You are on page 1of 0

Nikola Biondic (GA/ETK)

Event Description
1A A Primary CPICH enters the Reporting Range (addition of a cell to the active set)
1B A Primary CPICH leaves the Reporting Range (removal of a cell from the active set)
1C
A Non-active Primary CPICH becomes better than an active Primary CPICH
(replacement of a cell within the active set)
1D Change of best cell in the active set
1E A Primary CPICH becomes better than an absolute threshold
Intrafrequency
reporting
events for the
FDD mode
1F A Primary CPICH becomes worse than an absolute threshold
1G Change of best cell in TDD
1H DL Timeslot ISCP below a certain threshold
Intrafrequency
reporting
events for the
TDD mode
1I DL Timeslot ISCP above a certain threshold
2A Change of best frequency.
2B
The estimated quality of the currently used frequency is below a certain threshold,
and the estimated quality of a nonused frequency is above a certain threshold.
(inter-frequency handover)
2C The estimated quality of a nonused frequency is above a certain threshold.
2D
The estimated quality of the currently used frequency is below a certain threshold.
(enter compressed mode, start measuring neighbour cells on other frequencies
(inter-frequency or inter-RAT), triggered by low DL signal)
2E The estimated quality of a nonused frequency is below a certain threshold.
Interfrequency
reporting
events
2F
The estimated quality of the currently used frequency is above a certain threshold.
(exit compressed mode)
3A
The estimated quality of the currently used UTRAN frequency is below a certain
threshold and the estimated quality of the other system is above a certain threshold.
(inter-RAT handover)
3B The estimated quality of the other system is below a certain threshold.
3C The estimated quality of the other system is above a certain threshold.
Intersystem
reporting
events
3D Change of best cell in other system.
4A Transport channel traffic volume exceeds an absolute threshold.
Traffic-volume
reporting
events
4B Transport channel traffic volume becomes smaller than an absolute threshold.
Quality
reporting
events
5A A predefined number of bad CRCs is exceeded.
6A
The UE Tx power becomes larger than an absolute threshold (enter compressed
mode, triggered by high UE power level)
6B
The UE Tx power becomes less than an absolute threshold (exit compressed
mode, triggered by resolution of 6a)
6C The UE Tx power reaches its minimum value
6D The UE Tx power reaches its maximum value
UE internal
measurement
reporting
events
6E The UE RSSI reaches the UEs dynamic receiver range
7A The UE position changes more than an absolute threshold.
7B SFN-SFN measurement changes more than an absolute threshold.
UE positioning
reporting
events
7C GPS time and SFN time have drifted apart more than an absolute threshold.

You might also like