Professional Documents
Culture Documents
PART 2
LDO Schematic:
Buffer PMOS Selection: PMOS buffer is used because there will be better matching between the cascade amplifier stage and the Buffer stage. PMOS buffer is preferred as substrate and source are at same potential and in NMOS source and bulk are at different potential. Pass Transistor PMOS Selection: PMOS pass transistor is used since Vin and regulated voltage vary by small amount (.25V) and NMOS cannot be used as gate voltage (2.25+Vtn) needed in this is greater than maximum voltage available i.e. 2.5V and it requires additional charge .
Simulations: Width of pass transistor for different I loads are shown in simulations below (1 mA, 25m A, 50 mA)
Simulations:
Gain of differential amplifier with RC load as observed from the part 1 was 56.02 dB Gain with the buffer is now 51.23 dB. And bandwidth with RC load was 817.8 KHz and bandwidth with Buffer is 1.51 MHz. So the RC load assumption we made in part 1 was fairly reasonable. Observations: The input resistance of PMOS buffer is very high and the output resistance is low. So the input resistance of buffer is matched with the output resistance of the Differential amplifier and the output resistance of buffer is matched with input resistance of pass transistor. So there will be efficient transfer of power from one stage to other. Hand analysis calculated gain for pass transistor is 36 dB which is close to simulated value of 32 dB.