Professional Documents
Culture Documents
% computer fan can #e used to #uild a small prototype of the magnet motor. +ou can se the motor #efore disassem#ly (left) and after disassem#ly (right).
The picture on the left is showing the motor coils originally used to generate the magnetic field. We can replace the coils using the neodymium magnets. The magnets have to #e placed into the same directions, where the original coils were. This ensures that the magnetic field orientation, necessary for the motor operation, remains the same. In this motor, there are four coils, thus we need to use four magnets. -n the right picture you can see the hadr drive and the neodymium magnet you can salvage from it for free.
The magnets placed into the directions of the coils. The magnet motor running, needing no electric power. /ote( The coils don4t need the electric power any more. The can generate it) &ut remem#er, this is a very small unit, so only a little power can #e generated. In case you need only the wind from the fan, you can cut the ca#le.
%nother prototype of the magnet motor, with the magnets attached using a sticky tape, forming a porta#le unit.
The ilustration how the power e.tension cord can look like. It has several sockets. /ote the ma.imum power rating denoted on it. This power should never #e e.ceeded. ;owever, in some cases, the generated power limit of the free energy generator can #e lower due to the coil dimensions.
&eside the power e.tension plug, another necessary part of the free energy generator is the lighter. The image shows the comparison of the good and wrong lighters. The #lue one is the good one - the pie'o can #e salvaged from it. The orange one is the #ad one - it is the mechanical lighter, not electrical, and contains no pie'o. 0o remem#er, not every lighter is suita#le as a source of an initial energy)
Those photos illustrate the overunity generator #efore and after the ignition. I strongly recommend you to use the power strip with the indicator light in its switch. The light helps you determine Whether the generator is in active mode or in idle mode. %lso remem#er to turn on the switch #efore ignition. The ignition can take up to several cycles of the pie'o pulse.
Those two pictures are showing the detail of the pie'o and the free energy #eing started in dark. +ou can see the visi#le high voltage electric spark. %lso note that the pie'o, unlike the nonoverutiny elements, has only a single wire and no return wire.
<ast pair of the photos shows the electric loop free energy generator in loaded state. It can #e loaded even with a = kW heating unit)
to connect, #esides the <32 diode, some other electrical load to the solar cell output. Bnless the load is too #ig for the system, the device continues operating even with this load connected. The operation can #e stopped #y disconnecting the <32 (electrical shutdown method) or #y shading the panel (shadow shutdown method). 0hutting the device down #y shorting the solar panel output is not recommended, as it may lead to its damage. The system was tested with the cool white <32, #ut there4s still room to e.periment with other types of <32s, like warm-white <32s or color <32s. &efore doing anything, read the 2isclaimer first.
The e.ample of the non-working e.perimental setup with the incadescent light #ul#s.
The working setup with <32 - the e.ternal light source startup and shadow shutdown methods.
<32 - !hotovoltaic loop free energy overunity self running generator in operation.