You are on page 1of 2

ultrapoly PE

The prefilter for the removal of solid contaminants in gases with absolute retention efficiency.

Cross section of the ultrapoly prefilter

Product description: The ultrapoly prefilter contains the high porous, sintered polyethylene filter medium. Even finest dust particles and other contaminants in compressed air and gases are being removed effectively on the surface and in the depth of the filter medium. Applications: The ultrapoly prefilter is for example being utilised in the following industries Chemical industry Petrochemical industry Characteristics: By utilising various filtration mechanisms such as direct impact and sieve effect contaminants down to the size of 25 m particles, are being retained in the filter. Pharmaceutical industry Plastic industry General machine fabrication Food industry Beverage industry Process industry for instrumentation and control air

Technical alterations reserved (Date 1/99)

international AG Bssingstrae 1 D-42781 Haan Phone ++49/21 29/5 69-0 Fax ++49/21 29/ 5 69 -1 00

ultrapoly PE
Features: Permanent temperature range: 20C up to +80 C Void volume: porosity grade 45% Filter surface: 35 cm2 (02/05) up to 3100 cm2 (30/50) Removal of contaminants down to 25 m Regenerative Benefits: Broad application spectrum High dirt holding capacity; lower differential pressure Appropriate for any application and flow Guaranteed retention grade Economical, longer service life time

Technical data
Materials: Filter medium Bonding End caps 2 O-Ringe Pure, high molecular Polyethylene Epoxy resin Aluminium Perbunan silicon free and free of parting compound (standard)

Retention rate: 100% in gases (defined removal rates or particles related to the pore size)

Max. differential pressure: 2 bar at 20C, irrespective of system pressure

Initial differential pressure at nominal flow: PE Performance of PE elements compressed air Differential pressure [mbar] 120
m

0.03 bar

Element-Type 02/05 03/05 03/10 04/10 04/20 05/20 05/25 07/25 07/30 10/30 15/30 20/30 30/30 30/50

Correction Factor Filter Surface KF 0.04 0.08 0.12 0.17 0.19 0.25 0.32 0.47 0.68 1.0 1.55 2.10 3.28 5.89

100

80 Volume flow [Nm3/h]

60

40

20

0 0 5 10 15 20 25 30 35 40 45 50
These curves define the flow of a 10/30 filter element at standard conditions (1 bar abs; 20C; F. = 70%)
Technical alterations reserved (Date 1/99)

international AG Bssingstrae 1 D-42781 Haan Phone ++49/21 29/5 69-0 Fax ++49/21 29/ 5 69 -1 00

25

You might also like