Professional Documents
Culture Documents
PET1030/PET1035
All version
Service Manual
TABLE OF CONTENTS
Chapter
Technical Specification & Service Tips.... 1 Safety Instructions.. 2 Instruction for Use 3 Mechanical Instructions. 4 Troubleshooting 5 Overall Block Diagram. 6 Overall Wiring Diagram7 Electrical Diagram 8 Component Layout. 9 Service Part List 10 Revision List. 11
Copyright 2005 Philips Consumer Electronics B.V. Eindhoven, The Netherlands All rights reserved. No part of this publication may by reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronics, mechanical, photocopying, or otherwise without the prior permission of Philips
Version 1.3
will need to be exchanged with a new units of production serial number of the followings or onwards. PET1030/00 LL1B0725008507 PET1030/37 LL1A0724006785 PET1030/05 LL1B0724001007 PET1030/58 LL1A0724002110 PET1030/98 LL1A0724000305 PET1030/93 LL1A0728000506 EXCHANGED SETS NEED TO BE COLLECTED FOR FURTHER NOTICE. ADDITIONAL INSTRUCTIONS WILL BE GIVEN BY THE NATIONAL SERVICE ORGANIZATION SHORTLY! Take care that these sets are claimed with IRIS repair code Z6 IRIS code: X XXX X Z6
General
Dimensions (W x H x D): Weight: Power supply: Power consumption: Operating temp. & RH: Laser wavelength: Video system Dynamic range: Signal/Noise ratio: Frequency response Channel Separation 1kHz Channel Balance 1kHz Audio out (analog audio) Load impedance: Video out Output level Load impedance 204 x 168 x 33 mm 1.0kg DC 9V 1.8A 20W 0 - 50 degC / 30 90% RH 650nm NTSC / PAL / AUTO >/=80dB >/=85dB 20Hz-20kHz +/-1dB >/=85dB 1dB Output level: 2V +/- 10% 10Kohm 1Vp p +/- 20% 75ohm
DVD, Picture-CD, SVCD, Video CD, MP3CD, CD-R/CD-RW, WMA-CD, DVD-R, DVDRW, DVD+R, DVD+RW
Disc Diameter
Pixel specification
Current consumption
DC-IN SUPPLY (9V) Battery Charging Current 1.2A typical BATT. SUPPLY (7.2V) Power Off 0A Playback with TFT on <1.2A typical Playback without TFT on <600mA Battery time (playback) >2.5 hour
Maximum output power: Frequency response: SNR (A-wght): THD (0.2-20kHz): Left-Right Channel Separation: Left-Right Channel Balance:
Factory Service Mode (FSM) Procedure to check the software version of your portable DVD Player
1. 2. 3. Press [SETUP] to enter the setup Meun Press [RETURN] and then press 1 -> 2 -> 3 by remote control The display will show the software version as the date of which the software was built on the bottom of the screen.
Procedure to upgrade the software of your portable DVD Portable For the best performance of your DVD Portable. Check www.philips.com/support for latest software upgrades available.
1. 2. 3. 4. Download the latest software from the Philips support site Unzip the files and then burn it into a CD-ROM to make a disc for upgrade Power on the Portable DVD Player with AC/DC adaptor Play CD-ROM for firmware upgrade
7.
Region code 0 can be used for all regions! 8. 9. Press [SETUP] to save and exit your setting Power off and power on again to verify if region code change is done
Warning: Do not unplug the AC adaptor during firmware upgrade to prevent flash corrupt of the set!! 5. 6. Once upgrade is completed, the player is reset automatically Open the DVD door to remove the disc
Remarks: 1. Password is CONFIDENTIAL 2. Region code is printed on product type plate. Due to DVD legislation region codes different to assigned region may not be released
ESD
NL
WAARSCHUWING
All ICs and many other semi-conductors are susceptible to electrostatic discharges (ESD). Careless handling during repair can reduce life drastically. When repairing, make sure that you are connected with the same potential as the mass of the set via a wrist wrap with resistance. Keep components and tools also at this potential.
Alle ICs en vele andere halfgeleiders zijn gevoelig voor electrostatische ontladingen (ESD). Onzorgvuldig behandelen tijdens reparatie kan de levensduur drastisch doen verminderen. Zorg ervoor dat u tijdens reparatie via een polsband met weerstand verbonden bent met hetzelfde potentiaal als de massa van het apparaat. Houd componenten en hulpmiddelen ook op ditzelfde potentiaal.
ATTENTION
I
Tous les IC et beaucoup dautres semi-conducteurs sont sensibles aux dcharges statiques (ESD). Leur longvit pourrait tre considrablement courte par le fait quaucune prcaution nest prise leur manipulation. Lors de rparations, sassurer de bien tre reli au mme potentiel que la masse de lappareil et enfiler le bracelet serti dune rsistance de scurit. Veiller ce que les composants ainsi que les outils que lon utilise soient galement ce potentiel.
AVVERTIMENTO
WARNUNG Tutti IC e parecchi semi-conduttori sono sensibili alle scariche statiche (ESD). La loro longevit potrebbe essere fortemente ridatta in caso di non osservazione della pi grande cauzione alla loro manipolazione. Durante le riparazioni occorre quindi essere collegato allo stesso potenziale che quello della massa dellapparecchio tramite un braccialetto a resistenza. Assicurarsi che i componenti e anche gli utensili con quali si lavora siano anche a questo potenziale.
Alle ICs und viele andere Halbleiter sind empfindlich gegenber elektrostatischen Entladungen (ESD). Unsorgfltige Behandlung im Reparaturfall kan die Lebensdauer drastisch reduzieren. Veranlassen Sie, dass Sie im Reparaturfall ber ein Pulsarmband mit Widerstand verbunden sind mit dem gleichen Potential wie die Masse des Gertes. Bauteile und Hilfsmittel auch auf dieses gleiche Potential halten.
GB
Safety regulations require that the set be restored to its original condition and that parts which are identical with those specified, be used. Pour votre scurit, ces documents doivent tre utiliss par des spcialistes agrs, seuls habilits rparer votre appareil en panne.
NL
Veiligheidsbepalingen vereisen, dat het apparaat bij reparatie in zijn oorspronkelijke toestand wordt teruggebracht en dat onderdelen, identiek aan de gespecificeerde, worden toegepast.
F
Les normes de scurit exigent que lappareil soit remis ltat dorigine et que soient utiliss les pices de rechange identiques celles spcifies.
GB
Warning !
D
Bei jeder Reparatur sind die geltenden Sicherheitsvorschriften zu beachten. Der Original zustand des Gerts darf nicht verndert werden; fr Reparaturen sind Original-Ersatzteile zu verwenden.
Varning !
SF Varoitus !
I
Le norme di sicurezza esigono che lapparecchio venga rimesso nelle condizioni originali e che siano utilizzati i pezzi di ricambio identici a quelli specificati.
Avatussa laitteessa ja suojalukituksen ohitettaessa olet alttiina nkymttmlle laseristeilylle. l katso steeseen!
DK Advarse !
"After servicing and before returning set to customer perform a leakage current measurement test from all exposed metal parts to earth ground to assure no shock hazard exist. The leakage current must not exceed 0.5mA."
Usynlig laserstrling ved bning nr sikkerhedsafbrydere er ude af funktion. Undg udsaettelse for strling.
When the power supply is being turned on, you may not remove this laser cautions label. If it removes, radiation of laser may be received.
PREPARATION OF SERVICING
Pickup Head consists of a laser diode that is very susceptible to external static electrocity. Although it operates properly after replacement, if it was subject to electrostatic discharge during replacement, its life might be shortened. When replacing, use a conductive mat, soldering iron with ground wire,etc. to protect the laser diode form damage by static electricity. And also, the LSI and IC are same as above.
Ground conductive wrist strap for body.
AC VOLTMETER
(5000 per volt or more sensitivity) Good earth ground such as a water pipe, conduit, etc.
1500 10W
AC OUTLET
0.15uF 150V AC
Test all exposed metal. Voltmeter Hook-up for Leakage Current Check
The lightning flash with arrowhead symbol, within an equilateral triangle, is intended to alert the user to the presence of uninsulated "dangerous voltage" within the product's enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons. The exclamation point within an equilateral triangle is intended to alert the user to the presence of important operating and maintenance (servicing) instructions in the literature accompanying the appliance.
4 - VOL + Volume control. 5 SETUP Enter SETUP menu. 6 DISPLAY Adjust the display value of the system. 7 DISC MENU Display MUNE page. 8 , , , Up / down / left / right cursor. OK Confirm seletion.
1 2
5 6 7 8 9 10 11
12
13
9 OPTION Access additional functions. 10 CHR/IR/POWER Power /remote sensor /charging indicator. 11 OPEN Opens disc door to insert or remove disc.
14 15
CAUTION
Use of controls or adjustments or performance of procedures other than herein may result in hazardous radiation exposure or other unsafe operation.
16 17 18 19 20 21 22 23
REMOTE CONTROL
1 MENU Display MENU page. , , , 2 Up / down / left / right navigation key. OK Confirm seletion. VOL +/Volume control. 3 DISPLAY Adjust the display value of the system. 4 Skip to previous chapter, track or title. 5 Start / pause / resume playback 6 Access additional functions. 7 0-9 Numeric keypad. 8 9 SUBTITLE Subtitle language selector. RETURN For VCD menu page. 1 11
10 A - B To repeat or loop a sequence in a title. 11 SETUP Enter SETUP menu. 12 OPTION Access additional functions. 13 Skip to next chapter, track or title. 14 Mute player volume 15 AUDIO Audio language selector. 16 ZOOM Enlarge video image.
3 4 5 6
12 13
14
7 8 9 10 15 16
Fig.5 6. Disconnect DVD driver from board, then soldered short pattern for laser diode as Fig.6.
Fig.6 Fig.3 4. Open the door and remove screws to remove door & middle cabinet discreteness as Fig.4. 7. Remove screws to remove lithium battery and lithium battery protective pcb as Fig.7.
Fig.4
Fig.8
Fig.13
Fig.12
no
set OK?
yes
no
no
yes
go to other SYMPTOM
Check operation of the DVD drive. Does the DVD drive work? yes
no
start
Check if the LED on the front lights up? yes Check if the backlight is OK?
no
Repair connector
yes Open the top and bottom assembly to check the connector harness Is the connector harness broken? Remove the LCD cover and plate of the LCD unit to check the connector of the FL harness
no
no
no
yes
yes
no
Open the top and bottom assembly to check the connector to the main board
no
Remove the LCD cover and plate of the LCD unit to check the connection of the harness to the LCD unit
yes
no
start
Pick up lens does not light up at all Check the connectors of the DVD drive and main board? Pick up lens light up OK Not OK Secure the connection of the DVD drive and main board
OK
Insert a DVD disc and turn on the power The DVD drive works but the initializing operation of the optical pick-up lens does not start (the optical pick-up lens operates twice), or abnormal noise sound DVD drive does not work What is the reaction of the DVD drive?
The operation of the DVD player stops at initializing display. Is there any message shown on display
oading?displayed
HECK DISK?displayed
Nothing on display Does the image output stop during the operation? Is the DVD disc OK? no
yes
DVD disc OK
start
Install a good battery does the LED lights up orange while the AC adapter is connected and does the DVD drive operate OK? NOTE: - For this check, use a battery which is not fully charged (because the LED does not light when the battery is fully charged.) - Before this check, make sure other function work correctly. yes Replace battery
no Is the connection of the battery OK inside the DVD player? yes Secure the connection of the battery harness inside the DVD player
no
start
no
yes
64M SDRAM
HY57V641620ETP-7-C
DC 9V 74HCU04 27MHz
OSCILLATOR OZ9930GN
DV23 PU mechanism
RF AMP & SERVO & DVD PROCESSOR MPEG-2 DECODER & VIDEO ENCODER MT1389DE/P-L
+5V +3.3V +1.8V
TFT MONITOR
+5V
DRIVER (SA5954)
VIDEO IN
VIDEO OUT 110~240V 50/60Hz AC Adapter R AUDIO +/-5V AUDIO IN L AUDIO AMP (UTC4558E) TFT POWER +5V DC/DC +15V -10V +8V
AUDIO OUT
DC IN +9V
BATTERY
PHONE OUT
XS3
BATTERY
XS8 1 2 3 4 5 6 7 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6 BATT+ BATT+ BATT+ THM GND GND GND C B RFO CD/DVDSW A D GND F LD/VCC V20 E LD/CD GND LD/DVD NC VCC MD NC VRDVD VD/CD FT+ TF+ LIMIT GND SL+ SLSP+ SP1 2 3 4 5 6 7 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 1 2 3 4 5 6
1 POWER-DET 1 2 GND 2
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24
1 9V 2 9V 3 TFTON BRIGHTCON 4 5 GND 6 GND 7 SPL+ 8 SPL9 SPR10 SPR+ 11 GND 12 GND 13 +5V 14 +5V 15 ST1 16 IR 17 CPU3.3V 18 GND 19 STVR 20 CKV 21 SDA 22 SCL 23 KEYAD2 24 KEYAD1
SWITCH PCB
XS1
XS2
JS9
JP2
MAIN PCB
IF PCB
JP1
XS6
JP4
JP9 XS1
JP6
BLACKLIGHT PCB
XS001
GND GND PLANE PLANE PLANE HVOUT15 HVOUT14 HVOUT13 HVOUT12 HVOUT11 HVOUT10 HVOUT9 HVOUT8 HVOUT7 HVOUT6 HVOUT5 HVOUT4 HVOUT3 HVOUT2 HVOUT1
1 2 3 4 5 6
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1 2 3 4 5 6 7 8
XS001
1 2 3 4
1 2 3 4 5 6
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
VCOM GND VLC V11 V9 V7 V5 V3 V1 R/L B0 B1 B2 B3 B4 B5 OEH STHL 3V3P CLK GND REV NC G0 G1 G2 G3 G4 G5 GND
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
LCD
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
GND R0 R1 R2 R3 R4 R5 GND V2 V4 V6 V8 V10 VLC GND VCOM V/D V13 VGH V14 VGL V12 3V3P EDGSL GND STVR CKV OEV NC POL
30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
1 2 3 4
1 2 3 4 5 6 7 8
CN1
HV PCB
CB30 CB28 100N AVDD33_DMPLL C13 RFV18 10U/10V L26 601H DV33 L31 601H 100N V18 V1P4 100K
C14 10U/10V
20P
DV33 JITFO C10 C12 10U/10V C2 R7 10U/10V 390P 750K SW3 JITFN R8 10K TFTSW R9 10K
CB1 100N
15K
CVBSIN
L30 601H
R12
3 4
32 45 1
SW2
2 5 1
APLLVDD3 DACVDD3 C9 CB5 100N CB6 100N CB7 10U/10V ACVDD3 100N 10 R18 XTALI CB10 5P1 CB9 100N
1N
1500P
100N
SW1AF-360-T10 T
R-MAIN
L-MAIN
SPDIFOUT#
C19
T15
L4 601H
DV33
R-IN
33N
47N
47N
C138
C135
DV33
V18
DV33
CLOSESW
5 4
ACVDD3 LMAIN
RMAIN
RFVDD3
RFVDD3
51 42 3
1 2 3
10U/10V C16
AVDD33_ADC
CVBSIN AVDD33_VFE
RFVDD3
PLLVDD3
100N
RFV18
C18
C20
C23
STVL STVR
+P5V COAXIAL
U10
DVDA DVDB DVDC DVDD D A B C E F MD
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
256 255 254 253 252 251 250 249 248 247 246 245 244 243 242 241 240 239 238 237 236 235 234 233 232 231 230 229 228 227 226 225 224 223 222 221 220 219 218 217 216 215 214 213 212 211 210 209 208 207 206 205 204 203 202 201 200 199 198 197 196 195 194 193
C44 C31
L8 601H
AVDD3 IREF RFGC OSN OSP RFGND CRTPLP HRFZC RFRPAC RFRPDC RFVDD3 ADCVSS ADCVDD3 LPFOP LPFIN LPFIP LPFON PLLVDD3 PLLVSS JITFN JITFO XTALI XTALO RFVDD18 RFGND18 ADACVDD1 ADACVDD2 AL / SDATA2 / GPIO1 AVCM AR / SDATA0 / GPIO0 ADACVSS1 ADACVSS2 APLLVSS APLLCAP APLLVDD AVDD18_VPLL VPLL_TST AGND18_VPLL VFE_TSTP / AUDIO_IN1 VFE_TSTN / AUDIO_IN2 AGND_VFE CVBS_INP AVDD33_VFE CVBS_INN / BATTERY AVDD33_ADC AGND_ADC DVDD33_ADC DGND_ADC SPDIF / GPIO23 GGPIO12 (MCDATA) GPIO11 (ASDATA4) DVDD18 GPIO10 (ASDATA3) GPIO9 (ACLK) GPIO8 (ABCK) GPIO7 (ALRCK) DVDD33 GPIO6 (ASDATA2) GPIO5 (ASDATA1) GPIO4 (ASDATA0) VCOM / GPIO3 DACVDDC VREF FS
601H VD1
CB8 100N
C17 10U/10V
D1
V18
N2 FMC3
1 2 3 4 5
HSJ1456-010335 JS6
CB12 22P
3 2
STZ6.2N L14 R22 330 R24 100 RFO C43 NC C42 1uF
CB13
R21 SPDIFOUT 39
RFO
601H JP5 VD2 9V TFTON/OFF BRIGHTCON USB SPL+ SPL+ SPL- SPLSPR- SPRSPR+ SPR+ +5V ST1 ST1 IR IR CPU3.3V CPU3.3V STVL# STVR# CKV# U/D# OEV# STHL# 9V
100N
R55 100N 10K L17 CB146 C67 601H USBVCC C75 CB20 100N V2P8 + C26 10U/10V
3 4
PQ05DN01ZPH
24C02 VD4 R39 39K ISS355 DV33 R41 4K7 R42 4K7
NC NC
VIN
VOUT GND
CB147 10uF/16V 2 1
MS_CLK# MSBS# MSD0# MA4 MA5 MA6 MA7 MA8 MA9 MA11 CKE CLK# MA3 MA2 MA1 MA0 MA10 BA1# BA0# CS# RAS# CAS# WE# DQM1 SD_CMD# DQ8
10uF/16V 2 1
2 1 10uF/16V
SM24B-SURS-TF
2 1 10uF/16V
EN
en
R68
R151 C155
5.1K NC
DTC144 VD11 3 2
CB23 100N
CB24 100N
CB25 100N
CB26 100N
C41 10U/10V
CD/DVDSW
1
JP2
1 2 3
V18
CB32 100N CB33 100N CB34 100N
2
CLK# R0# R/L# R1# R2# R3# R4# R5# G0# G1# G2# G3# G4# G5# B0# B1# B2# B3# B4# B5# OEH# REV# POL# STHR#
DQML DQMH
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
SM24B-SURS-TF
TFTON/OFF
FMC3
DVDD33 IOWR# A16 HIGHA7 HIGHA6 HIGHA5 HIGHA4 HIGHA3 HIGHA2 HIGHA1 IOA20 IOCS# IOA1 IOOE# AD0 AD1 DVSS18 AD2 AD3 AD4 AD5 AD6 IOA21 / GPIO17 ALE AD7 DVSS33 A17 IOA0 DVDD18 UWR# URD# DVDD33 UP1_2 / GPIO19 UP1_3 / VSCK UP1_4 / VSTB UP1_5 / VSDA UP1_6 / SCL UP1_7 / SDA UP3_0 UP3_1 UP3_4 / RXD UP3_5 / TXD ICE PRST# IR GPIO22 / SD_DATA0 / INT0# DQM0 GPIO21 / SD_CLK RD7 RD6 RD5 RD4 RD3 DVDD33 RD2 RD1 RD0 RD15 RD14 RD13 RD12 RD11 RD10 RD9
TFTON
R45 10K
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128
MT1389P 1389P
DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15
1 14 27
2 4 5 7 8 10 11 13 42 44 45 47 48 50 51 53
3 9 43 49
6 12 46 52
DQ0 DQ1 DQ2 DQ3 DQ4 DQ5 DQ6 DQ7 DQ8 DQ9 DQ10 DQ11 DQ12 DQ13 DQ14 DQ15
DV33
TFTSW POWER_DET USB_DET CLOSESW SCL SDA TFTON/OFF BRIGHTCON# RXD TXD SDD0# DQM0 SD_CLK# DQ7 DQ6 DQ5 DQ4 DQ3
PWR# A16 A15 A14 A13 A12 A11 A10 A9 A20 PCE# A1 POE# D0 D1
DQ2 DQ1 DQ0 DQ15 DQ14 DQ13 DQ12 DQ11 DQ10 DQ9
D2 D3 D4 D5 D6 A21 STBY D7
UWR
64MSDRAM
A17 A0
CLK CKE
CS RAS CAS WE
XS3 53261-0890 PWR# PCE# VD6 STZ6.2N VD8 STZ6.2N VD9 STZ6.2N VD10 STZ6.2N
DQM0 15 DQM1 39
1 2 3 4 5 6 7 8 9 10
R51 33
23 24 25 26 29 30 31 32 33 34 22 35 20 21
38 37
36 40
N9
MA0 MA1 MA2 MA3 MA4 MA5 MA6 MA7 MA8 MA9 MA10 MA11 BA0 BA1
29 31 33 35 38 40 42 44 30 32 34 36 39 41 43 45 13 14 15 47
37
27 46
GND1 GND2
VCC
CS RAS CAS WE
CLK CKE
19 18 17 16
54 41 28
NC NC
CB39 100N
CB41 100N
RESET
8 7 6 5
RN2 33*4
1 2 3 4
OUT0 OUT1
DV33
8 7 6 5
RN4 33*4
1 2 3 4
A0 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20
CE OE WE
C38 1N
25 24 23 22 21 20 19 18 8 7 6 5 4 3 2 1 48 17 16 9 10
8 7 6 5
RN3 33*4
1 2 3 4
10 9 8 7 6 5 4 3 2 1
I1
A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12 A13 A14 A15 A16 A17 A18 A19 A20# A21#
12
1 1 2 3 4
R1# R/L# R2# R3# DRILL I7 XS7 53261-0890 OUT3 DRILL I8 L15 601H C77 10uF/16V RXD
R1 R/L R2 R3
8 7 6 5
RN5 33*4
0 0 0 0 0 0
1 1 2 3 4
R4# R5# G0# G1# DRILL I9
R4 R5 G0 G1
8 7 6 5
RN6 33*4
1
DRILL I4
1
UPDATET TXD
RXD
G2 G3 G4 G5
8 7 6 5
RN7 33*4
1 2 3 4
1
DRILL I2
DV33
TXD D7 74LCX373 T11
5 6 8 9 11 13 14 16 17 19
MS-GND MS-BS MS-D1 MS-D0 MS-D2 MS-INS MS-D3 MS-D3 MS-VCC MS-GND
SD-DTA2 SD-DAT3 SD-CMD SD-GND SD-VCC SD-CLK SD-GND SD-DAT0 SD-DAT1 SD-CD GND SD-CD
20 18 15 4 10 7 12 3 2 22 21 1 23
DV33
1
UPDATET
1
DRILL I3
1 2
1 2 3 4 5 6 7 8 9 10
20 19 18 17 16 15 14 13 12 11
20 19 18 17 16 15 14 13 12 11
R52 D5 D4 D7 D6
R70 T8
4K7
5V
SD-WP SD-WPGND 3
SD_CD
1 1
+P5V UPDATET T D0 D1 T3 GND UPDATET T4
1
T T9 VD50
GND
B0 B1 B2 B3
8 7 6 5
RN8 33*4
1 2 3 4
1
DRILL I10
3 4 5
R58
100
UWR
2SD601
1 1
T T D2 T5 D3
T6
1
T
1 1 2 3 4
B4# B5# OEH# REV# DRILL I5
HSJ1456-010335
DV33
SDD0 SDD1 SDD2 SDD3 SD_CMD SD_CD R63 R64 R65 R67 R59 R62 10K 10K 10K 10K 10K 10K
6 7 8 9
1
T
B4 B5 OEH REV
8 7 6 5
RN9 33*4
T7 T 1 100
1
DRILL I6
R90 10K/NC
R91 10K/NC
R93 10K/NC
R94 10K/NC
C47 10P/NC
1
T
10
POL STHR
8 7 6 5
RN10 33*4
1 2 3 4
POL# STHR#
1
DRILL
C49 20P
C50 20P
C52 20P
C53 20P
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26
1 3 2
OPO
STZ6.2N
1 2 3 4 5 6 7 8
HSJ1456-010335 JS7
R29
0 USBVCC R28
USBM VD12
1 3
R30 NC USB_DET STZ6.2N R56 0 USBP 10K
R40 680K
OPO OPOP+
AGND DVDA DVDB DVDC DVDD DVDRFIP MA MB MC MD SA SB SC / TNI SD / TPI MDI1 MDI2 LDO2 LDO1 SVDD3 CSO/RFOP RFLVL / RFON SGND V2REFO V20 VREFO FEO TEO TEZISLV OP_OUT OP_INN OP_INP DMO FMO TROPENPWM PWMOUT1 / V_ADIN0 TRO FOO AGND33_DMPLL AVDD33_DMPLL USB_DP USB_DM VDD33_USB VSS33_USB PAD_VRT VDD18_USB VSS18_USB USB_XTALO / GPIO15 USB_XTALI / GPIO14 DVDD33 DVDD18 FG / GPIO16 DVSS33 DVSS18 IOA22 / GPIO18 DVDD18 IOA2 IOA3 IOA4 IOA5 IOA6 IOA7 HIGHA0 IOA18 IOA19
G1 1M 27M R25
MT1389P
DACVSSC CVBS(Y) DACVDDB DACVSSB DACVDDA G DACVSSA B R HCK HSTR HSTL HOE LR DVSS18 VOE UD VCK DVDD18 VSTU VSTD GPIO100 DVDD33 GPIO101 GPIO102 GPIO103 SD_D3 SD_D2 SD_D1 MS_D3 MS_D2 MS_D1 DVDD18 MS_CLK MS_BS MS_D0 DVDD33 RA4 RA5 RA6 RA7 RA8 RA9 RA11 DVSS33 CKE RCLK DVDD33 RA3 RA2 DVDD18 RA1 RA0 RA10 BA1 BA0 RCS# RAS# CAS# RWE# DQM1 DVDD33 GPIO20 / SD_CMD RD8
192 191 190 189 188 187 186 185 184 183 182 181 180 179 178 177 176 175 174 173 172 171 170 169 168 167 166 165 164 163 162 161 160 159 158 157 156 155 154 153 152 151 150 149 148 147 146 145 144 143 142 141 140 139 138 137 136 135 134 133 132 131 130 129
7 6 5 4 3 2 1
7 6 5 4 3 2 1
8 9 10 11 12 13 14
8 9 10 11 12 13 14
74HCU04
CB16 CB17 CB18 R2 R3 R4 R5 G0 G1 G2 G3 G4 G5 B0 B1 B2 B3 B4 B5 OEH REV POL STHR N5 TZC03P-200A R33 4K7 R43 4K7 100N 100N 10U/10V
+P5V
RESET
A3 A2 A1 A0 4 3 2 1
C27 10U/16V XXU/16V
5 6 7 8
RXD
TXD
POWER_DET
STBY
V18
SDA SCL
IR RESET
1 3
C100
R-MAIN
47U/4V 47U/4V R161 100K
C107
R146 6K8
R156 3.9K
C123 47U/4V
R147 10K
4R7
-5V
2N7
C106 10U/10V
+P5V R140 100 A-L 47U/4V R160 1K C91 2.2U VD17 R167 10K R164 1K R
5 7
+
1 2
R141 1K
L-MAIN
C118 47U/4V R145 47U/4V 6K8 R157 100K N7 C111 2N7 R159 3.9K R142 10K
6
2SD601 BA4558 C96 390P MUTE
3 1 2
VD18 2SD601 CVBSIN
1
PWM_OUT VD43 ISS355 +P5V
1 2 3
5
R144 10K
2 3
4
CB148 22uF/16V 2 1
47K
1 3
VD40 DTC124 R168 10K VD45
+P5V VD47
AV_IN
ISS355 ISS355A C132 220U/6V R135 10 R136 1K L13 601H JS4
3 2
STZ6.2N VD24 3 STZ6.2N R-IN# R100 VD23 1K C64 2.2U R108 10K R-IN
1
LS1
PGND ROUTPVDD RHPIN RLINEIN RIN VDD LIN LLINEIN LHPIN PVDD LOUT-
ROUT+ SE/BTL HP/LINE VOLUME SEDIFF SEMAX AGND BYPASS FADE SHUTDOWN LOUT+ PGND GND
24 23
R171 10K R125 0 0 R126 R174 10K +P5V R162 R184 C86 470N 56K +P5V R185 100K 100K 510K VD42 AUDIO5V
4 3
53261-0290
2 1
SPRSPR+ R
2 3 4
R-IN
1 2 3 4 5 6
CK35-19(BLACK)
1 2
22 21
R169
1 3 2 3 2
L-IN# STZ6.2N
SPR+ SPRR-IN
5 6 7
20 19 18 17 16 15
C114220U/6V
C125
8
2.2U L-IN C126 2.2U AUDIO5V LS2 L-IN L
STZ6.2N
9 10 11
SPL-
14
R137 10 R117 0 R134 10K
4 3
2 1
12
13 25
L16 601H
5 4 3 6 2 1
HSJ1494-010110(CK35-17) JS5 VD44 R178 75 VIDEO# L20 0 R181 0 C130 NC
53261-0290
R139
R183 NC
VD25
1 3 2
STZ6.2N
1K +P5V
R132
1 3 2 3
C127 NC
A-R
1 2
VD46 2SD601
STZ6.2N
CK35-19(BLACK) VOUT
STZ6.2N
1 3 1 3 2
VD31 A-L
2
VD28
SPL-
STZ6.2N
1 2 3 4 5 6
JS8
AV_OUT
1
T T1
1
T T2
1
T
+P5V
L27 601 DV33 L32 CB49 C146 100N 10U/10V L23 601 C175 10U/16V + C170 1N C187 10U/10V + C189 10N L24 601 C174 100P CB46 100N RF3V3
C179 1N
C177 10U/10V
C165 100P
601
VD49 KTA1298
R192
4R7
LDO1
L25
1 2
C178 + 10U/16V
N16
XS5
F+ TT+ FVR/CD VR/DVD NC MD VCC NC LD/DVD GND LD/CD E V20 LD/VCC F GND D A CD/DVDSW RF B C GND GND
FPL0.5B-SMT-24
24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 25 26
F+ TT+ FVR/CD VR/DVD MD C183 LD/DVD LD/CD V20 R194 R195 R198 D# A# RFO R197 C180 0 0 0 0 1U 1U<Implementation> 1U<Implementation> <Implementation> OP+ C145 2N2 CB62 100N R189 680K 1U
8 7 6 5
TC4W53
1 2 3 4
CD/DVDSW
E F
RFO
B# C#
C181 C182
5V5 FOO CB58 10U/10V CB52 10U/10V CB53 L29 100N 601 DRVCC CB59 CB57 100N CB56 100N 10U/10V C141 10U/10V #DMSO R214 10K R212 20K
C192 10U/10V
C142 330P
<Implementation>
N17 BA5888FP
R210 10K
1
C186 10U/10V CB61 100N FT R203 20K R204 10K C184 R205 150PF FT-
28 27
C162 330PF R190 <Implementation> C185 150PF R202 18K CB55 100N R191
2 3 4 5 6 7
20K FT+
26 25 24 23 22
TT+ TT-
20K <Implementation>
C158 DV33 15N R200 10K LIMIT SL+ SLSP+ SPR218 150K R219 150K
DRVCC
8 9 10 11
21 20 19 18 17 16 15
DRVCC
53261-0690
R215
12 13 14
1 2 3 4 5 6 7 8
XS6
R196
0R5
T+ T-
OP+
OP-
29 30
VSYS
9V
R443 2 100K
R442 2 330K
VFO
10uF/16V
7 8
VM
R445 2 100K
R444 2 390K
BAT+
Q401A AO4801
Q402A AO4801 1 7 8 JP6 2 1 2 3 4 5 6 7 8 9 L401 3 4.7uH rchi rchi 10uF/16V C32 10uF/16V C406 1 10uF/16V 10uF/16V 1 100 C410 1 2.2uF C415 10 2 R428 11 4 9 8 26 21 D5 25 18 24 16 14 5 15 R427 31 chg_on 33 100K LV ct REF 10uF/16V lv 1 C418 1 2 D404 B240A CB109 0.1uF 1 100uF/16V 1 R417 33K UPD6100-A6 C83 C33 10uF/16V en lx1 1 L28 2 4.7uH dr1 fb1 dr1 4 3 Q406B dr2 AO4801 1 C424 10uF/16V C48 0.1uF 1 fb2 VSYS 1SS355 CPU3.3V C51 10uF/10V DV33 3 4 VD22 PQ033DN01ZPH L7 VOUT GND 6 C085 100uF/16V EN CB144 10uF/16V 2 1 1 DV33 1 C66 10uF/16V C21 10uF/10V 2 601 TFT3.3V TFT3.3V CPU3.3V R421 THM ichp ichm DR3 15K LV 220N 2 C429 1 0.1uF 2 C433 1batt_in 0.1uF SDATA en 7 8 150 1 2 10uF/10V 0.1UF SCLK 6 C85 2 CPU3.3V L35 601H 1 CB86 EL 5 R499 100 1 RCH401 SL1TTE50LOF 2 1 INBAT EXTBAT POWER_DET EL SCLK SDATA
R434
T1A/125V
JS2 HEC3600-010110 2 LV-R0484 F1 2 1 451003 3 2 1 4 C60 C78 + C79 VFO SL1TTE50LOF RAD401 vrad 5 6
R437 33k
VD7 SMAJ16A 1
10 1 C408 2
10
R404
R405
BAT+
C68 C69
SM7B-SURS-TF BAT+ T10 1 T D4 MC9S08QG8 IR RESET R2 R3 SW SW 1 2 3 4 1 2 3 4 5 6 7 8 16 15 14 13 12 11 10 9 16 15 14 13 12 11 10 9 R71 KEYAD1 KEYAD2 10K IROUT PWM_OUT INBAT EXTBAT DVDIN T14 1 T PWM_OUT
CHG_ONB
batsw
27
ISS355 D410 D8 ISS355 D407 VFo ISS355 1M C80 1 1uF R432 1 CHG_ONB C435 1 10uF/16V C426 1 C414 10uF/16V 1 10uF/16V 23
U401
VAC
C428 2 1 0.1uF
HDR
ISET CELL
12
ISET
2.2uF
R411
33k
D401 B240A
hdr
POWER_DET
chigh 28 3
CHIGH ACAV LV
22
6 7 2 en 20 13
DR3 FB3 DR2 FB2 DR1 FB1 VSET CT REF CHG_ON GNDA
VM
R403 51K
R401 91k 3
C422
U404A +
R429 batsw R423 ST1 10K ST1 comp1 R424 1k comp2 R426 29 1k frq R441 1k Q404 2N7002 2 C419 1n 1 C420 1n 1 R498 C423 1n 1 2 2 4K7 32 0
V+
30 1 17 19
LM393 R438
CHG_ONB
VIN
VM
NC NC
3.8V
6 5
C24 0.1uF
V+
OUT V6 U404B
chg_on 3
fb1 2 R410 51K VSYS AO4801 dr2 R414 5.1K 8 7 C407 C405 0.1uF 1 R413 100K 0.1uF 1 1 L403 lx2 4.7uH Q406A 2 1 R420 12K
LM393 REF
THM
REF
N12 5V5
IN
GND
OUT
2 C136
2 1
BA05
C05 100uF/16V
CPU3V3
R111 a1599
1K
+P5V
R6
30K
N14
VD5
1K
BA05 L18 AO3401 Q403A 1 4.7uH lx3 D412 L38 100uH -5V 1 1 C74 10uF/16V 2 C76 100uF/16V
CMAX
C25 100uF/16V
GND
R430
0 S-GND LX2 1
C412 2
VD13 BAV99 3
C15
#-5V
-5V
B240A fb3
C28 10uF/16V
IN
OUT
10uF/16V
10uF/10V
C73
C131
10uF/16V
C147 10U/10V
100U/16V
10uF/16V
VD36 1 DTA124
IN
VD3
ISS355 ISS355A
+P5V
dr3
GND
VSYS
OUT
2 C137
VD15
10uF/16V
XS2 1 2 3 4 HV TFTON BRIGHT HV-GND F1 1.5A F C4 C2 C5 XS2 SM04B-SURS-TF R9 R1 R8 33 C12 R3 C3 1 C10 Q1 C4 2 3 4 N1 SST-CMP ISEN CT VSEN 8 7 6 5 8 7 6 G1 S1 S2 5 C2 G2 C1 R2 C9 R6 33 C8 C6 T6 HV C11 LV 3 SM02B-SURS-TF 4 K12 C17 D2
GND
D1
D1
D2
D2
N2 D3
R4 R5 C7 R7
VD1 1 R20 VD4 CB2 R18 R15 VD3 LED1 XS2 1 2 3 4 5V ST1 RMCIN 3.3V R19 VD2 LED1 R11 SM04B-SURS-TF R13 R16 CB5 R17 VD5 R14
XS2 D1
C13 R12
CB1 GND 4 3 1
HS0036B
9.0 COMPONENT LAYOUT PET1030 MAIN BOARD DIAGRAM (TOP) PET1030 MAIN BOARD DIAGRAM (BOTTOM)
9.0 COMPONENT LAYOUT PET1030K FOUNCTION BOARD DIAGRAM PET1030H HV BOARD DIAGRAM
9.0 COMPONENT LAYOUT PET1035M MAIN BOARD DIAGRAM (TOP) PET1035M MAIN BOARD DIAGRAM (BOTTOM)
9.0 COMPONENT LAYOUT PET1030EL BACKLIGHT BOARD DIAGRAM PET1035K FUNCTION BOARD DIAGRAM
Service 12NC
996510003962
Service Description
PET1030M MAIN PCB ASSY/00/05 PET1030M MAIN PCB ASSY/58 PET1030M MAIN PCB ASSY/98 PET1035M MAIN PCB ASSY/00 PET1030T IF PCB ASSY PET1030K FUNCTION PCB ASSY PET1030H HV PCB ASSY 24 PIN HARDNESS-180PF 20 PIN HARDNESS-2-PF (LE105) PET1030 LITHIUM BATTERY
Photo
Pos. No.
100
110 120
996510003965
130
5 6
996510001274 994000002241
141 142
PET1030 PET1035
996510003961
150
PET1030 PET1035
996510006526
155
PET1035
996510004978
160
10
PET1030 PET1035
996510005764
370
Mechanical Part List: No. CTN Service 12NC Service Description Photo Pos. No.
11
PET1030 PET1035
994000002163
200
12
PET1030 PET1035
996510004977
210
13
PET1030 PET1035
994000002165
YD1635-2 SPEAKER
220
14
PET1030 PET1035
996510003967
300
15
PET1030 PET1035
996510003968
310
16
PET1030 PET1035
996510003969
320
PET1030 17 PET1035
996510003970
996510005763
Mechanical Part List: No. CTN Service 12NC Service Description Photo Pos. No.
18
PET1030 PET1035
996510003972
340
19
PET1030 PET1035
996510003971
350
20
PET1030 PET1035
996510003973
360
21
996510006727
380
22
996510006728
390
Photo
Pos. No.
994000003946
23
PET1030/05
996510003966
PET1030/37
996510001403
PET1030/93
996500042048
ADPV26A AC POWER ADAPTOR/05 ADPV26A AC POWER ADAPTOR/37 ADPV26A AC POWER ADAPTOR/93 CAR CIGARETTE ADAPTER
ACADAPTOR
24
PET1030 PET1035
996510001124
CARADAPTOR
25
PET1030 PET1035
994000001912
AV CABLE
AVCABLE
26
PET1030 PET1035
994000002586
SCABLE
PET1030 27
996510001287
RC
PET1035
996510003009
28
PET1030 PET1035
996510001130
CARMOUNT