtually all surface and no interior, its properties can vary considerably as the crystal grows in size.
The rod-shaped nanocrystals to the far left can be stacked for possible use in LEDs, while the tetrapod to the far right should be handy for wiring nano-sized devices.
59
Quantum dots
Quantum dots are main ingredients of modern and future nanoscience and nanotechnology. There was a substantial progress in their studies, many properties are already understood. However, many issues, in particular, role of electronelectron orbital and spin correlations, remain to be fully understood. This is a very exciting research area.
Quantum dots
60