You are on page 1of 2

ANNA UNIVERSITY : CHENNAI 600 025 B.E/B.

.Tech Degree Examinations, Oct-Nov-2012 EE2207- ELECTRON DEVICES AND CIRCUITS LABORATORY (Common to B.E., (EEE, E&I, I&C)) Regulations - 2008 Time: 3 Hours Maximum Marks: 100

a b

Choose a suitable two terminal unijunction device and obtain the characteristic curve. Find the static and dynamic resistance. Construct a suitable series circuit with the basic components resistor, inductor and capacitor. Find resonance frequency. Conduct a suitable experiment and obtain the regulated output. Find the forward and reverse resistance. Construct a suitable parallel circuit with the basic components resistor, inductor and capacitor. Find resonance frequency.

50 50 50 50 100 100 100 100 100 100 100 50 50

a b

3 4 5 6 7 8 9

Construct a suitable circuit using current controlled device used as an amplifier and plot its characteristic curve. Find its parameters. Construct a suitable circuit using current controlled device used for high frequency application and plot its characteristic curve. Find its parameters. Construct a suitable circuit using voltage controlled device and plot its characteristic curve. Find its parameters. Choose a suitable device used as relaxation oscillator and plot its characteristic curve. Construct a suitable circuit and plot the bi-directional characteristic curve of D3202. Construct a suitable circuit with three junctions four layer controlled rectifier and plot its characteristic curve. Choose a suitable device used for bidirectional phase control and plot its response. Conduct a suitable experiment and plot the characteristics of opto electronic devices. Construct a suitable circuit which allows the frequency above 1.5KHz.

10 a b

11 Construct a suitable circuit to reduce the ripple content during positive half cycle. 12 Construct a suitable circuit to reduce the ripple content of AC input. 13 Conduct a suitable experiment to amplify the difference in voltage and find the gain 14 Find the unknown frequency and phase angle of sinusoidal signals. 15 Construct a suitable series and parallel circuit with the basic components resistor, inductor and capacitor. Find resonance frequency. 16 a suitable circuit which allows the frequency above and below cut-off (1KHz). 17 a b 18 a b Conduct a suitable experiment and plot the characteristics of opto electronic devices Conduct a suitable experiment to measure the temperature in terms of resistance Choose a suitable two terminal injunctions device and obtain the characteristic curve. Find the static and dynamic resistance Construct a suitable circuit which allows the frequency below 1.5 KHz.

100 100 100 100 100 100 50 50 50 50 100 100

19 Construct a suitable circuit to reduce the ripple content to 1.21 20 Construct a suitable circuit to reduce the ripple content to 0.48

You might also like