You are on page 1of 8

2012 T-1000S Operating manual

1T-1000S System features


132256 GraySupport software Gamma correction 2Support t!e rules an" special-s!ape" !an"le# 3Single-port outputcan support 20$% lig!ts $Off-line&S' (ar") control* play +ac, content store" in t!e S' car"# 5T-1000S store a ma-imum of 16 programscopy multiple files to t!e S' car" in or"er* after formatting t!e S' car" as ./0T1 format# 6T!e program must +e name" in or"ers # 2-# 30041#le"* 0141#le"* 0241#le"# 5(ompati+le wit! single line or "ou+le line c!ips#
6OT231# 7!en T-1000S controller less t!an 512 pi-els t!e frame rate can reac! 30fps# 7!en T-1000S control more t!an 512 pi-els t!e frame rate will slow "own automatically# 2# T-1000S must use t!e new software 8e"2"it 2012#

2Support c!ips3

(!ip mo"el

(ontrol mo"e for software

9i-els&:0 ;)

6ote

89'6%03*'505*1101*6<0 <* 6<12 89'%%06*89'%%0< T:1%03*T:1%0$*T:1%0 <*T:1%12

T-1000-6%03 T-1000-%%06 T-1000-T:

20$% pi-els 20$% pi-els 20$% pi-els T:1%0$ an" T:1%0< are "i=i"e" into !ig! an" low 20$% pi-els 20$% pi-els 20$% pi-els 1<03 an" 1<0< are "i=i"e" into !ig! an" low 20$% pi-els 150?512 pi-els 20$% pi-els 20$% pi-els 7S2%11 +e "i=i"e" into !ig! an" low 20$% pi-els @ pi-els 20$% pi-els 20$% pi-els S:16515 +e "i=i"e" into !ig! an" low 20$% pi-els 20$% pi-els 20$% pi-els (ompati+le wit! stan"ar" ':;512

T:1<03 T:1<0$ T:1 <0<T:1<12 >(S6<0<>(S6<12>( S500<>(S5<03 >(S1<03>(S1<0<>( S1<12 >(S3<03 ':;512

T-1000-T:1< T-1000>(S-32 T-1000>(S-256 T-1000>(S-102$ T-1000-':;

7S2%01*7S2%03 7S2%11

T-1000-7S T-10007S2%11

'S1%<

T-1000'S1%< T8S3001*T8S3002T8S T-1000-T8S 300% 9<%13 T-10009<%13 S:16515 T-1000S:16515 S:16516 AS0<01*AS0<02 AS0%15 T-1000S:16516 T-1000-0<01 T-1000-0%15

30ppearance picture

4 Definition of printing3 Definition of buttons3 Auttons KL S2T MN :O'2 OP S922'C OP S922''(5B G6' 5D5-2$B EF 9O72G EE 2GGOG S' S' (0G' JE Sa=e Settings H to sa=e current settings file an" t!e play+ac, spee" I (!ange programs Spee" up Spee" "own 9ress spee"C an" spee"- on t!e same time t!e program will play circularly#

C5B power input 9ower G6' input C5#5-2$B power input 9ower in"icator 2rror in"icator S' car" slot GS$%5 signal# A 0 G6' Signal 0 ? ':;C Signal A ? ':;Signal groun"

TT8 signalH2$5?spi signalI3 (8Q '0T G6' (loc, signal 'ata signal Signal groun"

6OT2 3 /or t!e TT8&S9R) signal* t!e controller signal groun" must connect to t!e 82' groun" "irectly#

5 :o"e of connection

1# 2# 3#

:ultiple T-1000S controllers can +e casca"e" toget!er an" wor, sync!ronous# T-1000S one TT8&S9R) signal an" one GS$%5 signal port outputcan control 20$% pi-elsS 7!en t!e c!ip for 82' is single line c!ip Tust wit! "ata* t!en Tust nee" to +e connecte" wit! '0T an" G6' of t!e controller# Rf t!e c!ip for 82' is "ou+le line c!ip wit! '0T an" (8Q* t!en nee" to +e connecte" wit! '0T* (8Q* an" G6' of t!e controller# Rf you nee" to use GS$%5 signal you nee" to connect controller 0 wit! 82' 0 &':;C)* controller A wit! 82' A&':;-)* 7!en you nee" to +uilt a new proTect t!e controller type for t!e software is 3 T-1000-R( mo"el#

$#

5#

6 6ame of t!e program3H T!e rule of !ow to name t!e programs3 I T!e name for 6O#2 controller3

.0041#le"1 --------- 6O#1 program for 6o#1 controller

.0141#le"1 --------- 6O#2 program for 6o#1 controller .0241#le"1 --------- 6O#3 program for 6o#1 controller UU .1541#le"1 --------- 6O#16 program for 6o#1 controller
T!e name for 6O#2 controller3

.0042#le"1 --------- 6O#1 program for 6o#2 controller .0142#le"1 --------- 6O#2 program for 6o#2 controller .0242#le"1 --------- 6O#3 program for 6o#2 controller UU .1542#le"1 --------- 6O#$ program for 6o#2 controller UUU
9R(3

5 Special parameters
Memory card type3S' car"Hsuggest using high-speed SD cardI

Capacity312%:A2GA Format3/0T Store file3@#le" Physical parameters3 7or,ing temperature 3-30V%5V 7or,ing =oltage3'(5B ? '(5#5-2$B 7or,ing power317 siWe38165mmX7%0mmXY30mm weig!t30#35QG signal port33pin connect port

0ttention 3
Before copy files to SD card The SD card must be formatted as FAT format

The SD card in controller can not be hot-swappable, plug the SD card every time, you must first disconnect the power supply 5 Trou+le s!ooting Zuestion 1 3 0fter power* t!e T-1000S 2GGOG in"icator !as +een flas!ing wit!out "isplay output answer 3 T!e 2GGOG in"icator !as +een flas!ing means t!e controller "i" not rea" t!e

car" correctly* possi+le pro+lems[ \S' car" is empty* wit! no effect file# ]T!e effect file in t!e S' car" an" t!e controller mo"el are not matc!* please c!oose correct controller mo"el in 8e"2"it an" t!en re-create t!e effect file @le"# ^S' car" "i" not format to /0T +efore copy effect files# _9lease c!ec, t!e supply power =oltage* t!e controller can +e in"i=i"ually powere" to e-clu"e power reasons `(!anging t!e S' car" an" t!en test to e-clu"e t!e possi+ility of a +a" S' car" Zuestion 2[ T!e controller is powere" on* t!e in"icator is normal* +ut no effect c!ange in lig!ting 0nswer[ T!e reasons for t!is are as follows[ \ (!ec, if t!e lig!tingas signal line an" t!e controller connecte" correctly ] Rf t!e TT8 signal is recei=e"* t!e lamp an" t!e controller must +e common groun"* t!at means connect t!e lig!tingas an" t!e controlleras groun" toget!er

^ (!ec, if t!e mo"el c!ose "uring ma,ing "isplay files on t!e S' car" matc! t!e c!ips use" in t!e lig!ting

You might also like