Professional Documents
Culture Documents
Page 1 of 19
10 mA
R C 2.2 k
1.2 k
Vo
(a) 21.7V (b) 15V (c) 7.51V (d) 4.32V 7. Find the equivalent Transfer function to the given system (a) (b) (c) (d) 8. In 3 phase induction machine (or motor) torque angle and torque are maximum when (a) stator circuit is resistive (b) rotor circuit is purely resistive (c) rotor circuit is purely inductive (d) None of these. 9. For 3 phase induction motor which of the following is incorrect? (a) Due to presence of air gap, induction motor takes higher magnetizing current than transformer of same rating. (b) Rotor field rotate with synchronous speed with respect to the stator. (c) Efficiency of the induction motor is more than equivalent transformer. (d) At stand still rotor frequency is same as stator frequency.
Page 3 of 19
ON OFF V OFF
ON
I ON
OFF (iii)
The correct match is (a) MOSFET -(i) , BJT-(ii) , DIODE-(iii) (b) DIODE -(ii) , IGBT-(ii) , MOSFET-(iii) (c) DIODE -(i) , BJT-(iii) , MOSFET-(ii) (d) None of the above 11. In the circuit shown in figure, the value of Vx is (a) 17.5 V (b) -17.5 V (c) 35 V (d) -35 V
2 2
Vx
10 A
Page 4 of 19
13. For the given buck convertor, find the condition of discontinuous conduction mode (boundary condition)
(a) (b) (c) (d) 14. Consider the below subroutine LXI SP,2400H MVI C,01H PUSH B POP PSW RET After execution of this subroutine contents in the zero flag and carry flag will be respectively.
Page 5 of 19
at
in the
E V
+ Resistors V
0
I R
Page 6 of 19
x(t) A Exponential Decay (Ae-t), A is finite t 0 (a) Power signal with P=A2 (b) Energy Signal with E=A2/2 (c) Power Signal with P=A2/2 (d) Neither Energy nor Power Signal. 19. In the given circuit the current waveform through inductor in continuous conduction mode is
(fig: Buck convertor ) d=D =duty ratio = Switching time Note: Y-axis denote the inductor current iL. (a)
Page 7 of 19
(c)
(d)
Page 8 of 19
Page 9 of 19
Questions 26-55 carry 2 Marks each. 26. Consider the following circuit A
A1
A2
The ammeter A1 reads 5 A and A2 reads 3 A. The reading of ammeter A is (a) 8 A (b) 0 A (c) 2 A (d) 5.83 A 27. Find the system gain, type and order for
Page 10 of 19
+ +
R(s )
G H H
+ _
C(s )
+ +
(a) (b) (c) (d) 29. Match the following, H(s): 1. 2. 3. 4. A : C
1/b
-1/b
(a) 1-A, 2-B, 3-C, 4-D (b) 1-B, 2-D, 3-A, 4-C (c) 1-D, 2-C, 3-A, 4-B (d) 1-A, 2-D, 3-B, 4-C GATECounsellor | E-mail id: queries@gatecounsellor.com
Page 11 of 19
(a) YBUS = [20- 36.87] (b) YBUS (c) YBUS (d) YBUS
20 53.13 20 126.87 20 126.87 20 53.13
31. The flux linkage between points P1 and P2 external to the conductor C (as shown in figure) will be given by : (a) 2 10 7 ln( (b) 2 10 7 ln( (c) 2 10 7 ln( (d) 2 10 7 ln(
D2 r ) D1 r
D2 ) D1 D2 r cos ) D1 r cos
D2 r sin ) D1 r sin
32. An LTI system is invertible if, hinv[n] is impulse response of inverse system of h[n].Where, hinv[n] is impulse response of inverse system of h[n]. (a) (b) (c) (d) GATECounsellor | E-mail id: queries@gatecounsellor.com
Page 12 of 19
Page 13 of 19
4 (a) Z11= 6 ohm, Z12= 2 ohm, Z21= 2ohm, Z22= 6 ohm (b) Z11= 12 ohm, Z12= 4 ohm,Z21= 2ohm, Z22= 12 ohm (c) Z11= 16 ohm, Z12= 4 ohm, Z21= 4ohm, Z22= 16 ohm (d) Z11= 12 ohm, Z12= 4 ohm, Z21= 2ohm, Z22= 16 ohm 39. In the given circuit find the locus of current I (rms value)with respect to the variation in the parameter Xc, and the centre of locus, if the applied voltage is V volts (rms). I V Xc C Locus of I A
,C ,C ,C ,C
(0,0)
R=0
Page 14 of 19
Page 15 of 19
1k
1k
1k 1k
Vi
Vo
Page 16 of 19
Page 17 of 19
Page 18 of 19
54. For this circuit, value of VCEQ& ICQ are, (a) 3.52V, 0.8mA (b) 6.75V,1.05mA (c) 3.52V, 1.05mA (d) 6.75V,0.8mA 55. For previous question, the input resistance and ac voltage gain V0/Vin is (a) 3.33K, -101.5 (b) 0.73K, -203 (c) 0.73K, -101.5 (d) 3.33K, -203 END OF QUESTION PAPER
Page 19 of 19